- The problem
- General Motors LLC (GM) is recalling certain model year 2005-2007 Chevrolet Corvette vehicles manufactured March 29, 2004, through June 22, 2007. In the affected vehicles, the underhood bussed electrical center (UBEC) housing can expand and cause the headlamp low beam relay control circuit wire to bend. If the wire is repeatedly bent, it may fracture causing a loss of low beam headlamp illumination.
- The risk
- The loss of low beam headlamp illumination will decrease the driver's visibility, as well as the vehicle's conspicuity to other motorists, increasing the risk of a crash.
- The fix
- GM will notify owners, and dealers will install a jumper wire to correct this condition, free of charge. The recall began January 2, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 13146. Note: Model year 2008-2013 Chevrolet Corvettes will be covered under customer satisfaction program number 14203 for the same issue.
Vehicle safety record
2005 Chevrolet Corvette Problems, complaints & recalls
No owner complaints about the 2005 Chevrolet Corvette have been filed with NHTSA. It is covered by 6 recalls, the latest in May 2014 for the wiring.
NHTSA data checked
DMore problems than a typical Corvette year, for its age
- Complaints
- 0
- Recalls
- 6
- Crashes
- 0
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
2005 Chevrolet Corvette recalls 6
Recall repairs are free. Your dealer fixes them whether or not you bought the car there - check your VIN at nhtsa.gov/recalls to see if yours is done. What to do
- The problem
- Gm is recalling certain model year 2005 and 2006 chevrolet corvette passenger cars manufactured between march 2004 and january 2006 equipped with a tilt and telescoping steering column (rpo n37). In rare cases, repeated movement of the steering column may cause a signal interruption within the column. If this occurs, the message, "service active handling system" will appear in the driver information center, and one or more of the brakes may apply, possibly causing the vehicle to pull to the right or left.
- The risk
- If the driver does not respond to the change in vehicle movement, a crash could occur.
- The fix
- Gm will notify owners and dealers will repair the vehicles free of charge. The safety recall began on april 30, 2010. Owners may contact chevrolet at 1-800-630-2438 and gmc at 1-866-996-9463 or at the owner center at www.Gmownercenter.Com.
- The problem
- General motors is recalling certain model year 2005 through 2007 corvette vehicles equipped with a removable roof and model year 2006 and 2007 corvette z06 vehicles. The adhesive between the roof panel and the frame may separate. If there is a partial separation, the driver may notice one or more symptoms, such as a snapping noise when driving over bumps, wind noise, poor roof panel fit, roof panel movement/bounce when a door or hatch is closed, or a water leak in the headliner.
- The risk
- If there is a complete separation, the roof panel may detach from the vehicle. If this were to occur while the vehicle was being driven, it could strike a following vehicle and cause injury and/or property damage.
- The fix
- Dealers will install a new design roof panel free of charge. The safety recall is expected to begin during april 2010. Owners may contact chevrolet at 1-800-630-2438 or at www.Gmownercenter.Com.
- The problem
- On certain 2005-2006 chevrolet corvettes equipped with painted roofs, the adhesive between the roof panel and the frame may separate.
- The risk
- If there is a complete separation, the roof panel may detach from the vehicle and it could strike another vehicle and cause injury and property damage.
- The fix
- Dealers will inspect vehicles free of charge for potential roof panel-to- frame separation and add the specified adhesive foam or replace the roof with one having adhesive foam. The recall began on october 19, 2006. Owners may contact chevrolet at 1-800-630-2438.
- The problem
- Certain passenger vehicles may have been built with a power steering hose that is not to specification. Under extreme steering maneuvers, such as turning the steering wheel fully to the left or right while braking, the hose may fracture and leak fluid.
- The risk
- If this were to occur, power steering assist would be lost and increased steering effort would be required. On vehicles equipped with hydro-boost power brakes, it could also result in loss of power brake assist and increased braking effort would be required. If the power steering fluid spray were to spray onto hot engine parts, an engine compartment fire could occur.
