- The problem
- Fleetwood is recalling 3,782 my 2006-2009 providence, excursion, expedition, discovery and boulder diesel motor homes. The battery cable is routed too close to a sharp edge located on top of a shelf installed over the driveshaft.
- The risk
- This can cause abrasion to the battery cable insulation, leading to an electrical short and possibly a fire.
- The fix
- Dealers will re-route the cable away from the sharp edge location. This service will be performed for you free of charge. The recall began on may, 26 2009. Owners may contact fleetwood at 800-509-3418.
Vehicle safety record
2006 Fleetwood Excursion Problems, complaints & recalls
Owners have filed 7 complaints about the 2006 Fleetwood Excursion with NHTSA, most often about the equipment & accessories (3) and the visibility & wipers (3). Those complaints describe 1 crash. It is covered by 5 recalls, the latest in February 2009 for the cables. For comparison, the 2005 has 10 and the 2007 has 3.
NHTSA data checked
FFar more problems than a typical Excursion year, for its age
#250 most complained-about 2006 vehicle
- Complaints
- 7
- Recalls
- 5
- Crashes
- 1
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
Most common 2006 Fleetwood Excursion problems
Share of all 7 complaints. One complaint can name more than one area. Tap an area for its complaints and recalls.
2006 Fleetwood Excursion recalls 5
Recall repairs are free. Your dealer fixes them whether or not you bought the car there - check your VIN at nhtsa.gov/recalls to see if yours is done. What to do
- The problem
- Fleetwood is recalling 70,101 my 2003-2007 southwind, pace arrow, bounder, flair, storm, fiesta, terra gas class a motor homes; bounder, discovery, providence, excursion, expedition, revolution, american eagle, american heritage, american tradition diesel class a motor homes; jamboree tioga class c motor homes; and prowler, wilderness, terry, mallard, pioneer, pride and triumph conventional and fifth wheel travel trailers equipped with a two-door refrigerators manufactured by the dometic corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.
- The risk
- If this solution is exposed to an ignition source under certain specific circumstances, it can result in a vehicle fire.
- The fix
- Fleetwood is working with dometic to repair these refrigerators (please see 08e032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle inc. To manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact dometic/stericycle at 1-888-446-5157 or fleetwood at 1-800-322-8216.
- The problem
- On certain motor homes equipped with kwikee brand electric entry step built with a control unit manufactured by american technologies, may develop an electrical short during cold weather, allowing for the potential of the plastic case to ignite.
- The risk
- This will make the step inoperable and possibly result in a risk of personal injury, vehicle or other property damage.
- The fix
- Dealers will inspect and, if necessary, replace all american technologies controls associated with the kwikee brand electric entry step free of charge. The recall began on march 17, 2006. Owners may contact fleetwood at 800-509-3418.
- The problem
- Certain motor homes fail to comply with the requirements of part 567, "certification." The federal certification tag may be printed with the incorrect gross vehicle weight rating (gvwr) weight value of 31,000 pounds. The correct gvwr weight value is 28,000 pounds. The same weight error may occur on the cargo carrying capacity tag.
- The risk
- Overloading could damage the vehicle, adversely affecting vehicle performance including handling and braking, cause tire failure, and result in a crash.
- The fix
- Dealers will send replacement labels along with instructions. If necessary, dealers will change certain front suspension components and certify the chassis for the 31,000 pounds gvwr weight value. The recall began on february 27, 2006. Owners may contact fleetwood at 800-509-3418.
- The problem
- Certain diesel class a motor homes fail to comply with the requirements of part 567, "certification." The manufacturers' tow hitch receiver information label was printed with the incorrect weight carrying capacity value and the incorrect tongue weight value.
- The risk
- The weight label on the hitch receiver provides the maximum trailer weight rating and the maximum tongue weight rating. It is important that these ratings not be exceeded. Failure to comply could result in damage to the motor home frame, body, or hitch receiver and could cause unstable driving and handling characteristrics which may result in a vehicle crash.
- The fix
- Fleetwood will mail owners the correct tow hitch receiver weight information label. If owners do not feel comfortable installing the label, dealers will install the label for them. The recall began august 4, 2005. Owners may contact fleetwood at 800-509-3418.
What owners say
Be the first Excursion owner to share.
Problems or none - your experience is exactly what the next buyer is looking for. Write it now
7 complaints about the 2006 Fleetwood Excursion
Newest first, as filed with NHTSA by owners.
Tl* the contact owns a 2006 fleetwood excursion. The contact stated that the dual pane window became fogged and impaired his vision. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was 45,000.
The windows started foggy up in my rv and have steady gotten worse, especially the drivers window. At night it's almost impossible to see out of the side mirror due to the "fogging" of the window. From the many complaints I have read from other rvers, fleetwood seems to have used inferior windows when the rv was manufactured. I have never received a recall on these windows from fleetwood for replacement due to the inferior product. I have gotten an estimate for the costs to fix the windows that is over $2000,...
