Check Engine light on due to lower radiator blind jammed and closed. BMW has extended car warranty for this fault for various other models produced 2020 and beyond for up to 150,000 miles, under si B01 03 25 and si B01 12 19 However They do not cover my car, 2020 BMW 530e which has 78,000 miles where most of their 5 series and 3 series are covered under extended warranty for this exact problem for 150000 miles or 15 years. This is an emission part and jamming of flaps put at tremendous risk of car catching fire while driving due to heat. They must cover all their car for this manufacturing defect including 530e models.
Electrical system
BMW 530E Electrical problems by year
8 complaints filed with NHTSA about the BMW 530E's electrical system. Dead batteries, warning lights, wiring, alternators, infotainment and electronic module failures.
Electrical complaints by model year
Latest 530E electrical complaints
The contact owns a 2019 BMW 530E. The contact received notification of NHTSA Campaign Number: 26V441000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The contact had not experience a failure.
The contact owns a 2020 BMW 530E. The contact stated while driving at an undisclosed speed, the check engine and starter failure warning lights illuminated. The dealer was made aware of the failure. The contact was informed that parts were unavailable to repair the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact later received notification of NHTSA Campaign Number: 26V441000 (Electrical System); however, the part to do the recall repair was unavailable. The manufacturer was made aware of the failure. The contact was informed that parts were not available. The failure mileage was approximately 107,000.
Dear NTSB Team, I am writing to formally report a serious safety incident involving my 2019 BMW 530E, which occurred last night on [[redacted]] in Danville, CA. My vehicle was parked in my friend's private driveway, with the parking brake engaged and the gear selector set to Park. I was chatting with my friend who was in the passenger seat . My feet were on the floorboard, my seat belt was on and the engine was idling to provide heat as it was a cold night. Suddenly, about 10 minutes into our conversation, my...
Read the full complaint
car accelerated forward with speed, hit my friend's garage door and then reversed with the same speed and stopped in the middle of the street. This happened within the span of a few seconds at most. I think that I applied the brakes while the car was reversing with speed and I remember the car not slowing down but then it coming to an abrupt stop in the middle of the street. There were deep skid marks on the driveway, my friend's garage door was damaged, my friend's Tesla X was damaged with impact to the rear bumper, this parked Tesla had moved forward and crashed in the wall of the garage and a garage cabinet door dislodged and fell on the hood of this Tesla. My friends parked Toyota Prius also had bumper damage. The garage drywall sustained cracks as well. The force from these unexpected accelerations and impact has left me and my friend with aches and pains in the back, shoulder, knees, hands, head and neck; thankfully, we did not suffer more severe injuries. I am gravely concerned about the potential for this defect to cause a catastrophic accident. Had there been pedestrians, pets or another vehicle in the path of my rapidly reversing vehicle, it could have led to serious injuries or even fatalities. I called my car insurance company, local police and I will notify the Department of Motor Vehicles (DMV) and BMW of North America. I am hoping for a comprehensive investigation into what appears to be a dangerous electronic or software malfunction. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
My family was driving home on California [[redacted]] approaching [[redacted]]. Suddenly we saw heavy white smoke coming from our vehicle. Vehicles behind us had to almost stop as the smoke was very thick and covered all lanes. We pulled over and turned off the car. I started checking the control panel for any issues or alerts and found none. We never received any indication of issues in the control panel or dashboard. My husband got out of the car and inspected the tires which were all ok. He opened the hood and...
Read the full complaint
immediately saw flames from the center bottom of the hood. We all got out of the vehicle immediately and called 911. California Highway Patrol arrived and soon after Cal Fire arrived. Within 10 minutes my car was engulfed in flames and only the trunk area was sparred. I believe this was a malfunction or defect in the battery or electrical as we did not get any warning of engine issues or overheating. There have been several recalls on this model for battery defects which can lead to fire. My family's safety was put at risk as these batteries are highly combustible and could have exploded with us in the car. We had no warning whatsoever to immediately get out of the car and we were sitting there for at least 5-8 minutes trying to figure out what the issue was and who to call. I don't know at what point the car locked itself as the firemen had to use the jaws of life to open a door for the VIN. What if the car would have locked when we were still inside. I filed a claim with my insurance and they are deeming it a total loss based on the photos. I contacted the BMW service center and they said they can't do anything and I have to go through the insurance to have the car inspected. I asked if BMW will be sending someone to determine the cause and the rep said no. I sense that BMW does not want to do a thorough inspection of what caused the fire as the vehicle is still under manufacturer warranty and they would have to replace the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2019 BMW 530E. The contact stated that while her uncle was driving approximately 65 MPH, the instrument panel display became inoperable. During the failure, the speedometer was inoperable. The contact stated that the failure occurred on several occasions. The vehicle was taken to the local dealer however, the mechanic found no failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 30,000.
Serious crash from sudden unintended acceleration occurred yesterday where throttle seemed to be stuck in all gears and brakes didn't work
Car was parked/stationary with the emergency brake on and engaged, car was locked and no-one was near or in the vehicle, the car rolled into a car parked directly in front of it. Further, while in the car and after engaging the car in reverse to park in a parking spot, then shifting into drive (to straighten or pull the car forward the car continued to aggressively roll backwards. This happened on at least 3 separate occasions. Further, the car was parked/stationary and doors locked with no-one in the car and...
Read the full complaint
the windows on the passenger side both front and rear (on 2 separate occasions) opened all the way, on their own. Further, the brakes on the car squeal loudly upon stepping on the brakes.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked daily. Complaints are owners' own reports and are not verified. How we use the data