2016 Volvo V60 CC Engine problems

Engine suffered severe mechanical damage/failure due to excessive oil consumption caused by defective factory piston rings (Volvo Quality Bulletin P10207). Vehicle exhibited heavy engine knocking and flashing warning lights during operation, creating a risk of sudden stall or complete power loss. Annapolis Volvo confirmed severe internal engine failure via dealer diagnostic invoice. Purchased vehicle only 10 months ago under 100k miles (currently 98k), long after Bulletin P10207's quiet expiration. Volvo never...

The contact owns a 2016 Volvo XC60. The contact stated that while driving at 30 MPH, the low oil warning light illuminated. The contact pulled into a gas station, exited the vehicle, raised the hood of the vehicle, and added engine oil to the engine. The contact stated that while buckling the seat belt, the air bag warning light illuminated. A dealer was contacted. The vehicle was taken to an independent mechanic to be diagnosed; however, the vehicle was not repaired. The contact stated that the failure had...

Hello, I currently drive a 2016 Volvo V60 Cross Country which falls under the year of recalled vehicles related to the piston ring issue outlined in the Buchanan, et al. v. Volvo Car USA, LLC, et al., Case No. 2:22-cv-02227. According to the suit Volvo is supposed to replace my oil piston rings if it falls under warranty which is under 100k miles. For Volvo to confirm if my vehicle was impacted they performed an oil consumption test back in March of 2023 in which my vehicle failed meaning the rings still needed to...

Oil consumption has become a major issue and I am putting oil in every 1000 miles! I bought the vehicle certified pre owned in October 2023 and the oil light was consistently coming on early. However, it has since gotten much worse and is constantly burning through oil.

Currently on going, second time around with high oil consumption problems. Dealer is saying warranty is holding up repairs, warranty points finger at dealership, and Volvo refuses to address the massive safety problem with oil consumption cars by refusing to fix. I will never buy another Volvo, and strongly recommend anyone considering a Volvo to think about how they're treating current customers with the known oil consumption problem (horribly).

The component that failed was the oil consumption. I noticed it seemed to be using more oil than should be normal. It didn't seem to do it overnight. It seemed gradual, but over a short period of time, bc I haven't had the car that long. It wasn't super alarming but I was keeping an eye on it and would add more in here and there, as I like to keep it full. One morning, driving my son to school, I started hearing an odd sound, I don't know how to describe it, wasn't loud but different. I tried to turn around bc was on a main road, and when I did, I heard a loud bang and pop and I had to pull over to a safe spot bc on a main highway. I hv not driven since getting brought to my home. 06

Vechile is consuming oil rapidly, Warning light comes on says that the vehicle is unsafe to drive. We had an oil consumption test at the Franklin TN Volvo dealership and it failed. There is also a quality bulletin issued by Volvo and extended warranty to 100K miles or 8 years, we fall outside the years. The warning lights started coming on around 78K miles. This is a know vechile manufacturing defect and feels unsafe to drive and expensive maintain and repair (10K) estimate from dealer.

After piston rings were replaced 1 year ago, engine continues to burn too much oil. 4 quarts after 1800 miles.

Purchased a used 2016 Volvo XC60 from a BMW dealership. A month after purchase, oil light came on - so we added oil. Not long after, it came on again. Finally took the car to a Volvo dealership and they confirmed we have the "oil consumption" issue. There was a class action lawsuit against Volvo and they extended the warranty for this issue for 8 years or 100k miles. Unfortunately, we purchased the car at 8 years, 6 months. We had no idea this issue existed. Volvo says they will do nothing about it. This is...

Engin shut off while driving and would not start again. Fortunately, this happened in a parking lot. If this happened on a highway, there could have been a bad outcome. When the car shut off the steering became very heavy. Dealer says it was a result of skipped timing. Timing belt did not break and has about 10,000 miles on it. Dealer provided no reason as to why this happened. No warning signs and no warning lights before this happened.

Car burns a quart of oil every thousand miles.

See attached document for complaint

The contact owns a 2016 Volvo XC60. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. There was no warning light illuminated. The vehicle was towed to an independent mechanic, where the vehicle was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The dealer was contacted but the vehicle was not diagnosed or repaired. The manufacturer was made not aware of the failure. The failure mileage was approximately 84,690.

On [[redacted]], I was traveling back from North Carolina to Columbia Sc. While driving, I had my cruise control on ~78 mph and had a 4 foot Christmas tree on the top of my car. Suddenly, my car jolted and the car began to run funny. Almost run like there was sand. An alert also popped up on the dashboard that said something to the extent of "downshift or reduce speed" I was low on fuel and luckily the next exit was right there. I also scheduled an appointment with my local Volvo dealership as my car is under an...

