2015 Mini Cooper Paceman Problems, complaints & recalls

Lower Engine Support and Passenger Engine Mount damaged as per routine inspection by dealer in Feb2025. Never diagnosed before. Repair done by independent service center in Feb2025 and I have receipt of approximately 1K. Also, since 22feb2025, I am not able to add fuel to the tank because the pump stops constantly and causes spill of fuel. This can cause fire. Never happened before. Tried at least 4 different gas station and same result. Dealer charges over $200 to perform inspection/diagnostics. Not done yet. Repairs to fuel tank are in the thousands. No warning in the car dashboard for none of the issues. Car with less than 80k miles.

While driving the rear view mirror suddenly tilted downward (drooped). What happened, was that the tension ring popped off. As it turns out, this is a known issue per internet Mini Cooper pages. On hot days the ring loosens and, since the design does not include anything to prevent the ring from sliding off, it does slide off, resulting in the rear view mirror drooping. I reinstalled the ring. This occurred again the next day. I ended up uninstalling the rear view mirror, reinstalling the ring and gluing it in place. Thus far this has held.

The contact owns a 2015 Mini Cooper. The contact stated that while driving at an undisclosed speed, the rear convertible glass suddenly separated from the convertible compartment and fell on the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or local dealer. The contact stated that while searching online, he became aware that the failure had been a very well-known failure since 2017 with similar vehicles. The manufacturer was made aware of the failure; however, no assistance was provided. The failure mileage was approximately 62,000.

The sensors do not work. The car does not tell me when oil is needed, when my tires are low. No sensors work in the car. The dealer, Mini Of Edison, states FOUND INTERNAL HARDWARE FAULTS. But are stating its costs 2300.00 to fix. This is a huge safety issue.Ive been having to guess when my oil is low and when my tires are low. This has been going on since September 2023, the car was only bought in May 2023.

The fuel filling nozzle turns off repeatedly while trying to fill the fuel tank and spills out causing a safety and environmental hazard, regardless of the pump being used. As a result, no fuel goes into the gas tank, instead it goes all over the car and the ground.

What component or system failed or malfunctioned, and is it available for inspection upon request? CONTROL ARMS AND BUSHINGS How was your safety or the safety of others put at risk? CONSTANT CREAKING AND CLUNKING OF FRONT SUSPENSION Has the problem been reproduced or confirmed by a dealer or independent service center? MANY OTHER OWNERS OF THE SAME YEAR AND GENERATION HAVE THIS SAME ISSUE Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? NOT YET Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NO

Without any warning lamps,The vehicle started pulling left when the brakes were applied a certified mechanic looked at it and feels that is the due to a defective DSC/ABS control unit. The unit hasn't been otherwise inspected but is available for inspection

Fuel tank causes gas pump to click off after dispensing a tenth gallon of gasoline. Gas spills from gas tank while removing pump creating a safety and environmental hazard. Fuel tank will not accept gas at pump. No warning lamps, messages, or symptoms were present prior to the failure. Mini Cooper dealership stated that service valve in tank has failed and entire fuel tank must be replaced.

While driving on freeway in 109 degree temp the service engine light came on. Proceeded with trip home (approx 2 hrs). Made a service appt online with Mini of Stevens Creek which was for 3 days later. Upon inspection it was found that vehicle had multiple problems. Service Advisor would not allow me to drive vehicle home while awaiting parts that were on B/O. Estimated it could be as long as 2 months before repaired because there were 391 units coming in next delivery but my vehicle was number 403 on the list requiring this part and would have to wait for the following months delivery. I was quite alarmed of the repairs needed since my vehicle has <28,000 miles and well maintained.

The contact owns a 2015 Mini Cooper. The contact stated that after the vehicle was taken to a local dealer for a routine oil change, the mechanic also determined that the valve cover gasket needed to be replaced and an unknown engine software needed to be updated. The vehicle was not repaired. The manufacturer was made aware of the failure, and the contact was advised to file a complaint with the NHTSA Hotline. The approximate failure mileage was 78,000.

The horn does no longer work. Had to press harder and harder on the horn button and in different places as time went on. Also have the same problem in a 2005 Mini Cooper.

