Engine & cooling

Hyundai Azera Engine problems by year

85 complaints filed with NHTSA about the Hyundai Azera's engine & cooling. Stalling, loss of power, oil consumption, overheating, head gaskets, timing chains and engine failure.

Engine complaints by model year

2005 2006 2007 2008 2009 2010 2011 2012 202013 2014 2015 2016 2017

Year	Engine complaints	Crashes	Injuries
2017	1	0	0
2016	3	0	0
2015	2	0	0
2014	8	0	0
2013	20	0	2
2012	11	0	0
2011	7	0	0
2010	2	0	0
2009	6	2	0
2008	8	0	0
2007	4	0	0
2006	13	0	0

Latest Azera engine complaints

2016 Hyundai Azera Engine & cooling

Hello, my car was parked at home and as I turned the engine on, I noticed the red light 'oil pressure' on the dashboard. I checked the oil level and it was very low. On the same day I purchases 2 quarts of oil to keep it at a safe level. The next day I checked the dip stick again and much oil was loss. I was very concerned and finally was able to make an appointment to my mechanic shop for inspection which led to an appointment for a fix on 3/6/2025. The problem was a defective OEM oil pressure switch. This...

Read the full complaint

warranty of the oil pressure switch is covered by KIA under WTY026 Warranty Extension for 15 years/150000 miles for the same 3.3L GDI engine as my 2016 Hyundai Azera. Since Hyundai is the parent company of Kia I feel Hyundai should honor this warranty by reimburse me for the cost of bill.

2016 Hyundai Azera Engine & cooling

Engine overheating without Engine light or any other safety alerts until Engine finally failed

2015 Hyundai Azera Transmission & drivetrain Engine & cooling

Engine has a timing belt issue since 70,000 miles where it will rattle when it starts Transmission is going out BEFORE 100,000 miles

2016 Hyundai Azera Engine & cooling

The contact owns a 2016 Hyundai Azera. The contact stated that the heating system was inoperable. The vehicle was taken to two Goodyear Auto Repair Shops, where it was diagnosed with a head gasket leak. One of the Goodyear facilities replaced the thermostat and the radiator. The contact stated that while driving at 55 MPH, a message that the engine was overheating was displayed. The contact was able to pull over to the side of the road. The vehicle was towed to the dealer, where it was diagnosed that the head...

Read the full complaint

gasket was leaking because the head gasket bolts had melted. The dealer sent the vehicle to a machine shop, where the engine was repaired. Additionally, the contact stated that the vehicle was experiencing excessive oil consumption, and the contact noticed a burning odor coming from the vehicle and oil leaking underneath the vehicle. The manufacturer was notified of the failure and advised the contact to take the vehicle to the dealer for a diagnostic test, and the vehicle could be eligible for goodwill assistance. The vehicle was towed to the dealer, where it was being diagnosed. The vehicle was not yet repaired. The failure mileage was approximately 109,000.

2014 Hyundai Azera Engine & cooling

While driving at approximately 70MPH on the highway, my 2014 Hyundai Tucson Limited suddenly locked up with no warning lights, no noise and no prior symptoms. The engine completely seized, causing immediate loss of power. I was barely able to coast off the highway exit to a final stop on the feeder shoulder, in a desolate area. The vehicle has always been properly maintained and is in excellent condition. Upon research, I learned that Hyundai has known of internal engine defects caused by metallic debris left...

Read the full complaint

from manufacturing since 2010, which can cause bearing failure and engine seizure. My Tucson's failure matches the same pattern described in Hyundai's Theta II engine recall and warranty extension campaigns. This sudden failure created an extremely dangerous situation at highway speed and possibility of injury while being stranded on an open road. Many owners, myself included, were never properly notified of the risks. I am filing this report because this incident represents a serious safety defect and potential recurrence among similar vehicles that may not yet be covered by recall. I respectfully request that the National Highway Traffic Safety Administration investigate this issue and ensure Hyundai expands its recall and warranty coverage to include affected 2014 Hyundai Tucson Limited vehicles exhibiting this defect that was well-known to the Hyundai Corporation. Date of Incident: October 23,2025 in Houston Texas. Vehicle towed to Hyundai dealer which diagnosed Engine Seized and currently awaiting Warranty Extension Approval (TXXC/TXXI)

2013 Hyundai Azera Engine & cooling

Vehicle started having overheating issues around August 2024, took it to mechanics to get it looked at and tried various fixes, concluding in a blown head gasket. When I took my car to a third party mechanic to fix the head gasket they found that the head bolts of the cars engine had been pulled out of the threads and said that it was a manufacturing issue. Head gasket was fixed but the car was having the same issues due to the head bolts being loose. I've taken my vehicle to the nearest Hyundai Dealership and told...

Read the full complaint

them about the overheating and head bolts being pulled out of the threading. They ran their diagnosis and then charged $1000 for a thermometer change (which our third party mechanic had also done already) and a coolant flush, which did not fix the issue as the car would still overheating after pick up. After taking my vehicle back to the dealership they said it had a blown head gasket claiming over $14,000 dollars for an engine replacement. They failed to acknowledge the issue of head bolts being pulled of their threads which has become a common issue across their 3.3l v6 GDI Lambda II engines, as is documented by many online. The Hyundai 2017 Santa Fe which also uses the 3.3l v6 GDI Lambda II engine is currently getting an extended warranty for engine replacements for all models from 2013-2017. It's strange that Hyundai is only doing extended warranties/recalls for Santa Fe model cars when they have other vehicles, like my 2013 Hyundai Azera, that use the same 3.3l v6 GDI Lambda II engine that will have similar issues. All vehicles that use the 3.3l v6 GDI Lambda II engine should be getting recalled. Hyundai does not seem to want to take responsibility for their faulty engineering on this engine and lazily claim it to be a "blown head gasket" issue when the head bolts being pulled of the threads causes the vehicle to overheat is what is causing the blown head gasket in the first place. They dismiss it as a blown head gasket and don't look any further.

