Nothing, thank god had happened yet, but it will in a matter of time, how much time I have no idea. The problem is the motor cradle or frame is rusting out, the front where the motor sets had wholes rusted in it, the whole thing is rusting away.
Body, doors & structure
Saturn LS Body problems by year
29 complaints filed with NHTSA about the Saturn LS's body, doors & structure. Doors, hoods and latches, frame rust, sunroofs, leaks, trim and structural failures.
Body complaints by model year
| Year | Body complaints | Crashes | Injuries | Recalls |
|---|---|---|---|---|
| 2000 | 29 | 2 | 4 | 0 |
Latest LS body complaints
Tl* the contact owns a 2000 saturn ls. While driving approximately 25 mph, the contact noticed an abnormal noise from both the front passenger and driver sides of the vehicle. In addition, the contact stated that the steering wheel was difficult to turn. The vehicle was taken to an independent mechanic who diagnosed that there was corrosion around all of the wheel wells and the subframe needed to be replaced. The vehicle was not repaired. The vin was unknown. The failure mileage was 150,000.
I was driving a 98 toyota tacoma on a 45 mph highway when a pedestrian in the road caused all lanes of traffic to suddenly stop. I was unable to stop in time and went into the median to avoid an accident. I was unable to keep my vehicle in the median and struck the 2000 saturn coupe drivers side fender to drivers side fender. Upon impact the body of the saturn burst into 12 to 14 inch shards of whatever the body is made of, (perhaps fiberglass or something similar). One such shard shattered the drivers window...
Read the full complaint
and impaled me through my left shoulder and lodged itself protruding slightly from my back. The emergency responders were unable to stop the bleeding so I was airlifted to ormc for emergency surgery, and am lucky to have survived. The surgeon stated that another inch would have meant me bleeding out in the road. That vehicle should not have shot deadly projectiles upon impact. *Tr
When I went to get new tires for this car I was told there was a problem with my frame and should go right to a dealership. I contacted saturn and they authorized it for me to go to my nearest dealership, at the dealers convenience and my expense for a review of the problem. I made the appointment but in the mean time the front wheels stated to shake and shimmy. I was losing control of the car, so I pulled into the nearest repair shop and was given the advice to leave this car parked. Do not drive it at all. ...
Read the full complaint
Contacting saturn at this point they refused to even look into this problem. Never have I heard of a frame supporting the engine, and front wheels ever rusting through on a car before. They said it was my choice to have it fixed, therefore they had no obligation to look into this any longer. I believe I had no choice other than to get it fixed right there and then. Not only because it had to be done but for the safety of my family. *Tr
Driving down the road the vehicle started making noise and steering was uncontrollable. I trailered the vehicle back home. Closer inspection revealed the front subframe/engine cradle was completely rusted through in multiple spots, very dangerous!!! I contacted the dealer to get a new subframe and I was advised the subframe is no longer available and to try finding one in a salvage yard. I contacted a salvage yard and they said they had a few and it would be no problem to pull one. I got the call today saying...
Read the full complaint
they were sorry but all of the front subframes on the saturn l series they have are rusted through and are not usable. I contacted other yards with the same response. I ended up having to find a salvage yard down south that had a usable subframe. I went online to find numerous forum posts discussing this topic and I'm finding it is very common on this vehicle. Why was there never a recall for this with such a widespread safety hazard? From what I can tell it happens on all model years of the l series. The irony is the rest of the car is very clean, no rust on the rest of the undercarriage. There is no clear explanation why the subframe would have corrosion perforation at such low mileage with no other rust/corrosion on the rest of the vehicle. At a higher rate of speed this could have had a bad outcome. Thank you. *Tr
MY SATURN HAS A MASSIVELY RUSTED SUBFRAME. *TR
Subframe on saturn totally rusted away only thing holding passenger wheel on was strut bracket. *Tr
Tl* the contact owns a 2000 saturn lseries. The contact stated that while traveling 45 mph, the vehicle began independently steering to the left. The vehicle was taken to a local repair shop where it was confirmed that the failure was caused by corrosion of the sub frame. The manufacturer was not made aware of the failure. The vehicle was not repaired. The failure and current mileages were 165,000. Updated 10/25/12 *cn updated 11/08/12 ..Updated 11/14/12 *bf updated 11/15/2012 *js
Tl* the contact owns a 2000 saturn ls1. The vehicle was taken to an independent mechanic for an unrelated problem and the technician noticed that the frame was completely corroded. The vehicle was not repaired. In addition, the vehicle lunged forward independently. The failure occurred four times. The manufacturer was notified of the defect. The approximate failure mileage was 60,000. The vin was unavailable.
