My vehicle has active VANOS failure codes (131401 and 130304). These codes are preventing my car from passing the New York State safety and emissions inspection, rendering it legally unable to be used on the road. BMW/MINI Corporate is refusing to honor their national extended component warranty bulletin because they are conditioning the repair on a valid registration - which is a legal impossibility while the defect remains unaddressed.
Electrical system
Mini Convertible Electrical problems by year
6 complaints filed with NHTSA about the Mini Convertible's electrical system. Dead batteries, warning lights, wiring, alternators, infotainment and electronic module failures.
Electrical complaints by model year
Latest Convertible electrical complaints
While lowering the convertible top on my Mini Cooper Convertible, the trunk partition was not fully in place. Normally, the vehicle will prevent the roof from operating or provide a notification if the partition is not correctly positioned. In this case, the safety interlock system failed to warn me or stop the roof from lowering. While the roof was folding, the rear glass shattered, causing $6,000 in damage. The dealership confirmed that the rear parcel shelf was not fully in place and explained that the sensor...
Read the full complaint
only detects one side(in my case the trunk partition was in its place on one side ) , allowing the top to operate even when unsafe. They did not cover the damage under warranty. The vehicle was inspected by the authorized Mini Cooper dealership at the time of the incident. No police or independent inspections have been conducted. No warning lamps, messages, or alerts appeared, and the roof operated normally, giving no indication that the partition was not fully in place. The vehicle was only three months old. The shattered glass spread throughout the backseat and trunk area, creating a serious risk of injury to any passengers in the rear. Luckily no one was in the back at the time of the incident
The contact owns a 2017 Mini Cooper. The contact stated when the vehicle was started, the vertical aim headlights malfunctioned. The vehicle was taken to the dealer where it was confirmed that rodents had chewed through the insulation around and the electrical wires. The contact was informed that the insulation was made of soy, which attracted the rodents. The contact was informed that the electrical wires needed to be replaced. The vehicle was being repaired. In addition, the contact stated the repair had occurred...
Read the full complaint
previously and the current issue was the second occurrence. The manufacturer was made aware of the issue but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 55,000. The VIN was unavailable.
Digital instrument cluster of electric Mini SE (includes speedometer and battery/range information) turns off without warning while driving and does not turn back on until car is powered down for over half an hour. This has happened more than ten times. Vehicle was inspected by MINI dealer locally and no obvious equipment defect was identified, although they were able to replicate it happening. After disassembly and reassembly by dealer, issue stopped for about two weeks after car was returned to owner. Now it has...
Read the full complaint
begun again, to the point of turning off within a few minutes of driving every day, rendering car unusable as driver has no other speedometer in vehicle. After sitting for half an hour, the instrument cluster will turn on when the car is turned on next, only to go out again after a few minutes of driving. Other electronics in car do not appear affected and car operates normally.
After work, I started the car in a parking lot. Before leaving, a fire started under the hood behind the passenger side headlight. After using the jaws of life to take off the hood, the fire department contained the fire. No injuries. There was extensive damage to the right front. The contents were all smoke damaged. Neighboring cars were not damaged. The car has been totaled.
The night of October 24th, while I was driving my CID back screen went to black and there were messages displayed in white color. Bootloader 11.035.000/ FFW 1.8.3 Dec 5 2017 Next line is displayed HWEL:42E5 2.1.5 Followed by a large white bar This display stays on even after lock the car. The morning of October 25th, There are warnings came on " Battery discharged start engine" and "Increased Battery drain while stopped" After a while, I've noticed the instrument panel light were off. I had a day time running lights on, but lights weren't on, only the fog lights. And when I unlock and lock the doors, those lights weren't flushing. The morning of Oct 26th,my battery was dead.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked daily. Complaints are owners' own reports and are not verified. How we use the data