- The problem
- Winnebago is recalling certain recreational vehicles equipped with 1200-series norcold refrigerators. The population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. The response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.
- The risk
- The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.
- The fix
- Winnebago is working with norcold to identify and notify any affected owners. Owners will be instructed to contact norcold dealers to receive the remedy free of charge. Please see norcold's defect report 10e-049 for additional information. The recall began during december 2010. Owners may contact norcold at 1-800-767-9101 or winnebago at 1-641-585-3535.
Vehicle safety record
2005 Itasca Sunova Problems, complaints & recalls
Owners have filed 2 complaints about the 2005 Itasca Sunova with NHTSA, most often about the equipment & accessories (1) and the body, doors & structure (1). It is covered by 4 recalls, the latest in October 2010 for the equipment. For comparison, the 2004 has 1 and the 2006 has 2.
NHTSA data checked
CAbout as many problems as a typical Sunova year, for its age
#362 most complained-about 2005 vehicle
- Complaints
- 2
- Recalls
- 4
- Crashes
- 0
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
Most common 2005 Itasca Sunova problems
Share of all 2 complaints. One complaint can name more than one area. Tap an area for its complaints and recalls.
2005 Itasca Sunova recalls 4
Recall repairs are free. Your dealer fixes them whether or not you bought the car there - check your VIN at nhtsa.gov/recalls to see if yours is done. What to do
- The problem
- Winnebago is recalling certain model year 2005 through 2009 winnebago sightseer and itasca sunova motor homes because the dinette area seat belt restraints on those vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 210, "Seat belt assembly anchorages." In a collision, the generated crash forces can cause the restraint's attachment to tear and allow the anchor to separate from the body of the vehicle.
- The risk
- If the restraint separates from the vehicle during a crash, the belt will not properly restrain the seat occupant, increasing the risk of injury or death to the occupant.
- The fix
- Winnebago will notify owners a dealers will repair the vehicles free of charge. The safety recall began on december 10, 2010. Owners may contact winnebago at 1-800-537-1885.
- The problem
- On certain motor homes built on a 20,700 gvwr or greater workhorse chassis, there may not be sufficient clearance in the area where the fuel line crosses the frame cross member.
- The risk
- Without clearance, a condition could develop where the cross member may wear into the fuel line and a fuel leak may develop. Fuel leakage, in the presence of an ignition source, could result in a fire.
- The fix
- Dealers will repair these motor homes by providing clearance between the fuel line and frame cross member. The fuel line will be inspected and, if necessary, replaced. The recall began january 7, 2005. Owners should contact winnebago at 1-800-537-1885.
- The problem
- Certain seat belt buckles on some motor homes fail to conform to the load requirement of federal motor vehicle safety standard no. 209, "Seat belt assemblies."
- The risk
- The seat belt buckle may unlatch in the event of a vehicle crash, possibly resulting in personal injury to the seat occupant.
- The fix
- Dealers will replace the buckles. The recall began on november 12, 2004. Owners should contact amsafe at 1-574-266-8330 or winnebago at 1-800-537-1885.
What owners say
Be the first Sunova owner to share.
Problems or none - your experience is exactly what the next buyer is looking for. Write it now
2 complaints about the 2005 Itasca Sunova
Newest first, as filed with NHTSA by owners.
2005 Winnebago itasco sunova has problems with the chassis, it is unsafe to drive past 55m ph rv is reactive to slight wind gust from small to large vehicles. *Ts the consumer had other problems with the rv such as an inoperative stove top o ring, slide out fascia right side, driver side and passenger fender blew out, the water heater failed, driver side mirror had blown off while driving, a slide out leak, a toilet spray leak, bathroom caulk cracking/separating, shower caulk/ separation, the kitchen was delaminating and the wall paper was bubbling
Dt: the contact owned a 2005 itasca sunova 29r. There was 3700 miles on the motor home. Rear brakes were smoking. The brakes had been squealing every since he purchased vehicle. Itasca corporate headquarters representative said consume r must have been driving it hard. This was on flat land and vehicle was smoking . Could smell the brakes. The motor home was not even fully loaded. The dealership said brake pads where burnt, and were not checking on it. The manufacturer would not cover anything than bleeding of the brakes. The brake job would be $1280 at first, and curreently was up to almost $2000. 2002-2004 Models were recalled for brake problems. *Ak
Itasca Sunova: every year compared
All Sunova years2005 Itasca Sunova vs rivals
| Vehicle | Complaints | Recalls | Grade | |
|---|---|---|---|---|
| 2005 Itasca Sunova | 2 | 4 | C | |
| 2005 Itasca Suncruiser | 5 | 6 | F | Compare |
| 2005 Itasca Horizon | 1 | 4 | D | Compare |
| 2005 Itasca Meridian | 1 | 4 | D | Compare |
| 2005 Itasca Spirit | 1 | 3 | F | Compare |
| 2005 Itasca Sundancer | 1 | 4 | F | Compare |
| 2005 Itasca Sunrise | 1 | 5 | F | Compare |
More sales usually means more complaints, so compare similar vehicles of the same year. The grade compares each vehicle with its own model's other years.
Questions about the 2005 Itasca Sunova
Does the 2005 Itasca Sunova have any recalls?
Yes - NHTSA lists 4 recalls for the 2005 Itasca Sunova: equipment (October 2010); seat belts (October 2010); hoses, lines / piping, and fittings (December 2004); buckle assembly (December 2004). Recall repairs are free at any authorized dealer. Enter your VIN at nhtsa.gov/recalls to see whether yours has been fixed.
What are the most common problems with the 2005 Itasca Sunova?
By the complaints owners filed with NHTSA, the most common problem areas are the equipment & accessories (1), body, doors & structure (1), brakes (1).
How many complaints has the 2005 Itasca Sunova had?
2 complaints have been filed with NHTSA, the first on August 3, 2005 and the latest on March 27, 2006. Of these, 0 describe a crash and 0 a fire, and together they report 0 injuries and 0 deaths.
Is the 2005 Itasca Sunova a reliable vehicle?
Its Safety Index is 41 out of 100 (grade C: about as many problems as a typical Itasca Sunova year, for its age). The index weighs complaints, crashes, fires, injuries, deaths and recalls against how long the vehicle has been on the road, compared with the same model's other years. It is not a measure of every repair - read the complaints and owner experiences, and have any used vehicle inspected before you buy.
Which Itasca Sunova years have the most complaints?
2003 (4), 2002 (2), 2005 (2). See every Itasca Sunova year compared.
What should I do if my 2005 Itasca Sunova has a problem?
If it is a safety problem, stop driving it if it is unsafe and contact your dealer. Report it to NHTSA at nhtsa.gov/report-a-safety-problem - enough reports start investigations and recalls - and share your experience here so other owners know what to look for.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data