- The problem
- On certain 2 and 4 passenger, short and long bed low speed vehicles, the 12 volt output from the auxiliary card circuit board (a dc voltage to dc voltage converter) may become inoperative and result in loss of headlamp, tail lamp and turn signal lamp functions.
- The risk
- A loss of headlamps could impair a driver's visibility, increasing the risk of a crash. If there is a loss of tail lamp or turn signal lamp function, a following driver may not know when the brakes have been applied or that the vehicle in front is turning, a rear-end crash could occur without prior warning.
- The fix
- Dealers will replace the auxiliary cards, install a splash/spray protection, and adjust the dash seal free of charge. The recall began on september 11, 2006. Owners may contact global electric at 888-871-4367.
Vehicle safety record
2003 Gem Nev Problems, complaints & recalls
Owners have filed 2 complaints about the 2003 Gem Nev with NHTSA, most often about the electrical system (1) and the suspension (1). Those complaints describe 1 fire. It is covered by 1 recall, the latest in June 2006 for the electrical system. For comparison, the 2002 has 4 and the 2004 has 0.
NHTSA data checked
DMore problems than a typical Nev year, for its age
#342 most complained-about 2003 vehicle
- Complaints
- 2
- Recalls
- 1
- Crashes
- 0
- Fires
- 1
- Injuries
- 0
- Deaths
- 0
Most common 2003 Gem Nev problems
Share of all 2 complaints. One complaint can name more than one area. Tap an area for its complaints and recalls.
2003 Gem Nev recalls 1
Recall repairs are free. Your dealer fixes them whether or not you bought the car there - check your VIN at nhtsa.gov/recalls to see if yours is done. What to do
What owners say
Be the first Nev owner to share.
Problems or none - your experience is exactly what the next buyer is looking for. Write it now
2 complaints about the 2003 Gem Nev
Newest first, as filed with NHTSA by owners.
Fire inside dash of vehicle. Fire was caused by a defective module that already has a safety recall. The mfg. Will not replace parts/repair vehicle. They state vehicle had recall done already. Replacement parts are not available as the recall updates supercedes these parts with an upgrade kit (the recall). *Tr
Tl*the contact owns a 2003 chrysler electric gem. While driving at 10 mph the contact heard a loud clinking noise coming from the front of the vehicle. The faster the vehicle accelerated the louder the noise became . The contact called global electric motor company, and they suggested that the failure may be the front axle. The necessary parts for the repair were on back order. The current mileage was 7,346, and failure mileage was unknown.*Ak the consumer stated that the dealer set up appointment and came to repair the vehicle. Update 05/04/07*tr
Gem Nev: every year compared
All Nev yearsQuestions about the 2003 Gem Nev
Does the 2003 Gem Nev have any recalls?
Yes - NHTSA lists 1 recall for the 2003 Gem Nev: electrical system (June 2006). Recall repairs are free at any authorized dealer. Enter your VIN at nhtsa.gov/recalls to see whether yours has been fixed.
What are the most common problems with the 2003 Gem Nev?
By the complaints owners filed with NHTSA, the most common problem areas are the electrical system (1), suspension (1).
How many complaints has the 2003 Gem Nev had?
2 complaints have been filed with NHTSA, the first on April 17, 2007 and the latest on July 15, 2009. Of these, 0 describe a crash and 1 a fire, and together they report 0 injuries and 0 deaths.
Is the 2003 Gem Nev a reliable vehicle?
Its Safety Index is 38 out of 100 (grade D: more problems than a typical Gem Nev year, for its age). The index weighs complaints, crashes, fires, injuries, deaths and recalls against how long the vehicle has been on the road, compared with the same model's other years. It is not a measure of every repair - read the complaints and owner experiences, and have any used vehicle inspected before you buy.
Which Gem Nev years have the most complaints?
2002 (4), 2000 (2), 2001 (2). See every Gem Nev year compared.
What should I do if my 2003 Gem Nev has a problem?
If it is a safety problem, stop driving it if it is unsafe and contact your dealer. Report it to NHTSA at nhtsa.gov/report-a-safety-problem - enough reports start investigations and recalls - and share your experience here so other owners know what to look for.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data