When refueling, fuel is rejected after dispensing about 1/8 US gallons, about 4 oz. Of course, fuel spills are a hazard - both in possibly of fire, and to the environment - by contaminating ground water. Dealer said that there are several solenoid operated valves and replaced fuel tank and fill pipe, a cost to me of $2400.00. There are many reports of this on social media, one person suggested holding the fuel nozzle upside down which made a larger spill.

When refueling, nozzle kept shutting off, a gallon was pumped after nine attempts, also fuel erupted as the fill tube was filled with gas. reluctant to drive this car not knowing how much gas is in the tank. The needle shows less than 1/4 and miles remaining fluctuates between 80 and 110 miles. We are told that this problem exists in many mini automobiles, dealer has replacement gas tanks, but same problem exists Parking our Mini, indication of "roll back" is possible when car is parked. Shifter unit was replaced due to torsion spring.

The proportioning value that controls brake function had a catastrophic failure and caused the brake calipers especially the left front to lock suddenly. The caused the left front wheel to lock and caused the car to pull hard to left and become difficult if not impossible to control. The car pulled hard left and risked the car moving uncontrollably into on coming traffic. The failed part was saved and is available for inspection. The safety of the driver(my wife) was put at risk during the loss of control of...

On display I am getting warning " secure vehicle with parking brake when stationary" whereas my car is in park position with hand brake applied. The warning still shows up. The gearbox works fine the car drives fine. Its the warning that doesn't seem to go away. On diagnostics is shows code "420106" . DEFECTIVE GEAR SHIFT LEVER SPRING

On July 12 early morning hours I left Maryland drove to Augusta GA and continued on to Decatur GA totaling 704 Miles. Within an hour of me arriving to Atlanta, I attempted to leave the house again and the car would not crank. I had it towed to Global Mini there in Chamblee, GA. The key stopped communicating with the car, and I was asked to give them my spare key-I did not travel with my spare key and the key fob design does not have a replaceable battery per the dealership the fob is designed to charge while...

The fuel filling nozzle turns off repeatedly while filling the fuel tank, regardless of position of nozzle, pressure used, station used. In an attempt to remedy, Mini Service Technicians replaced tank vent valve but it did not correct the issue. I am unable to fill my gas tank.

I can not put gas into my car. I have had the charcoal canister replaced. I am now being told that I need a new fuel tank. I've also been informed that this is a reoccurring problem in 2015 mini coopers.

Fuel tank shuts off the gas pump no matter how much gas is in the tank. Faulty fuel tank vent (purge) value is causing the issue. This is a known issue on Mini's. A voluntary recall has been issued for 2016 Mini's, but this problem is also happening on 2015 Mini's. Dealership as well as another auto service store has replicated the issue. Check engine light is lit up as well.

Warning light to secure vehicle against rolling when placed in park. Alert of a danger situation.

Unable to fill gas as pump repeatedly shuts-off while trying to fill and would even over flow out of the filler neck. Tried 2 different pumps at local QT without luck.. Drove up to local Phillips 66 with exact same issue. Found several other owner with similar issue and found the following Service Bulletin posted on "NHTSA": https://static.nhtsa.gov/odi/tsbs/2015/MC-10147283-9999.pdf My vehicle build date is not covered under this Service Bulletin, however, suffering exact same issue.

Crankshaft Pulley burnt while driving. Could not accelerate. Car threw overheating codes and AC blew hot air. Battery Charging Malfunction error shown as well.

The contact owns a 2015 Mini Copper The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic and the contact was informed that the fuel tank needed to be replaced. The local dealer was not contacted. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failure. The failure mileage was 78,000. The Vin was not available

Fuel tank did not allow me to input fuel. Pump clicked off immediately. MINI issued a service bulletin on the problem in 2015. I have been advised the entire fuel tank must be replaced, and have heard from other MINI owners this is a systemic problem. If I had been traveling and this problem had surfaced I would have been stranded. The repairs warrant warranty coverage on the part of MINI. See service bulletin SI M16 01 15. https://static.nhtsa.gov/odi/tsbs/2015/MC-10147283-9999.pdf

Engine Mount and right control arm bushings have cracked and need to be replaced below 60,000 miles and only being 4 years old.