Rexhall is recalling 36 my 2005 aerbus, american clipper, base camp, rexair, sanscape, and vision motor homes equipped with a two-door refrigerator manufactured by the dometic corporation. The refrigerator may have a defect in the boiler tube. Pressurized...
1994-2005 · 10 model years
Rexhall Rexair Problems by year
Owners have filed 4 complaints about the Rexhall Rexair across 10 model years, and it has 5 recalls. The 2005 has the most complaints once its age is allowed for (1). The most reported problem area is the wheels & tires, followed by the visibility & wipers.
- Complaints
- 4
- Recalls
- 5
- Crashes
- 0
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
Rexair complaints by model year
Highlighted: the year with the most complaints for its age. Older vehicles have had more time to collect complaints - the Safety Index grade allows for that.
Most common Rexair problems
Rexhall Rexair recalls 5
On certain motor homes equipped with a two-door refrigerator manufactured by the dometic corporation, the refrigerator may have a defect in the refrigerator boiler tube. Pressurized coolant solution could be released into an area where an ignition source...
Certain motor home chassis fail to comply with the requirements of federal motor vehicle safety standard no. 105, "Hydraulic and electric brake systems." The brake system warning indicator may not function as required by standard.
Vehicle description: motor homes. The drive shaft bolts can come loose at the transmission and fall off. When the drive shaft separates from the transmission, the forward end of the shaft can drop to the ground, or come through the floorboards of the...
The awnings for the slide-out room can unfurl or unroll during transit causing the bracket to rip free of the sidewall of the vehicle.
Latest Rexair complaints
Issues with the g159 made by goodyear. Have been reading about it online. If this is relevant to action being taken for recall. Please contact and I will provide further information. *Tt *tr
Brakes on 2005 rexhall rexair with 35,298 miles had brake system failure. Brake calipers seized causing damage to entire brake system. Brakes proved to have extremely overheated causing damage to rotors, pads and sensors. Also electrical cluster on steering wheel for reading gears and mileage information also failed and had to be replaced. Rexhall referred us to workhorse for reimbrusement. Workhorse refused to acknowledge a defect and indicated that our unit was out of warranty and therefore not covered by...
Read the full complaint
them. The failure of the brakes could have cause a major accident and possibly serious or fatal injuries to my family. We are not alone with this brake problem and workhorse needs to be held accountable and reimburse their customers for these failures. The cost to us was $5,284.91 But could have been much higher had death occured from these failures. Please hellp us recoup this repair and advise other rv owners of these defects. *Tr
We were traveling on rte 95 in maine traveling at approximately 65 mph when we heard a loud "wind" sound. We exited the highway and noted the windshield at the top center was caving in. We supported the windshield from behind with paper towel roll's and the back of the upper compartment's and continued to cohackie new york to where we had purchased the rv. They made a temporary repair to get us to florida where we were heading to meet a delivery truck at our new home there. Along the trip, the temporary repair had...
Read the full complaint
failed, and we had resorted to holding the windshield in-place with roll's of paper towels. We brought the rv to a dealer in fort myers fla. And they made there own "design" to repair the windshield. This repair has worked and is still holding. We are familiar with at least one other rexhall that has the same problem, and a rexhall serviceman said it was not a uncommon problem. Had we not taken the aforementioned action's and continued to drive on I believe a castrophobic accident most likely would have happened.
PLEASE ADD MORE DETAIL. MICHELIN SIZE 235/8516E . MR
Questions about the Rexhall Rexair
Which Rexhall Rexair years have the most problems?
Which Rexhall Rexair years have the fewest complaints?
What are the most common Rexhall Rexair problems?
Across every model year, owners report problems with the wheels & tires (2), visibility & wipers (1), brakes (1) most often.
How many recalls does the Rexhall Rexair have?
NHTSA lists 5 recalls across all Rexhall Rexair model years. Each year's page lists the recalls for that year; check your own vehicle by VIN at nhtsa.gov/recalls to see whether the repair has been done.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked daily. Complaints are owners' own reports and are not verified. How we use the data