Lincoln Aviator Phev Engine problems by year

the vehicle with this active safety defect caused severe fuel-management failures and misfires, forcing raw fuel into the exhaust system and completely melting the catalytic converter. The manufacturer is now refusing to cover the catalytic converter under the Federal Emissions Warranty, citing that the vehicle is slightly over 80,000 miles - even though the failure was explicitly documented by the dealer well before that threshold. The lack of a timely recall remedy has directly resulted in secondary vehicle damage, creating an unsafe operating condition and compromised emissions controls.

using my foot to control the speed. Additionally, the Bluetooth connection was not functioning, the Navigation screen nor map would even load, and I was unable to use cruise control due to an error message "cruise unavailable". We get a separate Lincoln Aviator for a loaner, and not only does reverse park assist not work, the rear camera doesn't function, either. These cars are dangerous and need to be recalled immediately and taken off the road. We plan to sell/trade ours as the soonest possibility and incur whatever financial burden that may come with it. It's not worth my family's safety, or that of someone else.

that the "vehicle is shutting down" and then poof, the [[redacted]] thing shut down immediately without warning. The message was on the HUD and NAV for about a second and a half and it died. Thankfully we were at surface street speeds of around 30-35 and I was in command of the vehicle. This issue has been reported on other GRAND TOURING models of the Lincoln Aviator where people are at higher speeds, such as the highway or expressway. That said, this is my wife's main vehicle and I am terrified, as well as she, to have her driving this at all hours of the day responding to emergencies at her hospital. PLEASE HELP US ALL that own this vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

shut off, we got out, locked the doors, plugged it in, and just allowed it a few minutes to reset. Notta. Got all this on video. I finally had to pop the hood and use the freaking 2021-2023 Explorer / Aviator Hybrid Vehicle Emergency Response Guide to kill 12v power to the thing. After all that, it allowed us to get in and drive normally. However just a few hours later... 2,600 miles on the odometer and we were driving approx 55mph and the Aviator engaged the parking brake for about half a second. Nasty noise, huge bucking from the chassis, and just a split second of extreme confusion and wondering WTF. The red "park brake" was illuminated on the dashboard, and everything seemed normal afterward. However, immediately after that incident it then disabled adaptive cruise control via a message on the dashboard (no cruise worked). We drove home without further incident, called the dealer, and they stated to call Lincoln Roadside Assistance, get it towed back to the dealer that it was just a few days ago, and they'll deliver a loaner to us. A few hours later, it's on the tow truck. This is the second time this vehicle has placed us in danger. The first issue I'll report after this is submitted. Thank you.

https://www.mustangecoboost.net/threads/i-think-i-figure-out-how-to-fix-the-full-accessory-power-active.22706/#:~:text=It%20means%20you%20have%20full,press%20the%20start%20button%20again. I did that and vehicle restarted. I made an appt with my local Lincoln dealer, Bill Collins Lincoln, and they inspected the car on 1-18 thru 1-21. They did not find anything wrong with it but did find the codes. They stated they thought the battery was dead. This was impossible due to the fact I drove the car 500 miles from Alabama to KY on 12-21. Today, 2-2-22, my wife was driving home from work and the car shut off on the interstate. When I say shut off, I mean it died at 65mph. She tried to press the accelerator and the car just continued to de-accelerate. The check engine light popped up and said "Stop Safely Now". Luckily, my wife was able pull off the interstate without causing an accident. Once stopped, she turned the vehicle off and tried to restarted it. It popped the same message about "full accessory power" and the car wouldn't start. She tried the push button start to no avail, tried the remote start to no avail. Finally she used her "phone as a key" and it started. She was able to drive home. I have called Lincoln and made them aware of the issues. They have asked for me to bring the car in immediately. I informed them I would be filing a complaint here as well. This car is a $85,000 death trap. Lincoln needs to take this very seriously and an investigation needs to open to find out why this vehicle is behaving like this. It is not safe to drive.

it has taken approximately 3 hours for a Lincoln approved tow truck to come and get the vehicle leaving me stranded in the freezing cold with multiple children and no heat in my vehicle. My speed has varied each time this has happened. One time I was in park, another time I was doing 60+MPH and the others were in-between these speeds. I have multiple videos of what happens and have provided them to Lincoln. Lincoln has replaced the battery and also the Powertrain Control Module and nether of these have corrected the problem.

https://www.mustangecoboost.net/threads/i-think-i-figure-out-how-to-fix-the-full-accessory-power-active.22706/#:~:text=It%20means%20you%20have%20full,press%20the%20start%20button%20again. I did that and vehicle restarted. I made an appt with my local Lincoln dealer, Bill Collins Lincoln, and they inspected the car on 1-18 thru 1-21. They did not find anything wrong with it but did find the codes. They stated they thought the battery was dead. This was impossible due to the fact I drove the car 500 miles from Alabama to KY on 12-21. Today, 2-2-22, my wife was driving home from work and the car shut off on the interstate. When I say shut off, I mean it died at 65mph. She tried to press the accelerator and the car just continued to de-accelerate. The check engine light popped up and said "Stop Safely Now". Luckily, my wife was able pull off the interstate without causing an accident. Once stopped, she turned the vehicle off and tried to restarted it. It popped the same message about "full accessory power" and the car wouldn't start. She tried the push button start to no avail, tried the remote start to no avail. Finally she used her "phone as a key" and it started. She was able to drive home. I have called Lincoln and made them aware of the issues. They have asked for me to bring the car in immediately. I informed them I would be filing a complaint here as well. This car is a $85,000 death trap. Lincoln needs to take this very seriously and an investigation needs to open to find out why this vehicle is behaving like this. It is not safe to drive.