2005 Porsche Boxster Engine problems

While I was driving on a city street at about 30 mph, my 2005 boxster started making a rattling noise, then completely died in the middle of an intersection on a city street without any prior warning. At the same time, all of the warning lights came on. I was able to put the car in neutral and coast to the side of the road. Car was towed to my mechanic, who states it is an intermediate shaft bearing issue/failure. Had I been driving on the freeway at high speed, I most likely would have been killed. I am the original owner of the car, it has 128,000 miles and recommended maintenance is all up to date.

Tl* the contact owns a 2005 porsche boxster. The contact stated while traveling approximately 55 mph, the engine made a loud noise, various warning lamps illuminated on the instrument panel and the vehicle stalled. The vehicle was towed to an independent mechanic. The technician diagnosed that the motor needed to be replaced. The independent mechanic suggested that the vehicle be taken to an authorized porsche dealer for repairs. The vehicle was towed to an authorized dealer who verified the failure and stated...

Pulling away from a green light in traffic, the engine started to upshift into a higher gear much sooner than normal and the car felt down on power. The engine sounded as though it was running on fewer than normal cylinders. I stopped the vehicle immediately & had it towed to a porsche specialist. They told me it was an ims (intermediate shaft) bearing failure and that is was a known problem with m96 and m97 porsche engines. Mine being an m96 engine. *Tr

This is a very well know ims failure issue with porsche boxster which certainly calls for a recall from porsche. My 2005 engine will need to be replaced for 20k just because of the very obvious design flaw porsche has in its m96 engines. I am pretty sure there have been numerous complaints about this in past but nobody has ever heeded to it. I sincerely recommend some one to please look into and ask porsche to accept and recall m96 engines failing due to ims. Any car expert or mechanic or dealership can vouch for the design flaw porsche has. Its potentially fatal too. I sincerely request someone to look into this complaint with uttermost sincerity. *Tr

While pulling away from a stop light in light city traffic, engine suddenly had reduced power output immediately followed by loud sounds of loose metal parts through out the engine compartment. Upon inspection by a porsche specialist, he determined that the engine had suffered intermediate shaft failure which caused catastrophic engine failure by allowing the valves to make contact with the piston heads and shredding ball bears which sent metal shaving through the oiling system. The engine is considered non-repairable and requires a complete replacement engine.

Catastrophic engine damage due to intermediate shaft bearing failure. There are no signs that the part will fail. There is a grinding noise in the engine and upon stopping all the oil leaks out. As soon as the noise is heard, the engine is irreparable damaged. Instant, catastrophic damage. Engine is a total loss. Bearing is a defective design and has been redesigned in newer models. *Tr

Traveling 75mph on freeway when oil & engine lights came on and vehicle simultaneously came to dead stop in traffic; diagnosed as catastrophic engine failure by dealer service mgr., Engine replaced at cost of $17,000+. No prior warning. No fault of my own per svc.Mgr. 38K miles on 2005 vehicle, 3 mo out of warranty. Many similar incidents reported on several web sites. Service mgr reported porsche well aware of this issue but does nothing because its too costly to repair and prefers to handle on case by case...

My 2005 porsche boxster, 23k mi, had catastrophic engine failure at idle. The engine stalled;i was able to restart but a loud clanging noise came from engine. The car then died again. The mechanic said it was due to an intermediate shaft (ims) failure; the required engine replacement is $14k. The mechanic said he has heard of significant number of ims failures (but porsche has not notified owners). There were no injuries, but certainly engine failure like this could have serious consequences at freeway speeds. Porsche forums on internet show frequency of failures from this defect (poorly designed bearing assembly on ims) is very high, as much as 8-11% in one forum poll. *Tr

Vehicle was 2005 porsche boxster. Car engine self-destructed while driving highway at 70 mph. Cause was failure of intermediary shaft bearing at 29,000 miles as determined by engine dissembly. Car had been properly maintained and serviced by porsche facilities for its life. Intermediary shaft failed after bearing failed, sending metal pieces throughout engine including into oil sump. Timing belt perforated camshaft cover. Engine was irreparable. There are many other reports on internet sites, easily searchable, for "porsche engine failure" of this type. *Tr

2005 Porsche boxster. Consumer states engine made grinding a sound and would not start *tgw the consumer had the vehicle towed to the dealer, where he was informed the vehicle needed a new engine. The consumer stated no one could provide an explanation as to why a vehicle with such low miles would need a new engine. *Jb

I was driving on the inner lane of the freeway at 65mph. The engine suddenly stalled and the check engine light started flashing. I managed to have the car sliding toward the shoulder and get off freeway. The car wasn't able to restart again. A highway patrol came by and helped to push my car to wilder shoulder for safety. The rear bumper was damaged in the process. The car was towed to the dealer for inspection and still in the shop now. The mechanist said the engine need to be replaced. *Tr

Dt*: the contact stated while driving 35 mph on normal road conditions, and when stationary, there was a very distinct fume smell coming from the engine compartment. The smell was noticeable and came in through the vents. There were no warning signals prior to the incident. The vehicle was taken to a dealer several times, where they replaced the left and right cylinder head cover; cylinder head cup shield, manifold fuel gasket and the exhaust gasket but the smell persisted.

Dt*: the contact stated while driving various speeds on normal road conditions or when stationary, there was a smell of fuel coming from the engine compartment. The smell was noticeable and came in through the vents. There were no warning signals prior to the incident. The vehicle was taken to a dealer several times, who replaced the left and right cylinder head cover. Also, the cylinder head cup shield, manifold fuel gasket and the exhaust gasket were replaced, but the smell persisted.