- The problem
- Daimler trucks is recalling 243,435 my 1995-2008 thomas built school buses manufactured between january 1994, and march 10, 2008. (Additional buses have been added to this recall campaign. Please see supplemental report no. 4) The emergency exit door handle begins corroding around the securing roll pin and square drive mechanism causing the protective finish to chip and flake. Continued corrosion and pitting weakens the handle. Handles weakened by corrosion may break while trying to open the door from the exterior.
- The risk
- In the event of an emergency, a person on the outside of the bus may break the door handle trying to open the emergency exit potentially delaying evacuation and increasing the risk of personal injury to the vehicle's occupants.
- The fix
- Daimler trucks will notify owners and will replace the handles with a more robust handle free of charge. Repairs will be performed by thomas built buses dealerships. The recall began on august 18, 2008, and notification for the revised population is expected to begin on or about april 29, 2009. Owners may contact thomas built at 336-889-4871.
Vehicle safety record
2003 Thomas MVP EF Problems, complaints & recalls
No owner complaints about the 2003 Thomas MVP EF have been filed with NHTSA. It is covered by 6 recalls, the latest in February 2008 for the hinge and attachments.
NHTSA data checked
CAbout as many problems as a typical MVP EF year, for its age
- Complaints
- 0
- Recalls
- 6
- Crashes
- 0
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
2003 Thomas MVP EF recalls 6
Recall repairs are free. Your dealer fixes them whether or not you bought the car there - check your VIN at nhtsa.gov/recalls to see if yours is done. What to do
- The problem
- Certain 2001 through 2008 thomas built fs-56, er, mvp er, hdx, and mvp ef school buses manufactured from october 23, 2000, through january 24, 2006, equipped with tyco pc board and type ii auto reset circuit breakers. Type ii auto reset circuit breaker temperatures may exceed the rating of the tyco pc board causing the boards to melt potentially resulting in a vehicle fire.
- The risk
- A vehicle fire can occur possibly resulting in a crash.
- The fix
- Thomas built will notify owners and repair the buses by replacing the type ii auto reset circuit breakers with manual circuit breakers, and the jumper cable. The recall began on march 28, 2008. Owners may contact thomas built customer support office at 336-889-4871.
- The problem
- Certain 2002-2005 my thomas built minotour, conventional, mvp-er, er, hdx, and mvp-ef model school buses manufactured between january 8, 2002, and march 8, 2005, equipped with specialty mfg "5" series stop arms originally sold in or currently registered in states other than the following states: alaska, colorado, connecticut, delaware, idaho, illinois, indiana, iowa, kansas, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, montana, nebraska, nevada, new hampshire, new jersey, new mexico, new york, north dakota, ohio, oregon, pennsylvania, rhode island, south dakota, tennessee, utah, vermont, virginia, washington, west virginia, wisconsin, wyoming, and the district of columbia. In extremely cold weather, the microswitches used internally to position the stop arm sign in the open and closed positions may malfunction, causing the sign to open or close in an improper position, or to not open at all.
- The risk
- Should the stop arm not perform properly, a child or pedestrian may be endangered by passing vehicles should the motorist not stop at the correct location.
- The fix
- For those buses operated in or near any of the states listed above, thomas built is encouraging the bus owners to obtain the replacement switch. For those buses operated in the warmer states, dealers will replace the switch upon owner request. For those customers who request the remedy, thomas built will replace the original switch with a switch pack that is not sensitive to extreme cold weather and will inspect to ensure the microswitch heater wiring is properly connected. The recall began on september 14, 2005. Owners may contact thomas built's customer support office at 336-889-4871.
- The problem
- Certain 2002-2005 my thomas built minotour, conventional, mvp-er, er, hdx, and mvp-ef model school buses manufactured between january 8, 2002, and march 8, 2005, equipped with specialty mfg "5" series stop arms originally sold in or currently registered in the following states: alaska, colorado, connecticut, delaware, idaho, illinois, indiana, iowa, kansas, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, montana, nebraska, nevada, new hampshire, new jersey, new mexico, new york, north dakota, ohio, oregon, pennsylvania, rhode island, south dakota, tennessee, utah, vermont, virginia, washington, west virginia, wisconsin, wyoming, and the district of columbia. In extremely cold weather, the microswitches used internally to position the stop arm sign in the open and closed positions may malfunction, causing the sign to open or close in an improper position, or to not open at all.
