- The problem
- Fan blade rivet breakage can occur causing the fan blade to separate from the spider.
- The risk
- If this occurred while the hood was open, a person working under the hood of the vehicle or in the vicinity of the vehicle could be struck by the fan blade and injured.
- The fix
- Dealers will inspect and replace, if necessary, the fan with a newer fan having thicker-headed rivets.
Engine & cooling
1995 Chevrolet Blazer Engine problems
Owners have filed 200 complaints about the 1995 Chevrolet Blazer's engine & cooling with NHTSA - 16% of all its complaints, most recently on April 18, 2019. They describe 4 crashes, 8 fires and 1 injury. Stalling, loss of power, oil consumption, overheating, head gaskets, timing chains and engine failure.
- Complaints
- 200
- Recalls
- 1
- Crashes
- 4
- Fires
- 8
- Injuries
- 1
- Deaths
- 0
Engine recalls for the 1995 Chevrolet Blazer
Engine complaints
On highway truck dies all systems off ihave all receipts mulitple repairs from the egr valve coils fuel pump spider ..Along with multiple electrical issues involving the emergency button will not turn off had replaced still issue came back, car will not start unless something clicks in steering column also distributor and timing missing ? I can go on ..Nightmare.I love my truck howere I could have gotten a new car for this much but have put so much money into it and im a single mom not on any gov assistance or welfare or support..Please this truck>>>>argh
I have gas leak that come from the back of the car and that is when I get out of the blazer, and it seem to be wheel problem. *Tr
I had the egr valve replaced because there was problems with my vehicle running terrible and killing in traffic. It was replaced free because there was a bulletin, I really wonder if it was replaced on 10/01 because almost 1 year later 9/02 I started having the same problems again and it cost me $272 to have it fixed and once again as of 10/11/05 computer diagnostic reveals that the egr is sticking again and it's going to cost $375,could I have possible gotten a defective egr on 10/01. Also, I have had this...
Read the full complaint
problem with my blazer shortly after I purchased it . When driving on uneven surface it sounds as if something is cracking and trying to fall to pieces in the front and the steering is loose and pulls to one side, even after a front end alignment and rotation and balance, the problem is not corrected. I actually had 1 of many front end alignment and rotation done on 10/07/05 and my front end problem has gotten much,much worse than usually. I am almost scared to drive it. *Jb
While driving vehicle caught on fire. Investigation showed that fluid was overflowing out of the transfer case and traveling to the catalytic converter and exhaust system.*Ak the fluid overflowed to the hot manifold and exhaust system causing the fire. The consumer stated that the transmission was replaced and the seal that connects the transfer case was not replaced. The consumer stated that when the flammable liquid from the transmission went into the transfer case the seal gave way. The consumer stated that...
Read the full complaint
the placement of the vent tube over the hot exhaust is a dangerous design flaw and should be recalled due to fire hazard. The consumer stated the seal was replaced and she was overcharged. The consumer would like to be reimbursed for the cost of the repair. The consumer stated that if she does not hear the public address of this problem on the news she will take the issue to the news wire personally. *Tc
Engine compartment plastic shield disintegrated. As a result, water leaked into the vehicle. *Ak *tc
One of the oil cooler hoses came off the crimp causing the vehicle to lose all oil and pressure. Vehicle shut down in the middle of a curve, causing owner to lose control of the vehicle (but luckily regain it). Engine is a complete loss and will be costing us thousands of dollars to replace. This really seems to be a manufacturer issue, as the crimp method used for this high pressure (and highly important) hose is of a type that does not seem reliable. The shop that is holding our car, pending our decision on...
Read the full complaint
what we can do about this problem, has indicated they have had one or two other blazers in their shop in the last year with the same problem occurring - and that they noted at the time that the crimp method, without barbs to give extra grab to the hose - seems to be the contributing factor. I would really like to see chevrolet take responsibility for this manufacturing defect - if the hose had been attached in a reliable method, this problem would not have occurred. This is very dangerous.*Ak
The car surged and lost oxygen to brakes, etc. I have had exhaust system replaced, new tires, new computer e prom, egr valve cleaned numerous times, new injector unit installed, brakes replaced, total tuneup to try and rectify the problem. I still continue to have to have the carbon cleaned out of the egr valve as the car will not run properly. I purchased the blazer from ricko ent. Inc. 16 Moulton rd, rochester, nh, 03867.Also known as first city motor sales in rochester nh. The owner, richard ottino agreed to cover the cost of repairs but never did. The total of repairs that I have paid to date is $1,266.00. I sent the dealership a certified letter with all copies of the repair bills.
We have had numerous problems with the egr valve being clogged!Now we have had problems with the fuel system.We have had the fuel pump changed, and now it's back in the shop due to the spider.The abs brakes also don't work properly.Are there recalls due to the fuel system?*Ak
Egr valve needs to be replaced for the third time. Seems like this is becoming regular maintenance. *La
Car stalled numerous times at any speed. Independent shop stated that vehicle stalled due to a faulty egr valve. Dealer notified. *Ak
Vehicle oil line exploded. *Mr while driving down the highway, the engine light came on. The consumer lifted the hood and viewed oil everywhere. The service dealer stated that the oil line exploded. The oil line from the oil filter mounted off the engine in the front of the vehicle. *Scc *jb
Consumer stated that while driving and without warning, the egr valve failed, which caused the brakes to fail. Dealer notified. *Ak the mixing with the fuel was the biggest problem. (When there was carbon build up in the egr valve, it would leave it open and caused no vacuum hard pedal and brake failure. When it rained or was cold the truck ran rough. The service light came on when the vehicle had run rough more than once, noise was present and there was a smell of burnt wires and the ignition switch was...
