Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2026-2027 Zephyr, Wayfarer, Phaeton, Open Trail, GT1, Allegro Red, Allegro Open Road, Allegro Bus, Allegro Bay, 2026 Midas, Byway, and Allegro Breeze recreational vehicles, equipped with certain MaxxAir...
1999-2027 · 27 model years
Tiffin Zephyr Problems by year
Owners have filed 5 complaints about the Tiffin Zephyr across 27 model years, and it has 28 recalls. The 2008 has the most complaints once its age is allowed for (1). The most reported problem area is the body, doors & structure, followed by the steering.
- Complaints
- 5
- Recalls
- 28
- Crashes
- 0
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
Zephyr complaints by model year
Highlighted: the year with the most complaints for its age. Older vehicles have had more time to collect complaints - the Safety Index grade allows for that.
Most common Zephyr problems
Tiffin Zephyr recalls 28
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2025 Zephyr motorhomes with floorplan 45PZ. The secondary emergency exit is incorrectly located on the same side as the primary emergency exit.
Covers2025 Tiffin Zephyr
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2022-2025 Phaeton, Allegro Bus, and Zephyr motorhomes. The PowerGlide chassis controller may have insufficient circuit protection, which can result in a blown fuse and cause an engine shutdown.
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2022 Allegro Bus, Phaeton, Allegro Red 360, and Zephyr motorhomes. The pedestal mounting plate on the driver's seat may be improperly welded, which can cause the plate to separate and the seat assembly to...
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2016-2024 Allegro Bus, and 2017-2024 Zephyr motorhomes. The 240-Volt induction cooktop may not be grounded, which can create an electrical shock hazard if the wires short-circuit.
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2022-2023 Phaeton, Allegro Bus, and Zephyr motorhomes built on PowerGlide chassis. A fuse will trip during an a/c compressor failure, causing a loss of power to the chassis.
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2022 Zephyr, 2022-2023 Phaeton, Allegro Breeze and Allegro Bus motorhomes equipped with a Powerglide chassis. The chassis fuse can overheat while the motorhome is in motion, possibly causing the dash...
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2022 Allegro Breeze, Allegro Red, Allegro, Allegro Bus, Phaeton, and 2018-2021 Zephyr recreational vehicles. The sofa seat belts may not have been installed correctly, which could result in unsecured...
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2019-2020 Tiffin Bus and 2018-2020 Zephyr motorhomes. The windshield wipers may not work due to the control module being improperly wired.
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2019 Phaeton, Allegro Bus, and Zephyr motorhomes. The alternating current electrical wires may have been improperly secured in the Energy Management Module, causing increased electrical resistance.
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2019 Tiffin Allegro RED, Allegro Open Road, Breeze, Bus, Phaeton, and Zephyr motorhomes. The entry door on these vehicles may have been improperly assembled, allowing the door to open while the...
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2009-2018 Allegro and Allegro RED, Bus and Phaeton vehicles, 2009-2010 Bay vehicles, 2011-2018 Breeze vehicles, and 2009-2015, and 2017-2018 Zephyr vehicles. These motorhomes are equipped with Kidde...
Latest Zephyr complaints
Steering gear play -- problem brought to the attention of spartan, including trip to service center at charlotte, mi. -- Had tie rod ends replaced, new shocks, all wheel alignment, -- recently had recall completed on steering gear bracket. Have excess play in steering wheel, approximately 2" of play in the steering wheel before the tires turn. I'm constantly correcting steering in a cross wind or navigating construction areas where uneven pavement is encountered. There is a safety concern and potential of a wreck.
Tl* the contact owns a 2013 tiffin zephyr. The contact stated that while driving 15 mph, the slide out section independently opened and caused the vehicle to vibrate. The vehicle was taken to the dealer for inspection but they could not determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 3,200. Updated 11/14/13*cn the consumer stated the rv was sent to the factory three(3) times and none of the repairs were fixed. Updated 11/25/2013 *js
The coach's storage door leaked which caused the wiring, fuses and 2000 amp inverter to get wet. This resulted in shorts and electrical failures. *Nm the electrical failure included the windshield wipers, turn signal, dash gauges, headlight and taillights (2002 tiffin zephyr). *Nm
Re notice of defect which could cause a crash or injury or death pursuant to c.F.R. 575.6. *Bf manufacturer did not incorporate the specific statement and hotline telephone number required by nhtsa in the owners manual regarding safety concerns and notifications as set forth in cfr 575.6. Attempts made by the manufacturer to install an after market stabilizer to address complaints that the motor coach would wander in and out of lanes of traffic were unsuccessful. *Tc
Driver's side windshield was defective. Consumer was told the first time to have the windshield repaired at no cost. That was done, and currently the windshield was defective again.*Ak
Questions about the Tiffin Zephyr
Which Tiffin Zephyr years have the most problems?
Which Tiffin Zephyr years have the fewest complaints?
What are the most common Tiffin Zephyr problems?
Across every model year, owners report problems with the body, doors & structure (2), steering (2), visibility & wipers (2) most often.
How many recalls does the Tiffin Zephyr have?
NHTSA lists 28 recalls across all Tiffin Zephyr model years. Each year's page lists the recalls for that year; check your own vehicle by VIN at nhtsa.gov/recalls to see whether the repair has been done.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked daily. Complaints are owners' own reports and are not verified. How we use the data