Mini Cooper Paceman Engine problems by year

The Environmental Air Catalyst (EAC) Sensor on my 2016 MINI failed two years ago when I had only 25,000 miles on the car. (The car now has 30,200 miles on it; I do not drive it very much). NHTSA worked with MINI/BMW several years ago, and MINI extended a limited warranty for this sensor to 15 years/150,000 miles, but only for Cooper "S" models. Mine is not an "S". See Recall "S1 M01 05 20" The S has a BMW "B46M PZEV/SULEV " engine, which is covered by the extended warranty. My car - not the "S" model - has the...

Lower Engine Support and Passenger Engine Mount damaged as per routine inspection by dealer in Feb2025. Never diagnosed before. Repair done by independent service center in Feb2025 and I have receipt of approximately 1K. Also, since 22feb2025, I am not able to add fuel to the tank because the pump stops constantly and causes spill of fuel. This can cause fire. Never happened before. Tried at least 4 different gas station and same result. Dealer charges over $200 to perform inspection/diagnostics. Not done yet. Repairs to fuel tank are in the thousands. No warning in the car dashboard for none of the issues. Car with less than 80k miles.

Oil filter housing failure. MINI issued a recall for this part in 2014 when the third generation MINI Cooper S/JCW first launched. Unfortunately they did not fix the part and now as time goes on, the issue is occurring with high frequency on every BMW/MINI and Toyota Supra with the BMW B46/B48 2.0L turbocharged engine. The plastic oil filter housings crack causing oil and coolant to leak. In my case oil poured down the front of the hot engine which could have caused a fire. BMW/MINI dealers charge nearly $2500 to...

Drivetrain error occurred. I pulled codes and found P0015. I added oil, cleared code. The next day the drivetrain error popped back up. Pulled codes and found P0366. I took the vehicle to mechanic for diagnostics and to find the issue. They found faults: 130F11 and 120408. When replacing engine oil and filter, they found metal shavings in the oil; bearing material. They are recommending replacing the engine. Doing research, it appears this has been a common occurrence with these vehicles/engines. Is there a current...

Had recurring engine warning light which will only reset for one ignition cycle. Took to dealer to read code and result was "LIN bus communication fault for environmental air catalyst sensor". This is the same problem drivers of the Mini Cooper S model have reported and received an extended warranty from Mini of North America (15 year / 150000 mi) with replacement of sensor and radiator. However, talking with Mini of North America, the extended warranty does not apply to the base model 5-door Cooper because not...

My Mini service adviser said the timing case cover is seeping and will continue to get worse until the seep becomes a leak and the oil starts dripping onto the manifold, potentially creating a fire. It is at the seepage stage now and therefore my extended warranty will not fix it. My Mini service adviser said she doesn't think it is dangerous yet but I have to keep an eye on it as this is a common problem on Minis. They quoted me a price of $934 to replace the timing case cover itself. I researched the problem online and found this is a common problem and will need my attention to ensure it doesn't get dangerous before I'm able to get it repaired.

Freeze plug randomly popped out while driving causing vehicle to stall in the middle of traffic almost causing a major accident and or death. Research indicates there has been numerous complaints by Mini Cooper owners experiencing the same issue of a premature unexplained failure with no action taken from Mini to mitigate this safety issue. I'm lucky to be alive.

Notes from Beckley Auto Service from 2-12-24. "Verified warning light on, retrieved one code for LIN bus communication fault for environmental air catalyst sensor. Checked and found technical service bulletin (TSB) from Mini Cooper M13 01 19. The chemical composition of the fan shroud contaminates the sensor. This repair involves the replacing of the radiator with each sensor and fan shroud. Should be covered under Mini Coopers emissions warranty. Called Mini Cooper of Des Moines(Jerimiah) and was advised...

The fuse box JBE module has a Quality Assurance problem with a solder connection to the NEC low pressure fuel relay. This is a known issue with BMW/Mini. The car suddenly stalls without warning. If the driver is not keen or if traffic patterns do not allow, the car can be left in very dangerous situations on the highway or in the middle of intersection. The repair for this problem is widely distributed online via blogs and YouTube, but replacement modules are $1500 (part only) and these modules are not...

The contact owns a 2015 Mini Cooper. The contact stated that after the vehicle was taken to a local dealer for a routine oil change, the mechanic also determined that the valve cover gasket needed to be replaced and an unknown engine software needed to be updated. The vehicle was not repaired. The manufacturer was made aware of the failure, and the contact was advised to file a complaint with the NHTSA Hotline. The approximate failure mileage was 78,000.

Transmission-get message when opening car door to put parking brake on to secure vehicle from rolling... Car does not roll, goes into gear with no problem... on the mini message board a lot of owners getting the same message....

The contact owns a 2014 Mini Cooper. The contact stated that while driving approximately 25 mph, there was smoke detected from the vehicle. The vehicle caught fire without warning. There were no reported injuries, air bag deployment, or crash. The fire department distinguished the fire. A police report was filed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The vehicle was towed to a lot. The manufacturer was not notified of the failure. The failure mileage was approximately 84,700.

Repeated experiences of sudden engine operational failure and reduced and/or complete loss of power while driving. The engine malfunction indicator lamp comes on. Car stalls and stops in traffic on the highway and on streets blocking traffic. Will not start again until powered off for periods between 5-15 minutes if at all. -First experienced the issue February 2020 and have intermittently experienced the same issue ever since. -Occurs when driving at a variety of speeds and a variety of fuel levels. -If...

The harmonic balancer aka crank damper went on my 2016 4dr hardtop 1.5L Mini Cooper. Has 73,000 miles on it. It has been sitting at a garage now for almost a month waiting for bmw to have the part in stock (tentative date avail. Sept.20, making it 2months wait time) tried every possible 3rd party parts dealer & not 1 harmonic balancer is to be found. I was told this part had already needed to be upgraded & modified making it a faulty part to begin with. Was told by garage it's a common part to go on these cars. ...

Crankshaft Pulley burnt while driving. Could not accelerate. Car threw overheating codes and AC blew hot air. Battery Charging Malfunction error shown as well.