Chrysler is recalling certain model year 2012 chrysler vehicles, including 200 and town and country models, dodge vehicles, including charger, durango, grand caravan and journey models and jeep grand cherokee vehicles manufactured from august 31, 2011...
Engine & cooling
Dodge Grand Caravan Engine problems by year
1,833 complaints filed with NHTSA about the Dodge Grand Caravan's engine & cooling. Stalling, loss of power, oil consumption, overheating, head gaskets, timing chains and engine failure.
Engine complaints by model year
| Year | Engine complaints | Crashes | Injuries | Recalls |
|---|---|---|---|---|
| 2020 | 2 | 0 | 0 | 0 |
| 2019 | 7 | 0 | 0 | 0 |
| 2018 | 35 | 0 | 0 | 0 |
| 2017 | 60 | 0 | 0 | 0 |
| 2016 | 102 | 1 | 0 | 0 |
| 2015 | 38 | 0 | 0 | 0 |
| 2014 | 81 | 2 | 0 | 0 |
| 2013 | 73 | 0 | 0 | 0 |
| 2012 | 121 | 1 | 0 | 1 |
| 2011 | 97 | 0 | 1 | 0 |
| 2010 | 196 | 2 | 2 | 0 |
| 2009 | 51 | 1 | 0 | 0 |
| 2008 | 145 | 4 | 0 | 0 |
| 2007 | 41 | 0 | 1 | 0 |
| 2006 | 31 | 1 | 1 | 0 |
| 2005 | 49 | 0 | 7 | 0 |
| 2004 | 20 | 0 | 0 | 0 |
| 2003 | 17 | 1 | 0 | 0 |
| 2002 | 23 | 0 | 2 | 0 |
| 2001 | 19 | 0 | 0 | 0 |
| 2000 | 96 | 0 | 2 | 0 |
| 1999 | 73 | 1 | 0 | 0 |
| 1998 | 140 | 0 | 3 | 0 |
| 1997 | 103 | 2 | 0 | 0 |
| 1996 | 169 | 4 | 4 | 1 |
| 1993 | 17 | 0 | 0 | 0 |
| 1992 | 15 | 0 | 0 | 0 |
| 1991 | 9 | 0 | 0 | 0 |
| 1990 | 3 | 0 | 0 | 0 |
Engine recalls
In certain vehicles, the engine cylinder head oil galley plug does not seal properly and engine cylinder head oil is not adequately retained.
Latest Grand Caravan engine complaints
My vehicle caught fire on 10-14 after being parked for 2.5 hours. Three weeks prior I had bumped into a light pole while backing up and my airbag light triggered on. The airbag did not deploy and nothing seemed wrong with the van. Then my battery died so I had to have it jumped. It died 3-4 times before I replaced it with a fresh battery 10-7. I did smell heat, but I attributed it to my oil leak, but I think I was smelling wires, not oil. I went by an autoparts store and they read my old battery temp and it was...
Read the full complaint
at 173 and didn't say it was hot or anything. I don't think that was safe to put a new battery in when there was obviously a problem. The airbag light consistently dinged off and on but since the airbag didn't deploy I didn't think it was any problem. But now I think it was slow draining the battery and then the new one kept charging it causing something to overheat and catch fire.
Randomly shuts off Says key is in the ignition when it isnt
The contact owns a 2016 Dodge Grand Caravan. The contact stated that while driving at various speeds and attempting to accelerate, the vehicle hesitated and jerked slightly before accelerating. The check engine warning light was illuminated. The vehicle was taken to a certified mechanic, and the vehicle was diagnosed with transmission pump failure. The contact was informed that transmission pump needed to be replaced. The mechanic declined to repair the vehicle after discovering NHTSA Campaign Number: 16V461000...
Read the full complaint
(Power Train) for the issue. The mechanic referred the contact to the manufacturer, who was informed of the issue and confirmed that the VIN was not included in a recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 138,000.
The vehicle has experienced repeated serious engine/cooling-system problems. It ran hot/overheated and would lose some power on even very slight inclines; when this occurred, the temperature gauge would rise. It never completely lost power or stalled. The vehicle developed an engine ticking noise that continues. An oil-pressure warning appeared, and the check-engine light repeatedly came on. In approximately March 2026, the engine failed and was replaced with a used engine reportedly having approximately 40,000...
Read the full complaint
miles. Within approximately six months, the replacement engine developed additional oil-pressure/oil-system problems and continues to make a ticking noise. The vehicle has required substantial additional repairs. These problems create a safety concern because overheating, loss of power and possible engine failure could occur while driving and could leave the vehicle unable to safely maintain speed or operate normally in traffic. The problems have been diagnosed and repaired by independent automotive service facilities. The vehicle has not been inspected by the manufacturer, police or an insurance representative. The vehicle is available for inspection upon request. The symptoms began after we purchased the vehicle used on September 2, 2023, at approximately 68,000 miles. It now has approximately 109,000 miles. We have limited driving to very short trips because of these ongoing concerns. I HAVE RECIEPTS FOR the MOST RECENT 2026 REPAIRS , However the system here wont allow my picture/files
While driving, the engine shuts off, leaving the driver with no power steering or power brakes. All power is off. There is no warning or error messages on the dash of any kind. No warning at all. The last time this happened, I was able to coast to the side of the road to a stop. Once stopped, i can put the transmission in Park, restart the vehicle and continue. This time, I drove directly to my service shop to have the computer checked for codes. There were none, like the event never happened. They could not...