Tl* the contact owns a 2000 saturn lw1. The contact stated that the vehicle was being inspected when the contact was advised that rear frame was severely corroded. The vehicle was not taken to the dealer for inspection or repairs. The failure and the current mileage was 105,063.
This happened very suddenly. I applied the brake to enter the ramp to the highway and the car pulled to the left and made a noise. I thought it may be a bearing or brake problem but I had not had any issues before that so I went on since it seamed to be driving ok. While I was on the interstate I went to go into the left lane and realized there was a serious problem with the steering. I slowed down and got off the highway to the shop. I was told there the k frame had less than 1/2" before breaking completely and...
Read the full complaint
could have been a serious accident since it has to do with steering. I have regular maint on the car and there was no indication that this might happen. The underside is in very good shape. I had the frame replaced. I feel it was a defect in the frame. I'm sure im not the only one this has happened too. *Kb
The front subframe rusted through. Mechanic stated was not normal wear. *Tr
Vehicle pulled when braking. Symptoms started on a monday as a light pull. More noticeable above 50 mph, and not noticeable below 35. By thursday morning, pull was severe above 50mph. Stayed till after 6:00 at night to avoid traffic. Ride home was "entertaining" as steering wheel did not always go back to "center" when going straight. I thought I needed a steering rack until I inspected the vehicle on saturday. My inspection showed that front subframe (a.K.A. Engine cradle) failed where the "passenger...
Read the full complaint
side lower control arm rear bushing was attached". A sizable piece of frame ripped out, with bushing still attached to lower control arm. Rusted perforations in subframe visible approximately 6" behind where frame failed. Two sets of rims (summer and winter) with no "dings" testifies that vehicle never even hit a curb in 170,000 miles. 4 Cylinder, so no exhaust nearby to "weaken steel". Bad choice of corrosion protection in a critical part of the frame, and/or undersizing of steel thickness to accommodate for corrosion is my estimate of "failure mode". Contacted dealer and no replacement parts available. Well maintained vehicle, very disappointed it failed this way. Last vehicle I junked was a 17 year old 1973 olds. Everything but the subframe indicated I'd get another 5 years out of this vehicle. *Tr
4 Cylinder shot, engine shot.This 2000 ls2 v-6 had the whole 100,000 mile maintenance done, timing chain bla bla bla.Electric windows,4 ways hazards, turn signals,engine,a/c-heater,blower motor,handles broke-interior only,car ran good when it ran but when it stopped it always costs money. *Tr
Tl*the contact owns a 2000 saturn ls1. While parked on the side of the road due to icy conditions, a semi-truck lost control while driving up an incline. The semi-truck was headed directly towards the contact's vehicle, so he jumped out of the passenger side and fell into a ditch. The semi-truck struck the front corner panel of the contact's vehicle and placed a few dents in the door. When the contact jumped out of the vehicle, all of the doors automatically locked and prevented him from re-entering. He...
Read the full complaint
sustained hip and minor spine injuries, for which he is currently being treated. Throughout the entire incident, the air bags in the vehicle never deployed. He believes that had he remained in the vehicle with the air bag failure, he could have suffered major injuries. He called the manufacturer and was informed that nothing could be done about the vehicle. The vehicle was completely destroyed. A police report was filed. The vin was unknown. The current and failure mileages were 150,000.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked daily. Complaints are owners' own reports and are not verified. How we use the data