2005 Saturn Ion Engine problems

Tl* the contact owns a 2005 saturn ion. The contact stated that while driving approximately 55 mph, the loss motive power without warning. The contact stated that steering assist and gauges were in operable. The contact coasted to the side of the road and restarted the vehicle. The contact stated that several of the electrical functions returned however, the electrical functions failed intermittently. The power steering assist warning light illuminated intermittently when the power steering assist was inoperable....

Tl* the contact owned a 2005 saturn ion. The contact's son observed an orange glare coming from the back of their house. The family ran outside together and discovered that the son's vehicle was on fire. The fire department was down the street, but took twenty minutes to arrive at the scene. The contact's nineteen year old son extinguished the fire with water from the house. A police report was filed and there were no injuries. The vehicle was totaled. The dealer and manufacturer were not made aware of the failure. The failure mileage was 217,000.

I have had issues with my car even after I have had some recalls done to it. The biggest issue is when I am driving or stationary with my car on, the car rumbles and feels like it is tugging backwards. The cylinder 2 keeps misfiring (p0302). I have seen several saturn ions that are having the same issue. Over the past four years this has been a problem consistently. There are periods where it doesn't happen much and sometimes it happens every time I drive. Furthermore, my car still doesn't turn on/off all the way sometimes and the ignition switch messes up.

Engine failed at 125,000 miles. Engine specialist determined cylinder #4 oil starvation as the cause. Oil change intervals have always been approximately 7500 miles. Engine stalled out and would not crank to restart. Engine will need to be replaced. Cost: approximately $4,000.

Tl* the contact owns a 2005 saturn ion. While driving at various speeds, the steering wheel became hard to maneuver. The power steering and check engine warning lights illuminated. The contact pulled over to the side of the road and restarted the vehicle, but the failure occurred once more. The vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure. The failure mileage was 97,200.

Case # 8-1587665159 - 2005 saturn ion ... I cannot get any help with this vehicle and I have gone through all the channels. The car dealership stated the ignition and power steering motor was replaced,yet, I have received no paperwork stating this was done. Ignition was replaced. If the power steering motor was replaced, it went out again while I was out of town, had a garage replace it along with the module but it also went out. Took it back to the dealership as paperwork from gm stated I should do but they...

Engine would not de-accelerate and hitting the brakes did not stop the vehicle. I was passing cars on a highway,and I could not get the engine to down shift. It felt like it was in cruise control, and it was not. I hit the cruise control button to make sure I had not hit it by mistake. I had not. I down shifted into low gear that did not stop the engine from racing. I put it in neutral that didn't help. I managed not to hit any cars. I put the car in a snow bank near a guard rail. There was no crash because...

Tl* the contact owns a 2005 saturn ion. The vehicle was repaired under special policy 10187 at the dealer. While driving approximately 35 mph, the vehicle completely shut off and the power steering warning indicator illuminated. The failure recurred on multiple occasions. The vehicle was taken to a dealer who diagnosed that the electronic power steering control module failed, the vehicle was not repaired and the manufacturer was notified. The approximate failure mileage was 118,000. Updated 4/13/15*cn updated 9/20/2017*cn

Tl*the contact owns a 2005 saturn ion. The contact stated that while driving at approximately 25 mph, the vehicle stalled without warning. The vehicle was able to restart. The failure occurred on three occasions. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 124,000. The vin was not available.

The gas pedal gets stuck while driving and the check engine light comes on. Car will not exceed 5 mph even if the pedal is pushed to the floor. Car must be turned on and off 3 times for the pedal to go back to normal. Another incident is the car will stall when stopping at a light or stop sign. Turns back on with no problem. I have had all recalls performed. *Tr

**The other affected part was speed control.... Aside of the current recall issue having been a problem since I purchased the vehicle in 2005 (which has "been repaired"-i guess so if you call repaired the car trying to start itself, not starting at all, current pcm overload thanks to soo many negative codes being thrown for this worthless piece of junk.) I have filed numerous complaints with the dealership about the throttle body and am constantly and consistently provided the same answer and it is becoming a...