- The risk
- Should the stop arm not perform properly, a child or pedestrian may be endangered by passing vehicles should the motorist not stop at the correct location.
- The fix
- Thomas built will notify its owners and replace the original switch with a switch pack that is not sensitive to extreme cold weather and will inspect to ensure the microswitch heater wiring is properly connected free of charge. The recall began on september 14, 2005. Owners may contact thomas built's customer support office at 336-889-4871.
- The problem
- Certain 1998-2003 my freightliner fs-65 school bus chassis and mb-45, mb-55, and xb shuttle bus chassis, and thomas built bus: mvp-er and mvp-ef school bus and non-school bus models equipped with cummins isb diesel engines and equipped with federal-mogal 12 and 24 volt fuel lift pumps. The fuel pump could fail to transfer fuel appropriately creating an engine stall condition.
- The risk
- Should the engine stall while the vehicle is in use, a possible vehicle crash could occur.
- The fix
- Cummins will notify the customers of freightliner and thomas built and replace the fuel lift pump free of charge. Owners may contact cummins at 1-800-diesels.
- The problem
- Certain 2001-2004 my thomas built mvp-ef, er transit, mvp-er, hd, and hdx school buses manufactured between september 24, 2000, and march 4, 2004. The tie rod assembly can fracture and fail, possibly resulting in complete separation.
- The risk
- Tie rod failure can possibly result in complete wheel separation and a vehicle crash could occur.
- The fix
- Thomas built will notify its customers and will replace the tie rod assembly free of charge. The recall began september 6, 2005. Owners may contact thomas built at (we do not yet have a telephone number).
What owners say
Be the first MVP EF owner to share.
Problems or none - your experience is exactly what the next buyer is looking for. Write it now
No complaints about the 2003 Thomas MVP EF yet
No owner has filed a complaint about this vehicle with NHTSA. If yours has a problem, share it here and report it to NHTSA.
Thomas MVP EF: every year compared
All MVP EF years2003 Thomas MVP EF vs rivals
| Vehicle | Complaints | Recalls | Grade | |
|---|---|---|---|---|
| 2003 Thomas MVP EF | 0 | 6 | C | |
| 2003 Thomas ER | 1 | 6 | D | Compare |
More sales usually means more complaints, so compare similar vehicles of the same year. The grade compares each vehicle with its own model's other years.
Questions about the 2003 Thomas MVP EF
Does the 2003 Thomas MVP EF have any recalls?
Yes - NHTSA lists 6 recalls for the 2003 Thomas MVP EF: hinge and attachments (February 2008); fuses and circuit breakers (November 2007); school bus stop arm assembly (August 2005); school bus stop arm assembly (July 2005) and more. Recall repairs are free at any authorized dealer. Enter your VIN at nhtsa.gov/recalls to see whether yours has been fixed.
How many complaints has the 2003 Thomas MVP EF had?
None have been filed with NHTSA so far.
Is the 2003 Thomas MVP EF a reliable vehicle?
Its Safety Index is 50 out of 100 (grade C: about as many problems as a typical Thomas MVP EF year, for its age). The index weighs complaints, crashes, fires, injuries, deaths and recalls against how long the vehicle has been on the road, compared with the same model's other years. It is not a measure of every repair - read the complaints and owner experiences, and have any used vehicle inspected before you buy.
Which Thomas MVP EF years have the most complaints?
1998 (3), 1997 (2), 1996 (1). See every Thomas MVP EF year compared.
What should I do if my 2003 Thomas MVP EF has a problem?
If it is a safety problem, stop driving it if it is unsafe and contact your dealer. Report it to NHTSA at nhtsa.gov/report-a-safety-problem - enough reports start investigations and recalls - and share your experience here so other owners know what to look for.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data