Read the full complaint
replaced, the brake pedal seemed soft on more than one occasion and the master cylinder and other brake components were replaced to try and solve the problem, the cd player had not worked since the ignition switch was changed, the rear windshield wipers had become inoperative, a noise would occur when turning but was not duplicated, and the muffler tail pipe had fallen off and rusted due to carbon build-up. The egr valve was cleaned but the problem persisted. The mechanic stated that in order to perform a proper job, the excessive carbon build up in the upper and lower intake manifold which effected the egr pendel, and the 02 sensor could cause a problem with the exhaust system, catalytic converter, fuel pump, the brakes, etc. The brakes squeaked, there were no dash lights, no air conditioning, and no 4-wheel drive. The fuel injections needed to be checked, and there were two recall stickers on the engine. *Scc the rear wiper motor, fuel injectors and brakes were replaced. *Jb
Egr valve & oxygen sensors problem the above mentioned items have been identified as a problem with these vehicles by dealer & private mechanics. A service bulletin was sent out in 1997 with a summary that provides if nothing else a temporary fix. I have spent several hundred dollars fixing this problem over the last 5 years and would like to have some type of reimbursement, preferably a recall to have it fixed permanently. I have viewed others comments on this vehicle and it is an overall problem. Seems like...
Read the full complaint
the manufacturer is not taking any responsibility. Since your questions below do not prvide room for explanation in the crash column, I would like to remind everyone that when these valves get clogged up the vehicle literally seizes. Just stops, nice thought! My personal mechanic has recommended that when the vehicle starts clugging (as it will), prior to seizing up & just stopping in the middle of the road, (as it has already done), bring it in, (we will clean it out). Who's fault will an accident be? That repair could be to the tune of $100.00 Depending on if anything else was affected by this. This problem has been identified, and still nothing is done about it. Currently we are a two car family with 2 teenagers in the market. Chevrolet dealers will not be on my list to visit. For this problem you would need a reacurring incident date.*Ak
Oil hose assembly motor side; oil hose assembly from filter to radiator failure. *Ak
THE ENGINE FAILED WITHOUT WARNING. *JB
The oil line failed, which caused the engine to seize. *Jb
Egr has been replaced twice since 1999 when I bought the vehicle. I just had the egr valve replaced yesterday and today the check engine light is back on and the nasty smell of exhaust/fuel is back in my vehicle. I also had the catalytic converter. Replaced two weeks ago. Vehicle runs rough and stalls without notice. Safety hazard! I have two small baby's and fear for their safety because of breathing in exhaust/fuel and vehicle stalling whenever. Mdh in virginia. *Nlm
The vehicles egr valve malfunctioned and caused the vehicle not to run properly. *Nlm
The oil cooler line (4.3W) on my chevy s10 blazer came out of the crimp and caused considerable damage to my engine. The dealer who sold and does work on this vehicle says it is not their fault and the repair price tag is quite a large sum! I would like to know why and how can chevy let a "defect" of this magnitude go unnoticed! I do not feel it is my responsibility to pay for this repair!*Jb
The hose came off the oil filter. Which forced the driver to pull off the road.*Jb
The coolant line cracked, which caused coolant to leak.*Jb
Vehicle has a malfunction with the oil coolant lines,it keeps leaking oil. The dealership has replaced the line twice but the problem recurred. Ph
4 Egr valves (and I have got to put the 5th one on now) in the last 3 years $200.00 Each. 2 Cmfi units because of the fuel pressure regulator leaking the whole unit has to be replaced $500.00 Each. Fuel pumps $80.00 Each transmission has slipped at different times. Cooling is a problem it has never overheated but it would like to in the summer. I am a mechanic and all of my cars are taken care of to the slightest detail but it is not normal to replace this stuff more than a couple of times in the life of a car much less a couple of times a year. *Jb
Gas recirculation valve (egr) failed 5 times since purchase of the vehicle. Brakes failed by the time vehicle got to dealership. *Tt
We purchased a 95 chevy blazer from a dealer used at the end of october 2002. Less than 60 days later, the oil cooler line fell apart and all oil drained from the engine in 30-60 seconds, causing complete engine failure. The vehicle seized up in trafic in a dangerous area and there was not time to drive to a safe area to inspect the vehicle. The vehicle was towed to an independent mechanic who told us that this was a factory defect and suggested that we contact the dealer as the engine must be replaced. The...
Read the full complaint
dealer contacted chevrolet who has declined all responsibility and knowledge of this problem, yet there are numerous consumer complaints about the oil hose. Despite the fact that the vehicle was purchased less than 60 days before, we now are facing a repair bill that is half the cost of the vehicle and the dealer's response was "too bad."
Chevrolet Blazer engine complaints by year
Blazer engine problems, every yearSource: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data