The contact owns a 2016 Volvo XC60. The contact stated that while operating the vehicle, there was an abnormal burning odor inside the vehicle. The "Low Oil" message was displayed. The vehicle was taken to the local dealer to be diagnosed and the contact was informed that the piston rings were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 5,500.

Purchased the vehicle sometime in 2021. Been dealing with oil consumption issues since then. Always maintained the vehicle per manufacturer recommendations. At first I had to top off the oil here and there and didn't think much of it. Forward to Sept 2023 I have to add a quart every 500 miles. I began to research about the oil consumption problem and learned the following: There was a letter that was sent out to Volvo owners in Feb 2023 about a service bulletin regarding an oil consumption test and if the vehicle...

My vehicle sustained catastrophic, permanent engine failure while I was driving, in two-way city traffic. Cars backed up behind me, I had difficulty opening my door because of oncoming traffic, and eventually was able to push it (and get help pushing) to the intersection gas station. No warning lights appeared on my dashboard before, during or afterward. Independent service center reports no battery or alternator issue - engine is locked up. No idea why. The vehicle is out of warranty. I will have to pay to replace the engine myself, ~$7-8,000 in order to sell it at near KBB value. So disappointed in Volvo.

Since 2021 my car has been burning excessive oil. I have recently discovered that a defect in the pistons of certain Volvo engines, including the one that is in my car, may be the cause for the excessive oil consumption. I am having check and add approximately add 1-2 quarts of oil every 1000 miles on a car that has only 70,000 on the odometer. The defects, according to a recent class action lawsuit may lead to potentially dangerous outcomes. I seek your assistance in getting help with this issue. I have provided all of the details of my concerns in the complaint which is attached.

Volvo XC60 is burning oil and putting off a smell. Approximately every 500 miles I am prompted to put in another quart of oil. No signs of leaking. Took the car into a mechanic to inspect and was notified this is a known Volvo problem and I'd need to take it to a dealership since there are several TSBs on it with this known issue. Issue has been progressively been getting worse since I purchased the car a few years ago.

The engine is using a quart of oil every 1000 miles, There is no leaks or pools of oil on the ground under the car. This is one of the engines identified in a class action lawsuit filed for this same reason.

This car has excessive oil consumption and burns oil because the piston rings are faulty. Eventually can cause the engine to stop working and put lives on the road in danger. This was proven in a class action lawsuit against Volvo and they extended the warranty to 8 years or 100,000 miles however some cars are over the 100,000 miles and are still needing to add oil every 2-3 weeks. The low oil light started coming on about 80,000 miles. Had it in for repair but the dealership didn't know what was wrong with it.

When stopped at a stop light, have to hold brake down in order to keep the car from driving as the rpms are revving up and down, causing the car to want to move and when in park revving so high that it went into red and caused the check engine light to come on and I had to turn off the vehicle. Also the gas tank filler tube cloggs up easily and has to be dropped in order for the tube / vents to be cleaned out or replaced.

"The contact owns a 2016 Volvo XC60. The contact stated that while driving at 25 MPH, the oil warning light illuminated. The contact stated that she refilled the oil when she arrived at her residence. The contact noticed that the vehicle was consuming an excessive amount of oil and she was refilling the oil each 4-6 weeks. The vehicle was taken to the dealer, Bobby Rahal of the South Hills, who diagnosed that the piston rings needed to be replaced for more than $4,000 or the dealer stated that adding oil to the car...

The 2016 Volvo V60 Cross Country started burning oil like crazy and the engine light went off. When I checked the levels, it was down multiple quarts. We have had all work done as detailed in the manual at the dealership. We took the car in and they said the Piston rings were damaged and that they had to replace those. Thankfully this was under warranty. They pushed back the repair for several months because this is such a systemic problem they were having a hard time getting the parts, and setting aside the time to do so many.

While the car was in motion, going down a steep (approximately 10 degree decline) the no oil pressure alarm was triggered and system instructions to pull over and stop engine immediately. The car was taken to the closest volvo dealer and it was determined the piston rings had failed/were failing leading to rapid, excessive oil consumption. Volvo has been aware of faulty piston and oil control rings in their engines made from 2012-2016 and have developed a remediation procedure. This is an extremely unsafe design flaw in these vehicles which could result in engine seizure. *Tr