The contact owns a 2026 Mini Cooper. The contact stated that while driving approximately 65 MPH with the AC unit engaged, the driver's side window shattered. The contact stated that the window was not impacted to cause the window to shatter. The contact stated that the failure had occurred approximately 15 minutes after the AC unit had been engaged. The contact was able to drive to the nearest BMW dealer. The dealer did not diagnose the vehicle. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 6,255.
Electrical system
Mini Hardtop 2DR Electrical problems by year
6 complaints filed with NHTSA about the Mini Hardtop 2DR's electrical system. Dead batteries, warning lights, wiring, alternators, infotainment and electronic module failures.
Electrical complaints by model year
Latest Hardtop 2DR electrical complaints
Either closing the moonroof or the wipers activating caused the screen to flicker off and back on. Sustained usage or frequent usage caused the screen to completely deactivate for 10+ minutes and the Driver's HUD to deactivate and retract. During this time, the car was operating on the highway in rain conditions with zero driver's instrumentation, including speed, navigation, fuel, battery, safety warnings, blinkers, or other indicators. It was unclear if blind spot indicators or driving assistance features were...
Read the full complaint
impacted, or if vehicle lights were impacted as no indicators were present in the vehicle. This incident lead to driver anxiety, reduced situational awareness, reduced confidence in the vehicle's safety and operational capability, and reduced safety to other vehicles around the car as it could have led to changes in driver behavior or lane changes due to surprise at vehicle behavior. The problem has been reproduced by the dealership's service station, however the dealership has changed ownership recently and has lost some records. The car has been in dealer service for the past 70 days but the fault is still not understood or remedied. The dealership was made aware of this roughly 60 days ago and is resisting even replacing the vehicle, let alone understanding and remedying the quality issue.
Digital instrument cluster of electric Mini SE (includes speedometer and battery/range information) turns off without warning while driving and does not turn back on until car is powered down for over half an hour. This has happened more than ten times. Vehicle was inspected by MINI dealer locally and no obvious equipment defect was identified, although they were able to replicate it happening. After disassembly and reassembly by dealer, issue stopped for about two weeks after car was returned to owner. Now it has...
Read the full complaint
begun again, to the point of turning off within a few minutes of driving every day, rendering car unusable as driver has no other speedometer in vehicle. After sitting for half an hour, the instrument cluster will turn on when the car is turned on next, only to go out again after a few minutes of driving. Other electronics in car do not appear affected and car operates normally.
The vehicle was on a repair rack at P & W BMW Dealer for an issue with the battery on the electric vehicle and the battery went into thermal runaway causing the vehicle to be consumed in the fire and causing significant damage to the other vehicles and to the structure. I, Det Michael Burns with the Pittsburgh Police Fire Investigation Unit investigated the fire and can be contacted at 412-670-4282.
After work, I started the car in a parking lot. Before leaving, a fire started under the hood behind the passenger side headlight. After using the jaws of life to take off the hood, the fire department contained the fire. No injuries. There was extensive damage to the right front. The contents were all smoke damaged. Neighboring cars were not damaged. The car has been totaled.
The night of October 24th, while I was driving my CID back screen went to black and there were messages displayed in white color. Bootloader 11.035.000/ FFW 1.8.3 Dec 5 2017 Next line is displayed HWEL:42E5 2.1.5 Followed by a large white bar This display stays on even after lock the car. The morning of October 25th, There are warnings came on " Battery discharged start engine" and "Increased Battery drain while stopped" After a while, I've noticed the instrument panel light were off. I had a day time running lights on, but lights weren't on, only the fog lights. And when I unlock and lock the doors, those lights weren't flushing. The morning of Oct 26th,my battery was dead.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked daily. Complaints are owners' own reports and are not verified. How we use the data