Under Recall 19N4, the electric coolant pump was replaced in July 2019 at 73,496 miles. That replacement pump failed prematurely in March 2025 at 109,628 miles - lasting only 36,132 miles. This was a safety-related recall part intended to fix a known defect with the original pump. Audi refused to provide goodwill reimbursement for this premature failure. I am reporting this to request further investigation and possible expanded remedy.
Engine & cooling
Audi Q5 Hev Engine problems by year
77 complaints filed with NHTSA about the Audi Q5 Hev's engine & cooling. Stalling, loss of power, oil consumption, overheating, head gaskets, timing chains and engine failure.
Engine complaints by model year
Latest Q5 Hev engine complaints
Invoice from mechanic states my water pump failed along with other engine components which led to a domino effect of system failures and leaks with potential to cause fire. Similar recalls have been issued for 2014 Audi Q5s
Vehicle: 2015 Audi Q5 2.0T VIN: [[redacted]] At around 70,000 miles, my vehicle began consuming engine oil abnormally. I received a low-oil warning and had to add 1 quart every 1,000 miles. I first approached an authorized Audi dealer at 75,000 miles, who inspected the vehicle and stated this was "normal for older vehicles" and found no issues. However, the problem worsened rapidly. By 79,000 miles, I visited a second Audi dealer who acknowledged that this was a common problem in this engine type. They quoted me...
Read the full complaint
$16,000-$20,000 for a full engine replacement, stating they could not replace pistons alone. At 80,000 miles, my car now consumes 1 quart of oil every 200 miles. The oil warning light comes on frequently. I am forced to carry oil and top off multiple times per week. This is not normal wear for a luxury vehicle with regular maintenance. This condition creates multiple safety risks: •Sudden engine seizure or power loss if oil runs too low, especially while driving at highway speeds. •Loss of steering/brake assist due to oil pressure failure. •Increased fire risk from leaks or overheating. •Frequent roadside stops to add oil, risking exposure to traffic. •Distraction while driving due to monitoring oil levels. •Environmental hazard from oil spills. The engine remains available for inspection. The vehicle has only been inspected by Audi dealerships. Audi should be held accountable for a defect that compromises safety and reliability at relatively low mileage. I urge NHTSA to investigate and take appropriate action. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2015 Audi Q5. The contact stated that there was an abnormal leak underneath the vehicle. In addition, the contact stated that the vehicle failed to start up as intended. The contact stated that the coolant reservoir was refilled; however, the failure persisted. The vehicle was diagnosed on the scene by an independent mechanic, who determined that water pump had failed. The independent mechanic related the failure to NHTSA Campaign Number: 18V229000 (Engine and Engine Cooling); however, the VIN was not included. The local dealer was not contacted. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 140,000.
I have noticed 2 times that my engine burn out oil very quick before the next predicted oil change and lead to safety risk of boosting engine while driving long distance if there is no auto one near. After speaking with one of the maintenance guy the last time I went for oil change at Jiffy live, He told me that there was a recall for the same problem with some other Audi models. How could we expect your help to address this safety concern with the manufacturer. This is very dangerous situation that you can't neglect. Best regards,
The contact owns a 2014 Audi Q5. The contact stated that while driving 60 MPH, the vehicle briefly lost motive power and the vehicle stalled. The contact was able to coast to the side of the road. No warning light was illuminated. The vehicle was towed to the daughter's residence. The contact stated that weeks before the failure, while the vehicle was being serviced at the dealer, it was determined that the engine was consuming an excessive amount of engine oil. The vehicle was not repaired. The manufacturer was made aware of the first failure. The failure mileage was 72,919.
Common problem with engine cooling systems and oil systems failing. Failing emissions because of this and overheating with risk of fire. Common problem with the Q5s. Which some of them are recalled but not my 2015 q5 premium for some reason.
I've reported multiple times to my dealer about the oil comsumption back in 2022 and work was performed on the vehicle in the prior year to fix leak and brake noise issue since approx 2021 on my 2015 Q5 that currently only has 65,000 miles. No warning indicator presents regarding the brakes. However oil indicator and engine light icons display. I'm constantly checking the oil indicator level to see how much is still in the and then add add once it shows thats its extremly low. I have to do this everytime I am about...
