Navistar, Inc. (Navistar) is recalling certain 2022-2024 International HV, International MV trucks, and 2022-2023 IC Bus TC commercial buses. When the parking brake is applied, the automatic transmission is still in drive or reverse position, and the...
Engine & cooling
International MV Engine problems by year
2 complaints filed with NHTSA about the International MV's engine & cooling. Stalling, loss of power, oil consumption, overheating, head gaskets, timing chains and engine failure.
Engine complaints by model year
Engine recalls
Navistar, Inc. (Navistar) is recalling certain 2023 International LT, International Lonestar, International MV, International HV, International HX, and IC Bus TC Commercial buses. The engine control module (ECM) may experience an internal electrical...
Navistar, Inc. (Navistar) is recalling certain 2019-2021 International MV, 2020-2021 International HV, 2014-2020 International DuraStar and 2015-2018 International WorkStar vehicles. When the parking brake is applied and the automatic transmission is still...
Navistar, Inc. (Navistar) is recalling certain 2019-2020 International MV and HV, 2018-2020 Workstar, and 2018-2019 Durastar vehicles equipped with feature codes 12VXT and 12VXU. With the parking brake applied and the automatic transmission in the 'Drive' or...
Latest MV engine complaints
The serpentine belt system keeps on eating belts. This unit needs a 4th belt with only 8900 miles. Its had many trips to the dealer under warranty and they refuse to fix the Root Cause of the belts going bad. The serpentine belt system controls the ac compressor, water pump, cooling fan and alternator. When belt failure occurs multiple truck operating systems simultaneously go down. The belt will start squeeking then eventually will stop charging. The dealership has replaced the belt tensioner and the...
Read the full complaint
serpentine belt twice. Its a design flaw, there is an engineering issue with either the belt tensioner, idlers or pulley alignment. The chassis upfitter was also complaining of multiple brand new units experiencing excessive belt squeeling that will in short time lead to failure. The problem is known about at the dealer, it is very easily reproduced as belts average lifespan is about 2,000 miles. This is a dangerous condition as it can disable multiple truck systems in the event of belt failure. No warning lamps.
The contact owns a 2020 International MV607. The contact stated that while driving 60 MPH, an abnormal thunder-like sound was heard coming from the vehicle, with several unknown warning lights displayed on the instrument panel. The contact stated that the vehicle began to jerk violently while shaking the contact was in the seat. The contact immediately pulled off to the shoulder of the highway. Due to the failure, the vehicle was towed to an independent mechanic, where the mechanic discovered that the fan hub was...
Read the full complaint
blown out of the engine. Due to the failure, the fan hub, fuel line, tensioner belt, and radiator all had to be replaced. The manufacturer was notified of the failure but offered no assistance. The vehicle had been repaired but remained with the dealer. The failure mileage was 178,359.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked daily. Complaints are owners' own reports and are not verified. How we use the data