- The problem
- On certain motorcycles, some of the fuel supply hose leading from the fuel tank to the fuel rail may be incorrect for use in a pressurized fuel system application.
- The risk
- Incorrect hoses may leak fuel or crack. Fuel leakage, in the presence of an ignition source, could result in a fire.
- The fix
- Dealers will inspect the markings on the fuel hose to determine if replacement is required. If necessary, dealers will replace the fuel hose with a new one of the correct material. The recall began on august 1, 2005. Owners may contact victory at 1-763-417-8650.
Vehicle safety record
2005 Victory Hammer Problems, complaints & recalls
Owners have filed 6 complaints about the 2005 Victory Hammer with NHTSA, most often about the transmission & drivetrain (2) and the suspension (2). It is covered by 2 recalls, the latest in July 2005 for the hoses, lines / piping, and fittings. For comparison, the 2006 has 2.
NHTSA data checked
FFar more problems than a typical Hammer year, for its age
#244 most complained-about 2005 vehicle
- Complaints
- 6
- Recalls
- 2
- Crashes
- 0
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
Most common 2005 Victory Hammer problems
Share of all 6 complaints. One complaint can name more than one area. Tap an area for its complaints and recalls.
2005 Victory Hammer recalls 2
Recall repairs are free. Your dealer fixes them whether or not you bought the car there - check your VIN at nhtsa.gov/recalls to see if yours is done. What to do
- The problem
- On certain motorcycles, the camshaft chain drive sprocket located on the crankshaft may have cracked upon installation.
- The risk
- If cracks are present, the sprocket may fail during operation. Sprocket failure could cause the engine to lock up which could result in loss of operator control, increasing the risk of a crash.
- The fix
- Dealers will remove the lower right engine cover, inspect the sprocket for cracks, and replace the engine or the necessary components free of charge. The recall began on june 10, 2005. Owners may contact victory at 763-417-8650.
What owners say
Be the first Hammer owner to share.
Problems or none - your experience is exactly what the next buyer is looking for. Write it now
6 complaints about the 2005 Victory Hammer
Newest first, as filed with NHTSA by owners.
This is a victory motorcycle. When downshifting to arrive at a light I heard a clunk in the transmission area. Shifting became impossible within a few minutes. The motorcycle was towed to a victory dealer in harrisonburg, va and 2 weeks later I was informed that one of the shift fork broke and fell into the transmission and ground up 2 gears. Also informed that the clutch was burned. Although this motorcycle is 10 years old, it only had 5330 miles on it and was regularly serviced. From my understanding shift...
Read the full complaint
forks do not just break. I believe either the part was defective or the design was defective. This is a very dangerous condition as the motorcycle would have locked up and thrown me off if the break had occurred while I was moving at regular highway speed. Please investigate this dangerous part and condition. Thank you. Update 9/15/15*cw updated 12/12/2017*cn
During a routine tire change, the tech notified me of a crack in my swingarm. After he showed it to me they located a take off (a used) from someone who wanted a chrome swingarm instead of black. I was offered that used swingarm at a good price and had it swapped. I went back and brought home the original (cracked) swingarm. I have it and have pictures too. *Tr
2005 Victory hammer premium being driven on an interstate traveling 65 mph went over a dip in the road. The rear tire suddenly began to drag and lock; able to pull to side of roadway. Inspection shows that cast attachment point on swingarm for shock linkage fractured on both sides, resulting in swingarm no longer being supported by shock linkage. Resulted in compression of rear of bike with rear fender and subframe resting on rear tire. Deep gashes in tire from structures on underside of fender, melted rubber, and discolored paint on fender from heat, and torn wiring. *Tr
13 Months after I bought my victory hammer new the 2nd gear began to skip between 3200 and 3600 rpm's. I took it to the dealer and they replaced the 2nd gear trans rack. Parts free. Labor $1500. That happened around 8,000 miles. 24 Month later @18,000miles 2nd gear started to skip again but this time it locked up on me in traffic. I heard something break and a lot of clatter so I quickly got over to the side and then it locked up. $4,000 For parts and labor for a new transmission. All parts replaced. All broken parts in my possession. They include a broken shift fork, and teeth broken on 4 of the 6 gears. *Tr
Tl*the contact owns a 2005 victory hammer. While driving approximately 70 mph, the contact heard a loud noise as if the vehicle shifted out of the correct driveshaft. He pulled the vehicle over for inspection. He noticed that the lower belt of the belt system spontaneously fractured and became jammed in the motor. He placed the vehicle into neutral and then reverse in order to remove the belt from the motor. The contact is in the process of notifying the manufacturer. The failure and current mileages were 8,894. Updated 06/25/08. *Lj updated 06/25/08
Dt*: the contact stated while traveling at 30 mph, the transmissioin seized causing the rear wheel to lock. The drive belt had to be cut in order to roll the vehicle out of traffic. The vehicle was taken to a service dealer. The seizure was due to fractured teeth on the 2nd gear plate and a bent and broken shift fork support. The manufacturer was notified. Updated 11/09/06. *Jb
Victory Hammer: every year compared
All Hammer years2005 Victory Hammer vs rivals
| Vehicle | Complaints | Recalls | Grade | |
|---|---|---|---|---|
| 2005 Victory Hammer | 6 | 2 | F | |
| 2005 Victory Vegas | 4 | 3 | F | Compare |
| 2005 Victory Kingpin | 3 | 4 | F | Compare |
| 2005 Victory Touring Cruiser | 3 | 1 | F | Compare |
| 2005 Victory Ness Vegas | 1 | 2 | - | Compare |
| 2005 Victory Anss Kingpin | 1 | 0 | - | Compare |
| 2005 Victory Vegas Eight Ball | 1 | 0 | A | Compare |
More sales usually means more complaints, so compare similar vehicles of the same year. The grade compares each vehicle with its own model's other years.
Questions about the 2005 Victory Hammer
Does the 2005 Victory Hammer have any recalls?
Yes - NHTSA lists 2 recalls for the 2005 Victory Hammer: hoses, lines / piping, and fittings (July 2005); power train (May 2005). Recall repairs are free at any authorized dealer. Enter your VIN at nhtsa.gov/recalls to see whether yours has been fixed.
What are the most common problems with the 2005 Victory Hammer?
By the complaints owners filed with NHTSA, the most common problem areas are the transmission & drivetrain (2), suspension (2), engine & cooling (2).
How many complaints has the 2005 Victory Hammer had?
6 complaints have been filed with NHTSA, the first on August 16, 2006 and the latest on July 28, 2015. Of these, 0 describe a crash and 0 a fire, and together they report 0 injuries and 0 deaths.
Is the 2005 Victory Hammer a reliable vehicle?
Its Safety Index is 11 out of 100 (grade F: far more problems than a typical Victory Hammer year, for its age). The index weighs complaints, crashes, fires, injuries, deaths and recalls against how long the vehicle has been on the road, compared with the same model's other years. It is not a measure of every repair - read the complaints and owner experiences, and have any used vehicle inspected before you buy.
Which Victory Hammer years have the most complaints?
2005 (6), 2006 (2), 2008 (1). See every Victory Hammer year compared.
What should I do if my 2005 Victory Hammer has a problem?
If it is a safety problem, stop driving it if it is unsafe and contact your dealer. Report it to NHTSA at nhtsa.gov/report-a-safety-problem - enough reports start investigations and recalls - and share your experience here so other owners know what to look for.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data