Read the full complaint
reproduce the problem. This has happened 3 times since August 2025. The wireless ignition module was replaced in 2015 under the recall notice 14V373000. That recall was for exactly this situation. So far, I have been fortunate to avoid hitting another vehicle or other objects. This is not a safe situation, especially knowing it might happen tomorrow.
I just started having this issue 3 days ago. When I put the car in reverse it does not directly go into drive. I have to go back to park to get the car back in drive. I put a brand new transmission in this car in 2024 and since I can only drive 45 miles per hour. When the drive or reverse does not light up in green, the camera in the back does not operate or show up at all.
Transaxle pump failure for my vehicle. Recall S44 does not include my specific vin so I am not able to get assistance through Dodge
The contact owns a 2016 Dodge Grand Caravan. The contact stated that while operating the vehicle, there was an abnormal knocking sound coming from the engine compartment, with the check engine warning light remaining illuminated. The cause of the failure was not yet determined. The manufacturer and local dealer were not yet contacted. The failure mileage was approximately 140,000.
The contact owns a 2014 Dodge Grand Caravan. The contact stated that while driving at approximately 30 MPH, the vehicle would lose automotive power and the steering wheel became difficult to veer in either the left or right direction. No warning lights illuminated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired due to the VIN not being included in any recalls. Upon further investigation, the contact related the failure to an unknown NHTSA Campaign number; however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 175,000.
specifics unknown check engine light came on cpl seconds before it started overheating / leaking coolant and or transmission fluid and overheating. and I'm not sure what. started last year but I don't drive very often so the issue just started last year
1) At D/S Stow and Go seat malfunctioned and was repaired by CarMax Service Center Jan 2023 - 2) Around 97,000 so - Engine started ticking on or about JUL/SEP 2023, enstate Lloyds Automotive in Spokane Valley replaced out engine due to manufacture defect in Oct 2023. 3) At 103,672mi - P/S stow and Go seat was repaired for same issues as D/S stow & Go Seat by Lloyds Automotive Oct 2023 when engine was replaced out. 4) Around 116,000mi the Transmission was flushed when I got the oil changed because I noticed jerking...
Read the full complaint
shifting at times, this was Aug 2024 there was no check engine or diag faults. 5) Around 132,720 Fell under CXLHX982 / CXLHX981 Actuator Sliding Door D/S & P both repaired and Transmissioned serviced again because my van started stalling out at stops and the jerking happened again no check engine or diag faults 6) Around 138,000 - D/S Sliding door hatch pin repair by Coos Bay Area Dodge. On 24Mar2026 - Around 142,000mi my transmission overheat warning came on and my van would not go any faster than 45 to 50mi, the RPMs went from 1.5 to 4 to 5 then 7 and back down, I immediately pulled over and sat for about 40min turned my van back on there was no overheat warning so I drove around 50mi per hour in the emergency lane to the next exit which was Hood River, Or and trailer towed my van from Hood River, Or to AAMCO, North Spokane Wa for transmission service. - I believe my vehicle 2016 Dodge Grand Caravan R/T model - transmission was built with some underlying transmission serious safety defects and should have been recalled and a part of Part 573 Safety Recall Report 16V-461. My vehicle malfunctioning could have caused an accident if not for my quick thinking that day and keeping my vehicle maintained at a high standard. I do keep all my service records.
I am filing this complaint regarding the service department at Vaden Dodge Chrysler Jeep Ram. My complaint concerns a failure to properly diagnose a mechanical issue with my vehicle, misleading statements about the condition of the vehicle after repairs, and poor communication during the repair process. The vehicle is a 2017 Dodge Grand Caravan. Before bringing it to the dealership, the vehicle was jerking when slowing or coming to a stop. On February 19, 2026, a diagnostic scan showed code P0420 - Catalyst System...
Read the full complaint
Efficiency Below Threshold (Bank 1). At that time the vehicle was still drivable. On March 2, 2026, I brought the vehicle to the dealership and reported the jerking issue. I also asked that the throttle body and transmission be inspected. The dealership stated that the technician could not determine the cause of the problem but recommended maintenance repairs including tires, brakes, and rotor service. Based on their professional recommendation, I approved the repairs. On March 6, 2026, I picked up the vehicle and paid 1,416.21. I was told the vehicle passed inspection and a safety test drive. However, within approximately thirty minutes of leaving the dealership, the vehicle began jerking violently and shut off while I was driving. The vehicle had to be returned to the dealership. After the vehicle was returned, I was informed that the catalytic converter needed to be replaced. This was concerning because I had asked the dealership to check that component during the initial inspection. I was originally quoted about 2,800, and after discussions with management including Jim Fife, I paid 2,165 on March 14, 2026 for the catalytic converter repair. Despite paying a total of 3,581.21, the vehicle continued to show drivability problems. A new diagnostic scan showed codes P0420 and P219B (air-fuel ratio imbalance), suggesting the underlying issue may not have been properly diagnosed before replacing the catalytic converter. I attempted to resolve the issue.
The fuel pump would run all night and going down the road the van would cut off...had it checked the tipm was bad
Engine loss of power, failure to accelerate, sudden forward lurch when stopped, Check engine light diagnosed by dealership and independent shop as Cylinder 2 failure. Purchased from Carvana 11/2024 with just over 70,000 miles on it. Currently has about 77,000. Cylinder head is currently being replaced at a cost of $6,500.00
2Nd cylinder head and exaust valvue part # r3602014aa intake manifold part #5184199af defective oil filter housing adaptor parts defective: 68228480aa
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked daily. Complaints are owners' own reports and are not verified. How we use the data