Read the full complaint
to use the car. This can be dangerous at times since there's no indication that its very low and its not seen unless you go into the "car" section that shows the level, it has no alert display for the level. All required diagnostic and maintenance services have been performed with the dealer. When inspecting the brake issue they always come back with no findings say that no issue could be found, howeve when I'm driving it, it sqeeks and makes a grinding sound all the time. This has been going on for quite a few years. As for the oil consumption issue, this isssue has been in recent years and both times this has been looked into by the dealer I was informed that its not covered under any manufacturers warranty and would cost me approx. $10,000.00 for them to repair it or I could trade it in. This is a very expensive luxury car and at this low milage shouldn't have these types of issue. I've seen on various car sites that both the oil comsumption and piston issue is a known issue with this model Audi and that issue occurs aournd 60,000 miles but was rectified for the models that came after 2015. I wish I had know this before making this purchase. Now the driver seat adjusting panel is broken, this came out of no where about four weeks ago with no warning. I haven't received any recall notifications since my Audi Care coverage expired, not sure why this would stop because I didn't continue this service.
After paying to run an inspection test recommended by Audi USA, it was confirmed that the issue of the excess oil consumption was with the piston, and they also recommended changing the engine. It puts me at risk every time I drive the car because I am not sure how much oil my car has at this point. I have been reporting to the dealer my observation of excessive oil consumption. They kept telling me that it was because my car was old. I have an Audi Q5 2015 with 85,600 miles. I have done all my manufacturing...
Read the full complaint
maintenance at the dealer, so they have records that I do take care of my car. I paid to run a diagnostic test suggested by Audi USA. I was told that I have to pay about $30,000 to fix the engine ($13,000 + for the piston and $17,000 + for the engine). The car started warning me that it needed oil soon. I reported it to Audi USA and told them that this issue was one of the recalls done in 2017. I was told that I did not qualify for any coverage because it was only for cars that had an issue in 2017. Now, at 85,600 miles, I am using almost two-quarters of an ounce for every 1,000 miles. I called Audi USA over a month ago, and they asked me to take my car to the dealer so that they could run the test. I had to pay for the test only to confirm that I needed to change the engine and piston. This is a costly luxury car, and nobody should be going through this issue. Audi is responsible for this manufacturing defect.
Vehicle stopped while driving!!! Middle of the driving. Very dangerous. And it happened twice. With that as the headline, another known problem with this vehicle has been the engine oil needing to be filled literally every month. And time to time it resulted in "engine light" to come. So we kind of ended up in a "wolf cry" and really didn't act. However, we did take care to Audi service for oil refill and they IGNORED to do the inspection on engine light well under 100,000 miles and 10yrs on warranty. So our...
Read the full complaint
recent car stopped when we were just about 2 months over 10yrs and 3,000 miles over 100,000 mile warranty Audi has for the problem needs repaired. Please help. Now Audi is saying we needed to pay almost $6,000 to get that repaired. Which they have seen for months prior to the 10yrs and 100,000. It's really a unfair business practice.
Cylinder #3 lost compression, down to 30 psi from 170 psi, causing the car to lose power and run extremely rough or not run on occasion. This is a safety hazard, especially risky for highway driving. There were no warning messages, car just start running very rough or wouldn't start. Such loss of compression has been reported by an Audi service manager who says Cylinder #3 is known to have this issue, but there is no recall for it yet. The problems began in May 2021. The car was drinking/consuming oil frequently...
Read the full complaint
and occasionally running rough. It was taken to multiple mechanics to identify the issue. Fixes included changing spark plugs, coils, and the PCV valve to provide temporary solutions at best. 5/24/21 increased consumption of oil began 9/9/22 rough idle, spark plugs replaced 10/14/22 rough idle and burning oil, taken to a service shop, replaced the PCV valve 7/12/23 rough idle again, spark plugs replaced again under warranty 2/14/24 - rough shake again, spark plugs replaced again and dead cylinder #3 confirmed
The contact owns a 2014 Audi Q5. The contact stated that while driving at 10 MPH, the vehicle lost motive power. The engine and EPC warning lights were illuminated. The vehicle was consuming an excessive amount of engine oil. The vehicle was towed to an independent mechanic, who stated that the failure was due to the timing chain, piston rings, and a hole in the valve. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 73,000.
Oil consumption Burns a lot of oil
Timing chain went out
The car has a known "oil consumption issue" that has led to engine failure that Audi has failed to take responsibility for. This is a 2104 Audi Q5. The car is in San Francisco and available for inspection. The car vibrates and can't be safely driven at highway speeds, if the engine suddenly lost power on the highway it could be a major safety issue for the driver and other drivers. The dealer has reproduced the issue and diagnosed it as needing new Pistons and Rings at 99,000 miles (but it has had this issue...
Read the full complaint
since in the 60,000 mile range, they just said keep adding oil). It has not been inspected by police or insurance representatives, just the dealers. I'm sure some warning lights came on, but could not say which ones or when.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked daily. Complaints are owners' own reports and are not verified. How we use the data