- The problem
- Winnebago is recalling certain recreational vehicles equipped with 1200-series norcold refrigerators. The population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. The response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.
- The risk
- The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.
- The fix
- Winnebago is working with norcold to identify and notify any affected owners. Owners will be instructed to contact norcold dealers to receive the remedy free of charge. Please see norcold's defect report 10e-049 for additional information. The recall began during december 2010. Owners may contact norcold at 1-800-767-9101 or winnebago at 1-641-585-3535.
Vehicle safety record
2004 Itasca Sunstar Problems, complaints & recalls
Owners have filed 1 complaint about the 2004 Itasca Sunstar with NHTSA, most often about the electrical system (1). It is covered by 3 recalls, the latest in October 2010 for the equipment. For comparison, the 2003 has 0 and the 2005 has 0.
NHTSA data checked
CAbout as many problems as a typical Sunstar year, for its age
#455 most complained-about 2004 vehicle
- Complaints
- 1
- Recalls
- 3
- Crashes
- 0
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
Most common 2004 Itasca Sunstar problems
Share of all 1 complaints. One complaint can name more than one area. Tap an area for its complaints and recalls.
2004 Itasca Sunstar recalls 3
Recall repairs are free. Your dealer fixes them whether or not you bought the car there - check your VIN at nhtsa.gov/recalls to see if yours is done. What to do
- The problem
- On certain motor homes equipped with samsung microwave ovens, models mr1031wb, mr1032bb, mr1033sb, mr1351wb, and mr1352bb, the microwaves were produced with a defective panel. An electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a "jumper" or jump wire. This may cause the oven to activate without pressing any key pads.
- The risk
- An electrical short can occur causing the oven to activate without pressing any key pads. This could result in excessive heat, smoke, or possibly a fire.
- The fix
- Samsung will notify customers and repair the panel free of charge. In the meantime, consumers should unplug their microwave, if possible. If the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. Consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 1-800-932-3837 or winnebago at 1-641-585-3535.
- The problem
- On certain motor homes equipped with samsung microwave ovens, these units were produced with a defective panel. An electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a "jumper" or jump wire. This may cause the oven to activate without pressing any key pads.
- The risk
- An electrical short can occur causing the oven to activate without pressing any key pads. This could result in excessive heat, smoke, or possibly a fire.
- The fix
- Samsung will notify customers and repair the panel free of charge. In the meantime, consumers should unplug their microwave, if possible. If the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. Consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800-932-3837 or winnebago at 641-585-3535.
What owners say
Be the first Sunstar owner to share.
Problems or none - your experience is exactly what the next buyer is looking for. Write it now
1 complaints about the 2004 Itasca Sunstar
Newest first, as filed with NHTSA by owners.
At freeway speed, while towing a honda behind the 2004 itasca 38 ft. Motorhome, the engine, transmission, power steering power brakes and all electronics spontanwously failed. With significant effort, the vehicle was moved out of traffic and stopped. No injuries resulted, however under different conditions such as a curve or grade the results could have been fatal. No diagnosis has been made. The vehicle was towed for warranty repair previously suffered complete hydralic system failure.*Ak
Itasca Sunstar: every year compared
All Sunstar years2004 Itasca Sunstar vs rivals
| Vehicle | Complaints | Recalls | Grade | |
|---|---|---|---|---|
| 2004 Itasca Sunstar | 1 | 3 | C | |
| 2004 Itasca Suncruiser | 6 | 3 | D | Compare |
| 2004 Itasca Meridian | 4 | 4 | F | Compare |
| 2004 Itasca Horizon | 3 | 5 | F | Compare |
| 2004 Itasca Sunrise | 3 | 5 | F | Compare |
| 2004 Itasca Sunova | 1 | 6 | D | Compare |
| 2004 Itasca Spirit | 1 | 5 | F | Compare |
More sales usually means more complaints, so compare similar vehicles of the same year. The grade compares each vehicle with its own model's other years.
Questions about the 2004 Itasca Sunstar
Does the 2004 Itasca Sunstar have any recalls?
Yes - NHTSA lists 3 recalls for the 2004 Itasca Sunstar: equipment (October 2010); recreational vehicle / trailer (July 2004); recreational vehicle / trailer (October 2003). Recall repairs are free at any authorized dealer. Enter your VIN at nhtsa.gov/recalls to see whether yours has been fixed.
What are the most common problems with the 2004 Itasca Sunstar?
By the complaints owners filed with NHTSA, the most common problem areas are the electrical system (1).
How many complaints has the 2004 Itasca Sunstar had?
1 complaints have been filed with NHTSA, the first on September 7, 2004 and the latest on September 7, 2004. Of these, 0 describe a crash and 0 a fire, and together they report 0 injuries and 0 deaths.
Is the 2004 Itasca Sunstar a reliable vehicle?
Its Safety Index is 44 out of 100 (grade C: about as many problems as a typical Itasca Sunstar year, for its age). The index weighs complaints, crashes, fires, injuries, deaths and recalls against how long the vehicle has been on the road, compared with the same model's other years. It is not a measure of every repair - read the complaints and owner experiences, and have any used vehicle inspected before you buy.
Which Itasca Sunstar years have the most complaints?
2012 (2), 2004 (1), 2013 (1). See every Itasca Sunstar year compared.
What should I do if my 2004 Itasca Sunstar has a problem?
If it is a safety problem, stop driving it if it is unsafe and contact your dealer. Report it to NHTSA at nhtsa.gov/report-a-safety-problem - enough reports start investigations and recalls - and share your experience here so other owners know what to look for.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data