Rexhall is recalling 36 my 2005 aerbus, american clipper, base camp, rexair, sanscape, and vision motor homes equipped with a two-door refrigerator manufactured by the dometic corporation. The refrigerator may have a defect in the boiler tube. Pressurized...
1994-2005 · 11 model years
Rexhall Aerbus Problems by year
Owners have filed 24 complaints about the Rexhall Aerbus across 11 model years, and it has 6 recalls. The 1999 has the most complaints once its age is allowed for (5). The most reported problem area is the brakes, followed by the equipment & accessories.
- Complaints
- 24
- Recalls
- 6
- Crashes
- 1
- Fires
- 1
- Injuries
- 0
- Deaths
- 0
Aerbus complaints by model year
Highlighted: the year with the most complaints for its age. Older vehicles have had more time to collect complaints - the Safety Index grade allows for that.
Most common Aerbus problems
Rexhall Aerbus recalls 6
Rexhall is recalling 6 motor homes equipped with norcold refrigerators. A fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak.
Covers2005 Rexhall Aerbus
On certain motor homes equipped with a two-door refrigerator manufactured by the dometic corporation, the refrigerator may have a defect in the refrigerator boiler tube. Pressurized coolant solution could be released into an area where an ignition source...
Certain motor home chassis fail to comply with the requirements of federal motor vehicle safety standard no. 105, "Hydraulic and electric brake systems." The brake system warning indicator may not function as required by standard.
Vehicle description: motor homes. The drive shaft bolts can come loose at the transmission and fall off. When the drive shaft separates from the transmission, the forward end of the shaft can drop to the ground, or come through the floorboards of the...
The awnings for the slide-out room can unfurl or unroll during transit causing the bracket to rip free of the sidewall of the vehicle.
Latest Aerbus complaints
Battery disconnect failed while driving our 20,200 pound rv at highway speed. The failure resulted in total loss of chassis power (engine stopped, power steering ceased, power steering ceased, all dash indicators non-operational, emergency flasher non-operational, etc.). The failure caused us to coast to a stop as there was nothing else we could do. The failed part was later identified as: battery disconnect solenoid (intellitec 01-00055-002 04098 bcc relay (printed on sticker placed on top portion of unit),...
Read the full complaint
612-12v 797 (printed on bottom of unit). The battery disconnect service manual, p/n 53-00066-100, rev b, 030905 fails to list total loss of power while in motion as a potential problem. *Tr
Automatic parking brake on chevrolet p30 chassis 1994 through 1998 motorhomes comes on while in forward or reverse unexpectedly. The brakes lock up, stopping vehicle at any time and unable to move. This is a very serious danger to everyone. Please see all of the complaints listed on the internet. Type in auto parking brake problems on 1997 chevrolet p30 chassis. Hundreds of complaints and general motors doing nothing about it. *Tr
Tl*the contact owns a 2003 rexhall aerbus rv. The contact stated that she received a recall notice on the refrigerator. The serial and part numbers were not available. The manufacturer was notified and offered no assistance in finding a way to get the refrigerators replaced although it could cause a fire to occur. The contact took the rv to a technician who tried to contact norcold who hasn't responded for three weeks.
Tl*the contact owns a 2002 rexhall aerbus rv. While the contact was driving approximately 65 mph the brake pedal traveled to the floor when pressure was applied to it. The vehicle was able to come to a stop after being driven closely against the curb. The vehicle was taken to the dealer. The failure was contributed to the right front wheel brake line in which the metal cracked allowing the brake fluid to leak. The dealer replaced the right front wheel hose. The service repair cost was $550. The manufacturer was notified and the warranty had expired. The failure and the current mileages were 26,000. Updated 6/1/10 *cn updated 06/04/10.
Brakes,50,000 motorhomes with bad brakes. I received a informal recall 18 months ago. I have pictures of the faulty brakes, dime size cracks in the rotors, rotors that are blue from heat. They were replaced with the same equipment that failed. I'll e-mail them to you. Will someone have to die before freightliner and bosch resolve the problem? *Tr
Tl*the contact owns a 1997 rexhall aerbus. The contact received a recall notice for the vehicle speed control: cruise control in september of 2007. The cruise control was disconnected in october of 2007. The contact called the dealer twice and was informed that the part was unavailable. There had been no failure to date. The current mileage was 60,000. Updated 04/21/08 *bf
Questions about the Rexhall Aerbus
Which Rexhall Aerbus years have the most problems?
Which Rexhall Aerbus years have the fewest complaints?
What are the most common Rexhall Aerbus problems?
Across every model year, owners report problems with the brakes (7), equipment & accessories (6), transmission & drivetrain (5) most often.
How many recalls does the Rexhall Aerbus have?
NHTSA lists 6 recalls across all Rexhall Aerbus model years. Each year's page lists the recalls for that year; check your own vehicle by VIN at nhtsa.gov/recalls to see whether the repair has been done.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked daily. Complaints are owners' own reports and are not verified. How we use the data