Tl* the contact owns a 2002 bmw k1200rs. While driving approximately 5 mph, fuel leaked from the engine compartment without warning. The failure recurred daily. The vin was not included in nhtsa campaign number: 04v028000 (fuel system, gasoline). The manufacturer was not notified of the failure. The approximate failure mileage was 28,000.
2002-2002 · 1 model year
BMW K1200RS Problems by year
Owners have filed 18 complaints about the BMW K1200RS across 1 model year, and it has 0 recalls. The 2002 has the most complaints once its age is allowed for (18). The most reported problem area is the fuel system, followed by the brakes.
- Complaints
- 18
- Recalls
- 0
- Crashes
- 2
- Fires
- 0
- Injuries
- 2
- Deaths
- 0
K1200RS complaints by model year
Highlighted: the year with the most complaints for its age. Older vehicles have had more time to collect complaints - the Safety Index grade allows for that.
| Year | Complaints | Recalls | Grade |
|---|---|---|---|
| 2002 | 18 | 0 | - |
Most common K1200RS problems
Latest K1200RS complaints
While riding the bike a few days ago, the abs failure lights came on. I shut the bike off, and restarted to attempt to reset the system. This did not work. Later in the day, when starting the bike up,...The abs was functioning, for about 15 minutes, then the failure lights again came on and have constantly stayed on since. The bike is a 2002 and has just turned 33,000 miles. I had the brake system flushed about a year ago in hopes it would prevent this from happening, as this is a very common problem on bmw...
Read the full complaint
bikes of this period,...Especially the bikes in the "k" family. Bmw dealers charge $2200 to replace the unit, with another identical unit, which is known to fail again. This has been going on for years, and bmw is well aware of the problem. Isn't it time to do something about it? I ride bmw motorcycles because they have abs brakes. This is the second bmw k1200 that I have owned in the last 10 years,.....The abs failed on the first one as well.
I put shenko motorcycle tires on my 2002 bmw motorcycle. After about 3000 miles the tread separated from the tire base. I complained to shenko and the dealer I purchased them from. This was a life threatening situation on a motorcycle with a passenger. I have done research and this problem is more common than it should be. Shenko should not be selling inferior and life endangering products in the usa. Please respond and look into the quality of this imported product, there will be deaths in the future with this tire. I can supply photos if you like. [[redacted]] information redacted pursuant to the freedom of information act (foia), 5 u.S.C. 552(B)(6). *Tr
This is a follow-up to my first report of this date. Bmw apparently conducted a recall (04v-028) for leaks with this coupling, however the recall addressed leaks from the quick disconnect o-ring and the hose clamps. In this case the body of the plastic male end of the coupling initially cracks and then separates allowing fuel under 100 psi to flow down the engine and then towards the rear of the bike. There was one report of a fire and an injury from the previous recall. Here we have a leak occurring from the same...
Read the full complaint
fitting with the same potential. Initially bmw replaced this fitting with the same original part only to find that the fitting failed again. This problem continues to plague bmw riders and needs to be addressed. It appears that the ntsb's initial investigation was suspended when the manufacturer agreed to a recall back in the 2004/5 time frame, thus the particulars of this problem where not forthcoming, and the full nature of the defect not adequately addressed. *Tr
Started my bmw k1200rs and backed it out of the garage. Noticed a spray emanating from the right side of the engine above the valve cove. Shut the bike down and checked for the leak. Found that the plastic fuel line quick disconnect coupling was cracked allowing fuel to spray out in a fine mist. This could have easily caught fire if the bike had been hot. Checked the internet and found that this failure is a common problem on bmw motorcycles and is not limited to my model or year. Bmw has not seen fit to recall the...
Read the full complaint
affected motorcycles even though they are aware of this problem and have redesigned the coupling. The fuel line is pressurized at 100psi so the likelihood of a catastrophic event is high. *Tr
Slowing down to stop abs brake lights came on. Front abs still works but rear went out. Took it to bmw dealer service tech says had to replace a lot of abs units in the past but not covered under warranty or recall. This part is 2332.00 Plus labor. *Tr
Questions about the BMW K1200RS
Which BMW K1200RS years have the most problems?
By the number of complaints owners filed with NHTSA: 2002 (18). Allowing for how long each has been on the road, the 2002 stands out most. Complaint counts also rise with sales, so compare years of the same model rather than different models.
What are the most common BMW K1200RS problems?
Across every model year, owners report problems with the fuel system (9), brakes (3), transmission & drivetrain (3) most often.
How many recalls does the BMW K1200RS have?
NHTSA lists no recalls for any BMW K1200RS model year on file.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked daily. Complaints are owners' own reports and are not verified. How we use the data