2012 Hyundai Azera Engine & cooling

The contact owns a 2012 Hyundai Azera. The contact stated while driving at approximately 35 MPH the vehicle was losing forward momentum. The contact stated that the vehicle stalled. The contact was able to coast to the side of the road. The low oil warning was illuminated. The contact had to leave the vehicle at the side of the road. The vehicle was not taken to a dealer or an independent mechanic. The vehicle was not diagnosed and was not repaired. The manufacturer was informed of the failure. The contact stated...

Read the full complaint

that before the failure, the vehicle was consuming oil at a rate requiring her to add one quart of oil weekly. The contact stated there was no evidence of a leak from the oil pan. The contact was also hearing an abnormal ticking noise coming from the engine compartment before the failure. The failure mileage was approximately 140,000.

2013 Hyundai Azera Engine & cooling

My Engines head bolts have been pulled out of the threads causing the engine to overheat

2017 Hyundai Azera Engine & cooling

See attached document for complaint.

2012 Hyundai Azera Transmission & drivetrain Engine & cooling

In 2023, Hyundai approved to pay for repairs of vehicles that suffer premature engine failures due to issues such as low oil, metal debris and/or fire in the engine. These issues were predominately found in the GDI engines in Kia and Hyundai vehicles. This suit failed to take into account the Hyundai Azera model and the 3.3 GDI engine. Same engine maker as the 2.2 and 2.4 models. My car stalled out in the middle of traffic with no warning lights for low oil or engine issues. The car was serviced previously with no...

Read the full complaint

coded issues noted accept excessive oil burning which was noted with all Hyundai models from the last decade. The GDI 3.3 has the most noted issues and is the most expensive to replace from the dealer. The engines are failing before the car is broken in the manufacture is making money on the replacement engines from customers who are still trying to pay the car off.

2013 Hyundai Azera Engine & cooling

[[redacted]] Bought a used 2013 Hyundai Azera. Since day 1 it has overheating issue. Within the first 2 wks of ownership, we replaced the radiator cap, thermostat, and had engine checked for leaks at Pep Boys. Replacing the water pump was next. On the night of [[redacted]] we replaced the water pump. Cranked engine and no leakage, so I decided to take my car home which was 45 minutes away. After driving for 15-20 minutes, the temp gauge was almost topped out, so I slowed down. I was approaching a gas station in a...

Read the full complaint

town halfway to home and decided I needed to pull in, but the car suddenly and steadily lost power. I had barely enough power to pull into a space away from door (I just knew it was bad and I didn't want car in the business's way). Car would not crank after being shut off for about 20 minutes. I called my husband and he brought a car hauler trailer to put it on. The vehicle was checked for leaks by PepBoys, but it is going for a reputable mechanic inspection soon as can be scheduled. So I had this car not even 30 days, paid cash for it (which I hope to recover) and mechanic friend of mine tells me it's a blown head gasket. From what I've read, it has the 3.3L Lambda engine causing issues for other model vehicles. Is there a recall? What options for replacement are there? Anyone can inspect the car at any time. It is just taking up a space in the apartment parking lot right now. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2012 Hyundai Azera Engine & cooling

My engine failed after only 104k miles. I took my car in to get an oil change and it had rod knock which randomly started when I had oil already in the engine. This was just a random failure because it was completely find the day before and then the next day it started when I knew i was going to put more oil in in just in case and it failed.

2014 Hyundai Azera Electrical system Brakes Engine & cooling

Received recalled letter in mail for car almost 9 months ago. Hyundai has yet to issue fix. 9 months to fix a potential life threatening issue is ridiculous. To top things off we are told to continue driving the car even though it will eventually explode into a fireball of a mess after enough brake fluid leaks into electrical components. We have a 9 month old baby and the Hyundai Azera is considered our "family car". Fix this asap! You're putting families in danger. Either fix or supply families with a loaner...

Read the full complaint

car. Additionally, the advice from the car company is to leave car outside to avoid your house catching on fire. We are told to keep cars outside knowing these specific cars are theft liabilities.

2008 Hyundai Azera Engine & cooling Electrical system

The contact owns a 2008 Hyundai Azera. The contact stated while driving 55 MPH, the battery charging warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the valve cover gasket was leaking onto the alternator, causing the alternator to fail. The mechanic replaced the valve cover gasket, the battery, and the alternator; however, the failure recurred. The vehicle was repaired for a second time; however, the failure persisted. The vehicle was taken back to an...

Read the full complaint

independent mechanic. The vehicle was not repaired. The contact stated that the failure recurred every 3 years. The contact related the failure to TSB Number: 21-01-047H-1. The dealer and the manufacturer were notified of the failure, but no assistance was provided. The failure mileage was approximately 99,000.

2014 Hyundai Azera Brakes Engine & cooling

The contact owns a 2014 Hyundai Azera. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the check engine warning light was illuminated. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 71,000. VIN tool confirms parts not available.

Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked daily. Complaints are owners' own reports and are not verified. How we use the data