- The problem
- Certain transit buses fail to comply with the requirements of federal motor vehicle safety standard no. 108, "Lamps reflective devices, and associated equipment." The flashing deceleration lamps were an optional item for some of these buses.
- The risk
- The standard requires that the deceleration lamp is a solid light rather than a flashing light.
- The fix
- Dealers will rewire the electrical system to remove the flashing function or install a new programmable logic controller (plc) which will make the lamps burn steady free of charge. The recall began on march 5, 2007. Owners may contact new flyer at 204-934-4874.
Vehicle safety record
2000 New Flyer D60LF Problems, complaints & recalls
No owner complaints about the 2000 New Flyer D60LF have been filed with NHTSA. It is covered by 4 recalls, the latest in February 2007 for the exterior lighting.
NHTSA data checked
DMore problems than a typical D60LF year, for its age
- Complaints
- 0
- Recalls
- 4
- Crashes
- 0
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
2000 New Flyer D60LF recalls 4
Recall repairs are free. Your dealer fixes them whether or not you bought the car there - check your VIN at nhtsa.gov/recalls to see if yours is done. What to do
- The problem
- On certain low floor transit buses equipped with adhesively bonded aluminum bus door panels, due to an imperfect bonding of the door panel skin to the panel frame, environmental moisture may infiltrate regions of imperfect bonding and cause separation of the frame and door panel.
- The risk
- Under these conditions, if the panel is separating or has separated, a passenger could fall from the bus onto the roadway, possibly resulting in personal injury or death.
- The fix
- Vapor will notify customers to have their buses inspected and will install mechanical fasteners to attach the skins to the frame elements free of charge. Owner notification began december 10, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact vapor corporation at 847-967-8300 or new flyer at 1-204-224-1251.
- The problem
- Vehicle description: transit buses equipped with vanner 60 series battery equalizers. The equalizer could fail to operate properly and cause malfunction of the battery charging system.
- The risk
- Without fusing, the equalizer may melt, burn, or smoke, possibly resulting in a fire or a smoke filled bus, thus necessitating a passenger evacuation of the bus. The failure mode can cause operator distraction, and/or possible personal injury.
- The fix
- Dealers will inspect the buses for certain equalizers by the date code. The affected equalizers will be replaced by vanner. New flyer is conducting the owner notification for this campaign. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact vanner at 1-800-227-6937 or new flyer at 1-204-982-8413.
- The problem
- Vehicle description: certain transit buses fail to comply with fmvss no. 121, "Air brake systems." The rear brake release time can exceed the requirements.
- The risk
- A slow brake release can cause premature brake wear, increasing the risk of a crash.
- The fix
- The center axle and rear axle brake control lines will be re-plumbed.
What owners say
Be the first D60LF owner to share.
Problems or none - your experience is exactly what the next buyer is looking for. Write it now
No complaints about the 2000 New Flyer D60LF yet
No owner has filed a complaint about this vehicle with NHTSA. If yours has a problem, share it here and report it to NHTSA.
New Flyer D60LF: every year compared
All D60LF yearsQuestions about the 2000 New Flyer D60LF
Does the 2000 New Flyer D60LF have any recalls?
Yes - NHTSA lists 4 recalls for the 2000 New Flyer D60LF: exterior lighting (February 2007); door (February 2002); 12v / 24v / 48v battery (April 2001); service brakes, air (September 2000). Recall repairs are free at any authorized dealer. Enter your VIN at nhtsa.gov/recalls to see whether yours has been fixed.
How many complaints has the 2000 New Flyer D60LF had?
None have been filed with NHTSA so far.
Is the 2000 New Flyer D60LF a reliable vehicle?
Its Safety Index is 39 out of 100 (grade D: more problems than a typical New Flyer D60LF year, for its age). The index weighs complaints, crashes, fires, injuries, deaths and recalls against how long the vehicle has been on the road, compared with the same model's other years. It is not a measure of every repair - read the complaints and owner experiences, and have any used vehicle inspected before you buy.
What should I do if my 2000 New Flyer D60LF has a problem?
If it is a safety problem, stop driving it if it is unsafe and contact your dealer. Report it to NHTSA at nhtsa.gov/report-a-safety-problem - enough reports start investigations and recalls - and share your experience here so other owners know what to look for.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data