1996 Ford Bronco Engine problems

First my engine seemed to overheat a bit then every once in a while it would sound like the engine was grinding on something and wouldn't stop.. Sounded like a bunch of chains in my hood. But then on occasions the stupid thing wouldn't shut off when it was making the chain sound, even with my key out. It just happened again and now the thing smells like something is burning and I have no power what so ever in my vehicle. Before when it finally shut off it sounded like it was about to spark. Then it was making a clicking noise that wasn't cool. *Tr

Dt*: the contact stated that the speed control deactivation switch was leaking fluid. There is a nhtsa recall on other ford vehicles. The vin was not included in the recall. When the vehicle was taken to a service dealer, the repair were made for a fee. Also every 25000 miles, the oil pan gasket needed to be changed due a small leak. The mechanic was unable to determine the cause of the problem. Third, the exhaust and intake manifolds were leaking causing a noxious smell inside the vehicle. The vehicle was then taken to the same service dealer. The dealer replaced both manifolds, and determined that there was an oil leak dripping onto the exhaust system.

On sunday december 11, 2005 while traveling on the highway I expired a sudden spike in temperature on my 1996 ford crown victoria. After taking my car to a ford dealership I was informed that my "plastic" intake manifold had cracked. I have researched the current investigation and had never received any sort of customer notification from ford. I heard about the manifold issue from a fellow employee. The total cost of repairs for this faulty manifold was $978.00. I feel if they knew they needed to update it with an aluminum manifold than they knew the plastic ones were faulty.*Jb

Dt: the vehicle caught on fire, the fire marshal said it started in the engine compartment, the insurance agency came to pick up the vehicle. Also, the house caught on fire. *Ak the fire started under the hood on the driver's side. *Sc *jb

Intake manifold was replaced on 1996 thunderbird in 2000. It is now cracked, and after spending 550.00 To find that out, there is nothing ford will do even though it is on campaign (97m91). Now I can not drive my car.

While driving vehicle would not go forward. Consumer stated transmission went out. Dealer contacted. *Ak cruise control and door locks are inoperative. Emergency brake light stays illuminated. Front end is out of alignment and pulls to the left. Head lights will not shut off. Thermostat, radiator, radiator cap, and water pump were replaced. The struts that hold the back window and door did not hold, springs for the back door are inoperative. Transmission needed adjustment, ball in transmission failed,...

After vehicle was parked for an hour consumer noticed smoke coming from vehicle . Please provide further information. *Ak

02 Sensor burned out while consumer was pulling out of dealership after purchasing vehicle. Also, this caused radio/ speedometer to burn out. Contacted dealer, and dealer fixed problem.*Ak