Body, doors & structure

Jayco Greyhawk Body problems by year

5 complaints filed with NHTSA about the Jayco Greyhawk's body, doors & structure. Doors, hoods and latches, frame rust, sunroofs, leaks, trim and structural failures.

Body complaints by model year

'02 '03 '04 '05 '06 '07 '08 '09 '10 '11 '12 '13 1'14 '15 '16 '17 '18 '19 '20 '21 '22 '23 '26

Year	Body complaints	Crashes	Injuries	Recalls
2026	1	0	0	0
2020	1	0	0	0
2019	1	0	0	0
2017	1	0	0	0
2014	1	0	0	0

Latest Greyhawk body complaints

2020 Jayco Greyhawk Visibility & wipers Body, doors & structure

While driving down the road at about 45mph, the driver side upper cabin window located adjacent to the eating table exploded and blew into the cabin. The window shattered and glass blew throughout the cabin area. Whatever caused this, the blast was strong enough to pull the Velcro straps holding the seat cushions blown off and the glass ripped the cushion's vinyl. If someone had been sitting at the table, they would have been extremely cut and hurt and possibly blinded. I had no warning to this situation. At...

Read the full complaint

first, I thought someone had shot out the window, but I nor the RV repaired found no evidence. Vehicles were passing me and I assume a rock or some other item was picked up and blown into the window. I thought these windows would only shatter, but not blow in. Weather was sunny in the 70's.

2026 Jayco Greyhawk Equipment & accessories Body, doors & structure

After a recent purchase of a new 2026 Jayco Greyhawk 29MV RV, I discovered my 2 cats trying to enter a previously unknown and unfinished opening adjacent to a designated sleeping/play area of my RV in the cab overhead. One of the cats was panicked as he was stuck in the opening. The opening is very difficult to see unless you climb well forward into the sleeping area for closer examination which I did not do before my purchase. The area contains a very long area of sharp, unfinished and in some places splintered...

Read the full complaint

fiberglass edging that actually goes the entire distance around the window opening. Since this easily accessible area is intended for sleeping/playing, a curious child could attempt reaching into the area to retrieve a toy or a pet could enter it and get cut by the unfinished fiberglass or be unable to exit. Portions of the fiberglass are inward flexible which increases chances of an entry and then unable to exit. The area also has accessible loose insulation which further increases the safety hazard. My concern is that a child or pet getting inside and being unable to exit with getting severe cuts from the sharp fiberglass surface. I reported this to the dealer who then informed Jayco who agreed to pay the dealer a whole "0.5 hours" labor for the dealer to "figure out a fix" for the issue. Apparently this issue is in many different makes/models (per the local dealer) and I feel there should be a proper fix applied to all of the fleet rather than a local patch merely to appease just the one customer that found the issue. As a retired military Safety Manager who authored numerous safety messages for issues for Army aviation, I feel this should be investigated for a possible fleetwide safety recall. Based on my conversation with the local dealer, it seems Jayco does not intend to do any further work on the affected vehicles. See attached pictures.

2019 Jayco Greyhawk Body, doors & structure

Tl* the contact owns a 2019 jayco greyhawk rv. The contact stated the rear exit window latch was loose. The contact reached out white horse rv center located at 980 n black horse pike, williamstown, nj 08094, (856) 262-1717, and notified the dealer of the failure. The rv was not repaired. The manufacturer was informed of the failure. The failure mileage was 140,017. *Ln*jb

2017 Jayco Greyhawk Body, doors & structure

While driving to a casino parking lot I heard something scraping under the vehicle. I pulled over and looked under the coach where I discovered that the hydraulic system had dropped on the ground (see photo). An accident could have occurred if this had happened at highway speeds.*Dt*jb

2014 Jayco Greyhawk Body, doors & structure

Jayco installed residential carpet directly over the uninsulated floor if the ford e-450 cutaway chassis. When the unit is sitting in traffic in hot weather the carpet begins to melt and smoke. This is most acute at high ambient temperature with the unit moving at slow speed or if the unit has been driving up a long grade and then is stopped at a light or in traffic. Jayco redesigned the 2015 model year greyhawks to properly insulate the floor however there are thousands of units endangering the public on the...

Read the full complaint

road. Jayco did replace the affected carpet on my unit however, they replaced it with residential foam rubber not certified for use in an automotive cab. I paid out of pocket to have proper automotive grade insulation put down before the rebond residential pad was placed on the cab floor. *Tr

Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked daily. Complaints are owners' own reports and are not verified. How we use the data