2018 Chevrolet Bolt Problems, complaints & recalls

The steering rack loses its lubrication make it turn harder and could potentially fail completely leading to a loss of steering. I noticed that when I am steering around a curve the steering wheel fails to pull back to the center position and has to be manually forced back. Loss of steering or steering malfunction could lead to a fatal crash. I have not had my vehicle inspected by a dealer or mechanic but have researched the problem and many people online have reported failure of the steering rack/gear as well....

Sometimes, the steering wheel of the car will not return back to center after turning. The steering also feels a lot heavier. This usually happens after driving straight for a little and then having to make a turn, but may happen spontaneously in other situations as well. The steering wheel suddenly not returning to center when it is expected increases the chances of accidents, especially in areas with many curves and people/activities. The car does not show any warning signs. The dealership said they said they didn't notice it when driving and thus didn't want to further check it (they only drove it from one parking spot to another).

On 4/5/2025 I was driving at 35mph and the steering wheel began to violently shimmy. The vehicle became difficult to steer putting safety at risk. Slowed to 25mph but shimmy did not stop. ABS warning light came on and Stabilitrak warning light came on and warning that steering was being was being automatically reduced. Driving became very difficult. Stopped and had car towed to Chevrolet. Car was diagnosed with broken left and right front axle anticlick washers and metallic debri found on sensors. Both front...

Steering wheel does not return to center

The steering of my 2018 Chevy Bolt is sticky. At moderate speeds and going around sweeping corners and curves, the steering becomes sticky and does not want to return to center - you must guide steering back to center and there is friction involved in pulling it back to center. This is a safety issue because the sticking does not allow the driver to sense true road conditions especially in adverse weather. The problem has been reproduced by the dealer and is commonly discussed in Chevy Bolt forums including...

Brake modules not working properly and need reprogramming. GM not honoring their buyback warranty.

Well known steering issue causing steering to almost "lock" and not return to center. Seemingly caused by lack of grease on the steering gear. Obviously dangerous for all involved as it is a steering problem.

HMI module failed. Distraction from road because the display pops on and off. Im not taking in my car because there are forums and forums discussing this issue. Not inspected by anybody either. There were no warnings, it just stopped working 2 weeks ago.

my bolt was bought in 2018 (2018model) and has only a lil over 35k mileage. I was just informed by the dealer that the whole steering gear needs to be replaced as it could fail at any moment. I checked online for similar issues and seems like there are thousands of complaints of this, I was quoted for $3700 to get this repaired.. This is such a safety issue that it needs to be a recall, especially when considering such a low mileage!!

The steering gear went out at 45k miles and I JUST got the car recently. The steering stays stuck when I turn it and it takes turns very sharply. In snow or rainy conditions,This might be fatal. I checked out a couple of forums online regarding this issue and seems like a lot of people have also encountered it. It's a $4000 fix when I took it Chevrolet. This should be something Chevrolet recalls, not for us to fix as it could end up in a lot of injuries or ever death.

The steering does not return to center after a turn. It must manually be returned to the center position. Also, there is a creaking sound when turning the wheel.

While driving, the steering wheel is stiff when turning left or right and the steering wheel will not return to center after turning a corner or chaning lanes.

The radio antenna/receiver/reception in my 2018 Chevy Bolt is very poor. There are many areas I receive almost no radio stations, or stations are extremely fuzzy. The reception is getting worse over time. In searching for a solution to this, I have found that there are many accounts, complaints, and forums related to this issue in all model years of this vehicle. The greater community has not found a viable solution outside of buying a separate radio and hooking it up to the auxiliary input. Many others have...

The rack and pinion steering degraded over a short period of time with less than 25,000 miles on the vehicle. The first thing we noticed was that the steering wheel would not return to center. Gradually, the steering worsened until it got to the point that the only way the steering would return to center was if it was forcefully pulled to center by the driver. The dealership told us they had no idea what could cause this. We looked online at Chevy Bolt forums and discovered that many other people were having these...