- The fix
- Dealers will inspect the power steering hose(s) for two suspect date codes and replace them if required. The recall will begin on october 14, 2005. Owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, buick at 1-866-608-8080, cadillac at 1-866-982-2339, isuzu at 1-800-255-6727, or hummer at 1-800-732-5493.
- The problem
- Certain passenger vehicles were produced with one or both rear brake hydraulic lines that can come in contact with or be affected by heat from the left engine exhaust manifold and the left exhaust pipe. The brake fluid could reach elevated temperatures and boil.
- The risk
- If the brake fluid boils in a rear brake line, the effectiveness of the rear brake system would be reduced which could result in a brake line leak and loss of brake fluid. If enough fluid leaks from the rear brake system so that brake pedal application can no longer build pressure to the rear brakes. The operator of the vehicle will experience limited braking which could result in a crash.
- The fix
- Dealers will (1) inspect the left engine exhaust manifold clip for proper alignment and placement on the body-mounted stud. If incorrect, they will reposition the clip on the brake lines and reinstall the clip on the stud; (2) the dealer will verify that both rear brake lines have the proper clearance to the left exhaust pipe. They will reposition the lines by bending as necessary; (3) dealers will remove the machining tab from the rear differential housing. Also, dealers are to inspect the brake lines for wear in these related areas and repair or replace if there is any sign of wear-through on the nylon overcoating. The recall began on january 18, 2005. Owners should contact cadillac at 1-866-982-2239 or chevrolet at 1-800-630-2438.
What owners say
Be the first Corvette owner to share.
Problems or none - your experience is exactly what the next buyer is looking for. Write it now
No complaints about the 2005 Chevrolet Corvette yet
No owner has filed a complaint about this vehicle with NHTSA. If yours has a problem, share it here and report it to NHTSA.
Chevrolet Corvette: every year compared
All Corvette years2005 Chevrolet Corvette vs rivals
| Vehicle | Complaints | Recalls | Grade | |
|---|---|---|---|---|
| 2005 Chevrolet Corvette | 0 | 6 | D | |
| 2005 Subaru WRX | 19 | 5 | C | Compare |
| 2005 Bentley Continental GT | 1 | 1 | D | Compare |
| 2005 Ford Mustang | 0 | 9 | D | Compare |
| 2005 Volkswagen GTI | 0 | 1 | A | Compare |
| 2005 Lamborghini Gallardo | 0 | 1 | C | Compare |
| 2005 Chevrolet Cavalier | 287 | 1 | F | Compare |
| 2005 Chevrolet Aveo | 235 | 1 | D | Compare |
| 2005 Chevrolet Avalanche | 206 | 3 | D | Compare |
More sales usually means more complaints, so compare similar vehicles of the same year. The grade compares each vehicle with its own model's other years.
Questions about the 2005 Chevrolet Corvette
Does the 2005 Chevrolet Corvette have any recalls?
Yes - NHTSA lists 6 recalls for the 2005 Chevrolet Corvette: wiring (May 2014); column (April 2010); roof and pillars (December 2009); roof and pillars (May 2006) and more. Recall repairs are free at any authorized dealer. Enter your VIN at nhtsa.gov/recalls to see whether yours has been fixed.
How many complaints has the 2005 Chevrolet Corvette had?
None have been filed with NHTSA so far.
Is the 2005 Chevrolet Corvette a reliable vehicle?
Its Safety Index is 26 out of 100 (grade D: more problems than a typical Chevrolet Corvette year, for its age). The index weighs complaints, crashes, fires, injuries, deaths and recalls against how long the vehicle has been on the road, compared with the same model's other years. It is not a measure of every repair - read the complaints and owner experiences, and have any used vehicle inspected before you buy.
Which Chevrolet Corvette years have the most complaints?
2016 (105), 2011 (85), 2010 (84). See every Chevrolet Corvette year compared.
What should I do if my 2005 Chevrolet Corvette has a problem?
If it is a safety problem, stop driving it if it is unsafe and contact your dealer. Report it to NHTSA at nhtsa.gov/report-a-safety-problem - enough reports start investigations and recalls - and share your experience here so other owners know what to look for.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data