2018 Genesis G80 Engine problems

Related Recall: 41D086R0 (Starter Relay Kit Installation, Part #91955-DH45K-QQH) Incident Summary: My 2018 Genesis G80 suffered an under-hood electrical fire directly at the location of the Starter Relay Kit installed under federal safety recall 41D086R0. On [redacted] (at 92,267 miles), Van Hyundai in [[redacted]] installed Recall Starter Relay Kit 91955-DH45K-QQH. On [redacted] (at 130,065 miles) the vehicle was towed to the same dealership for a no-start condition. After replacing the starter assembly, the...

This complaint is filed regarding an under-hood thermal fire incident and unauthorized modification involving a federally mandated safety recall for a 2018 Genesis G80 (VIN: [[redacted]]). To resolve a starting issue, technicians at Van Hyundai in [[redacted]], bypassed the standard ignition circuit and installed an un-fused manual starter bypass switch kit. This bypass directly conflicted with active NHTSA Safety Recall Campaign 24V107000, which requires a specific fused relay kit (Part 91950-DH15KQQH) to...

Failing oil pressure sensor which "blinds" the driver of the engines true oil levels. It occasionally causes the car to go into "limp" mode or stall which could cause unnecessary and unreasonable traffic safety hazards. This is a well known and documented critical safety defect by Genesis as they've already executed a recall for the issue in their home country / market of South Korea.

The contact owns a 2018 Genesis G80. The contact stated that the Check Oil and Low Oil warning light illuminated while the vehicle was idling. The warning lights turned off while driving. The vehicle was not taken to the dealer or an independent mechanic to be repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 72,200.

Component: Engine / Turbocharger / Oil Line / Fire Risk Vehicle Problem: For the past five months, my oil light has been coming on and off sporadically (not flickering), even though mechanics and oil shops said there was no issue. A few days ago, the car started smoking out of nowhere, though it wasn't overheating and there were no visible signs of leakage. I took it to the shop, and they diagnosed a turbocharger oil supply pipe leak that is severe and poses a fire risk. I am in a new city with no support system...

Engine while driving inadvertently stalls and vehicle shuts off. Does not matter what the conditions are. Have to place vehicle back in park and completely shut down vehicle to restart. It first starts by engine slowing down and then engine speeding up and ultimately stopping. When placed in park vehicle lungs forward slightly and front sensor tends to go off in warning without a vehicle in front of

There are two safety recalls, one for the starter and one for the turbo oil supply line, both have potential for a fire concern and the manufacturer has failed or is unable to remedy this safety recall for my vehicle in a timely manner.

Genesis issued the recall in mid-February and there is still not a remedy. We are supposed to park our auto outside and not in the garage. As we live in Florida and it is very hot and it is hurricane season, it is intolerably hot to park outside and, in the event of a hurricane or thunderstorm with hail, we cannot park outside without risking damage to our auto. It has been nearly five months since the recall which should be sufficient time for Genesis to have a solution to the problem. Also, they are not...

The contact owns a 2018 Genesis G80. The contact stated that the vehicle failed to start. The contact called Roadside Assistance, who arrived and restarted the vehicle. The contact used a boost charger to start the vehicle. The check engine warning light was illuminated. The trunk opened message was displayed. The vehicle was taken to the local dealer, who informed the contact about NHTSA Campaign Number: 24V107000 (Electrical System). The contact stated that the parts were on backorder. The manufacturer was not contacted. The failure mileage was approximately 80,000.

The contact owns a 2018 Genesis G80. The contact received notifications of NHTSA Campaign Numbers: 24V107000 (Electrical System) and 24V191000 (Engine and Engine Cooling) however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the issue. The contact stated that the vehicle was taken for routine maintenance; however, upon leaving the repair center, while driving...

Faulty oil pressure sensor comes on below 55 degrees and off when you increase RPM and speed. This is a huge safety issue if you think it's the sensor but it's not and can damage your engine, but it's nightmare when it's the sensor and you have a panic attack every time it comes on.

Recall in 2020 for a Oil Supply Pipe that is leaking and could cause a fire. It was completed in 2020. The same issue just occurred on 12/22/2023 where it stared leaking again and I took it to Genesis. They are saying I need to pay out of pocket but it is the same issue as the recall which is a fire hazard. They have had my car for 2 weeks. Opened a case with Genesis but they will not cover it. I have texts from the Gensis Mechanic saying it is the same issue. There were no warning signs except for the smoke when is was already leaking.

The contact owns a 2018 Genesis G80. The contact stated while driving at an undisclosed speed, there was white smoke coming from underneath the hood. The contact stated that in December of 2019 the vehicle was serviced at the dealer for a service appointment and unknown recall repair for the turbo fluid injector. The contact stated that the vehicle had experienced the failure like the description of the safety recall which was completed in 2019. The vehicle was taken to the dealer. The vehicle was diagnosed with...

The contact owns a 2018 Genesis G80. The contact stated that while driving approximately 35 MPH, there was white smoke coming from underneath the vehicle. The vehicle was later towed to the local dealer who diagnosed that the turbo pipe seal had failed causing oil to drip onto the exhaust manifold causing the white smoke. The contact was informed that the turbo charger oil supply pipe needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The contact indicated that the vehicle was previously serviced under the NHTSA Campaign Number: 19V538000 (Engine and Engine Cooling) but the failure occurred. The failure mileage was 45,000.

The oil pressure light comes on intermittently - often at low RPMs and then goes away at higher RPMs. It is a very expensive repair and appears to be just due to a faulty oil pressure sensor. The light causes issues because it covers up whether there is another more serious problem that needs attention.

The contact owns a 2018 Genesis G80. The contact stated the vehicle was making a knocking sound from underneath the hood of the vehicle near the engine. While the contact was attempting to accelerate the vehicle displayed a hesitation while idling or driving at various speeds. The check engine warning light was illuminated. The contact had taken the vehicle to the dealer to be diagnosed. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 38,500.

Went to the dealer to report a smell coming out of the engine as well as a squeaking noise when the accelerator is pressed either stationary or in motion. The dealer representative told me that there is a recall on the car but they don't have a remedy yet. I read about the recall. On my question 'what is going to happen if the engine catches fire?' The representative told me that they haven't seen any cars of this model to catch fire yet. I wonder what needs to happen so the manufacturer is more proactive...