Steering gear failed. My young daughter usually drives this car. I drove it for the first time in a couple of weeks because it was blocking my car in and immediately knew there was a an issue. When turning a corner it was difficult to straighten the steering wheel back to center and if not forced it would continue turning instead of returning back to center on its own. I immediately took it to a mechanic who indicated that the steering gear was failing. He said that when he had the car on the lift to diagnose, it was very difficult to move the wheels by hand. The failure happened pretty quickly and could have been disastrous had I not driven the car.

The contact owns a 2018 Chevrolet Bolt EV. The contact stated that after the dealer performed the recall repair under NHTSA Campaign Number: 21V560000 (Electrical System), the new battery charge range allowed for up to 90 miles, whereas the older battery allowed for up to 150 miles before recharging. Additionally, the new battery failed to retain a complete charge, with the "Unable to Charge" message displayed while charging. The contact felt that the recall remedy was not a permanent fix but a temporary repair....

My 2018 Chevrolet Bolt steering does not self center. After a turn I have to manually turn the steering wheel back to center. This occurrs turning either left or right. The steering also feels a bit heavy. This is alarming that something is binding in the steering. It is becoming more noticeable. The car was recently in the dealer shop for a seat belt cover recall and they didn't notice anything wrong. The tires were rotated but that made no difference. My wife took the car in for the recall but didn't know to ask about the steering. There are no warning lights.

Dealer will not do recall : (The high voltage batteries in these vehicles may pose a risk of fire when charged to full, or very close to full, capacity. General Motors said that the bottom of the battery tray is damaged.

The contact owns a 2018 Chevrolet Bolt EV. The contact stated that while driving at night at an unknown speed, the regen on demand (Rod) was engaged but did not notice any rear illumination. On other occasions, the contact noticed that the vehicles behind were often beeping at her while driving. The vehicle was inspected vehicle while running and the regen on demand (RoD) paddle was activated; however, the rear lights failed to illuminate as needed. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 20,000.

Have inquired repeatedly since recall no. 21V560 issued. Told each time by authorized GM dealer that replacement lithium-ion batter pack is not available yet. Coming up on two years and presumably my vehicle remains at increased risk of fire. Would like GM to execute on the recall and repair.

The factory installed steering rack is binding and fails to return to center. The car has 96,000 miles on it. The steering is dangerous and the vehicle does not track straight even after multiple attempts to align the front end suspension. We replaced the tires, front struts and aligned the vehicle only to discover there is a manufacturing defect in the design of the steering rack.

Driving 65mph in middle lane the vehicle suddenly dropped in speed to 45mph and on the dash a warning came up that said "Propulsion power is reduced" this almost caused a semi truck to rear end me.

I received a "Propulsion Power Reduced" warning indicator on my 2018 Chevy Bolt while driving on the highway. Although I did not lose power, I am afraid to drive my car. I am advised by the car repairer that I should not drive the vehicle until it is repaired because it may stop suddenly without warning. GM has never contacted me about this safety issue despite being aware of the problem. The National Highway Traffic Safety Administration should open an investigation and issue a safety recall on this issue. This problem should be categorized as a severe safety hazard and listed on the NHTSA website for the benefit of consumers.

Our vehicle's power steering is intermittent. It randomly shuts off, leaving the driver with no power steering. Most frequently, the problem surfaces just after start-up, however, this problem also occurs after driving the car for several minutes, such as when the vehicle is parked but turned on, when the vehicle is in motion while driving, and even once in the middle of a U-turn. Once out, the power steering stays off for several minutes, sometimes only 5 minutes, sometimes 15. Once out, the power steering has a)...

While driving at highway speed, the steering wheel started to shimmy, making the vehicle difficult to control. On inspection, the front wheel was very hot. The mechanic advised that the front caliper is defective. The Bolt EV is equipped with a regenerative braking system that stops the vehicle. This vehicle has been stopped by using this regenerative braking system about 99% of the time. The mechanic advised that since the caliper has not been used, it has started freezing, causing the brakes to continue to be...