Read the full complaint
not including the costs to drive the rv to the repair shop approximately 175 miles from my home and time lost from work since most repair shops are only open m-f. I believe fleetwood should be responsible for fixing their problem due to use of a product that creates a potential danger for visibility especially due to the huge investment I have put into their product. I should not have to incur the costs to replace windows that are faulty. *Tr
Bought a 2006 fleetwood excursion new in 2007 with in 3 years several windows lost their seal. Total of 5 so far including window by driver's seat,causing problems with vision. I contacted fleetwood who said they had no liability. I contacted a glass company who said that should not have occurred . I have owned cars 40 to 50 years old which did not have this problem . Is there not a standard for glass installed in motorhomes. Thanks for any help here replacement will run 200 to 300 each ,but I think this is a fleetwood defect. *Tr
Tl*the contact owns a 2006 fleetwood excursion. The motor home was jacked up and leveled. When the contact pressed the button to retract the jacks, all but one retracted because it was hung up. He called roadside assistance after two hours of attempting to get it back in and he even used hydraulic pressure to assist. He is currently waiting for another jack to be made for the motor home. The current and failure mileages were 40,000.
SLIDE TRAVEL LOCKS FAILED TO ENGAGE. *TR
Why doesn't fleetwood safety recall # 06004 show up in the nhtsa databse. Isn't it the same kwikee step & similar wiring problem as fleetwood's recall # 60220 for similar vehicles. While this recall is called an upgrade noting that "the wire is not intended to carry this amount of electrical energy & may burn through and melt" , #60220 regards this as a safety hazard.
Dt*: the contact stated while driving 60 mph at night the steering wheel made a winding noise and was hard to maneuver causing the vehicle to hit an object. This occurred on normal road conditions and during normal steering. The vehicle was taken to the dealership for inspection. Upon inspection, the dealership replaced the steering pump, both front brakes and pads which remedied the problem. The manufacturer was alerted. Updated 3/9/2006 - *nm
Fleetwood Excursion: every year compared
All Excursion years2006 Fleetwood Excursion vs rivals
| Vehicle | Complaints | Recalls | Grade | |
|---|---|---|---|---|
| 2006 Fleetwood Excursion | 7 | 5 | F | |
| 2006 Fleetwood Discovery | 9 | 5 | D | Compare |
| 2006 Fleetwood Expedition | 7 | 4 | F | Compare |
| 2006 Fleetwood Bounder | 6 | 8 | D | Compare |
| 2006 Fleetwood Bounder Diesel | 3 | 4 | F | Compare |
| 2006 Fleetwood Pace Arrow | 3 | 5 | D | Compare |
| 2006 Fleetwood Flair | 3 | 5 | D | Compare |
| 2006 Fleetwood Gearbox | 2 | 1 | B | Compare |
| 2006 Fleetwood American Eagle | 2 | 1 | F | Compare |
More sales usually means more complaints, so compare similar vehicles of the same year. The grade compares each vehicle with its own model's other years.
Questions about the 2006 Fleetwood Excursion
Does the 2006 Fleetwood Excursion have any recalls?
Yes - NHTSA lists 5 recalls for the 2006 Fleetwood Excursion: cables (February 2009); recreational vehicle / trailer (July 2008); recreational vehicle / trailer (February 2006); labels (February 2006) and more. Recall repairs are free at any authorized dealer. Enter your VIN at nhtsa.gov/recalls to see whether yours has been fixed.
What are the most common problems with the 2006 Fleetwood Excursion?
By the complaints owners filed with NHTSA, the most common problem areas are the equipment & accessories (3), visibility & wipers (3), body, doors & structure (2).
How many complaints has the 2006 Fleetwood Excursion had?
7 complaints have been filed with NHTSA, the first on February 9, 2006 and the latest on July 2, 2014. Of these, 1 describe a crash and 0 a fire, and together they report 0 injuries and 0 deaths.
Is the 2006 Fleetwood Excursion a reliable vehicle?
Its Safety Index is 14 out of 100 (grade F: far more problems than a typical Fleetwood Excursion year, for its age). The index weighs complaints, crashes, fires, injuries, deaths and recalls against how long the vehicle has been on the road, compared with the same model's other years. It is not a measure of every repair - read the complaints and owner experiences, and have any used vehicle inspected before you buy.
Which Fleetwood Excursion years have the most complaints?
2005 (10), 2006 (7), 2007 (3). See every Fleetwood Excursion year compared.
What should I do if my 2006 Fleetwood Excursion has a problem?
If it is a safety problem, stop driving it if it is unsafe and contact your dealer. Report it to NHTSA at nhtsa.gov/report-a-safety-problem - enough reports start investigations and recalls - and share your experience here so other owners know what to look for.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data