The steering bevel gear assembly may have water contamination which could lead to rust/corrosion.
1984-1994 · 8 model years
Toyota Van Problems by year
Owners have filed 35 complaints about the Toyota Van across 8 model years, and it has 3 recalls. The 1986 has the most complaints once its age is allowed for (9), while 1990, 1994 have far fewer than a typical year. The most reported problem area is the electrical system, followed by the engine & cooling.
- Complaints
- 35
- Recalls
- 3
- Crashes
- 5
- Fires
- 8
- Injuries
- 5
- Deaths
- 0
Van complaints by model year
Highlighted: the year with the most complaints for its age. Older vehicles have had more time to collect complaints - the Safety Index grade allows for that.
Most common Van problems
Toyota Van recalls 3
The center control arm of the steering linkage system may develop a crack if the steering wheel is repeatedly operated while vehicle is in parked position. The steering center arm may eventually break...
Voltage regulator which controls the amount of flow in the electrical system between the battery and the alternator, may have manufacturing errors in an integrated circuit. The regulator may overcharge the battery.
Latest Van complaints
Sliding door will pop open while driving, not close completely and motor reopens it. The first has happened 3 times so we turned off the door. The second happens every time we use the door with the motor on. Toyota says this is normal wear and tear. Started after only 1.5 Years of use... All other doors are fine. We were already out of mileage warranty. Will cost over $1500 to repair door. *Tr
1998 Toyota sienna engine failed due to "sludge." Upon researching this issue, I have found that many others have experienced a similar failure. The information in regards to this problem were never communicated to the owners of these vehicles. *Tr
WHILE PARKING VEHICLE LOST POWER STEERING. *AK
Consumer stated when braking, there is a loud noise coming from the rear of the vehicle.*Jb
1985 Toyota van with power steering. Part of linkage called center arm snapped in half while traveling at approximately 55 mph during turning. There was immediate loss of steering control. No bodily injury occurred, but had this occurred at freeway speed, I would undoubtedly be dead. *Ts ***dimsii ivoq entry posted after 12-12-02 cut over to artemis***761467
Consumer noticed fire coming out of the front wheel well area, consumer heard 2 explosions, consumer suffered burns to left hand, fire investigator was unable to determine cause, possible engine failure. *Tt
Questions about the Toyota Van
Which Toyota Van years have the most problems?
Which Toyota Van years have the fewest complaints?
What are the most common Toyota Van problems?
Across every model year, owners report problems with the electrical system (8), engine & cooling (6), steering (6) most often.
How many recalls does the Toyota Van have?
NHTSA lists 3 recalls across all Toyota Van model years. Each year's page lists the recalls for that year; check your own vehicle by VIN at nhtsa.gov/recalls to see whether the repair has been done.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked daily. Complaints are owners' own reports and are not verified. How we use the data