2005 Saturn ion. Consumer writes in regards to several recall defects and requests reimbursement for vehicle repairs. *Smd the consumer stated the vehicle broke down and had to be towed to the nearest repair factuality, where there kept the vehicle for over two months. After the vehicle was returned, the problems continued. The engine light was on and there was a problem with the ignition switch. Also, the engine vales, timing chain and sway bar links were replaced. *Jb

I've made reports of faulty switch ignition problems in 2010 to gm the replaced it with another and I still had issues with it. I also had issues with my windshield wipers which I ended up replacing after I was told they were not at fault. I've been having problems starting the car or either it would cut off while driving and cause problems for me to restart it. I recently took it to a dealership to have the recall issue fixed but I was informed that other issues also occurred and gm refused to fix. *Js

On april 28, I called a dealer in syracuse, ny about getting the recalled ignition switch replaced. Called last week about it. They still haven't ordered it. Three weeks ago I called another dealership, davidsons in watertown, ny. Still haven't been contacted by either of these. How long should we have to wait to get this dangerous situation resolved.. *Tr

Tl* the contact owns a 2005 saturn ion. The contact stated that while driving approximately 40 mph, the driver made a sudden turn when the engine stalled and caused a loss of steering control. The driver then traveled down and crashed into an embankment. There were no injuries and a police report was filed at the scene. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was 165,000.

Tl* the contact owns a 2005 saturn ion. The contact stated that while turning at approximately 20 mph, the vehicle stalled. The contact stated that the failure was experienced multiple times. The vehicle has not been repaired. The manufacturer was notified of the failure. The approximate failure mileage was 200,000.

My car constantly does not start. Also, when I go over speed bumps or hit pot holes my car will turn off. *Js

My daughter was driving to work through a wintry mix precipitation when she lost control, was turned to the right into a guardrail, which heavily damaged the front end and caused her to spin coming to a stop on the road. The damage seems like it should have caused airbag deployment, but the airbag did not, and she struck her head on the steering wheel. She felt as though she hit a patch of slush that pushed her to the right. The vehicle is a total loss and in custody of my insurer. The following day I received...

Tl* the contact owns a 2005 saturn ion. The contact stated that the vehicle suddenly stalled while traveling various speeds. The contact also stated that upon inspection, it was found that the control arms and bushings needed to be replaced. The vehicle was taken to the dealer where the failure was confirmed. The stalling issue was not diagnosed. The vehicle was repaired. The manufacturer was contacted about the failure. The failure mileage was not available. Updated 06/10/14*lj the consumer stated the vehicle...

When I was pulling out of the parking lot of my job there is a slight dip in the road when exiting the parking lot on to the street and as I was pulling out making a right turn and I went over the bump and my car shut off and I was not aware it had shut off until I was almost at a complete stop. That was the very first time it happen, it shuts off almost every time I hit a bump. *Tr

On october 31, and november 1 of 2013 I was traveling approximately 40 mph and in nearly the same spot the saturn lost complete power and died. Both times I was able to get off the road. After the second incident we had it towed to a garage where they replaced the battery. I did not drive it again and currently it is in storage as I purchased a new car. I drive 350 miles a week to work and need dependable transportation. When the recall came out we realized we may have had trouble with the ignition switch for up to...

We bought our 2005 saturn ion used sept. 4, 2012,(87,812) Before even could take off lot they had to install an ignition cylinder and cut new key, and the throttle was stuck could press all the way to floor, and would only get up to about 20mph. This was also fixed. (Or so we thought). Since our purchase, we still have trouble with the key getting stuck, it not turning off with car still running, or the car won't start, it happens so much that our daughter who drives it just figures that's they way it's suppose to...

Tl* the contact owns a 2005 saturn ion. The contact stated that the vehicle would not start intermittently and without any warning. The vehicle was taken to the dealer where they advised that they were unable to duplicate the failure. The vehicle was not repaired. The manufacturer was contacted and offered no assistance. The failure mileage was approximately 78,000. The current mileage was approximately 103,000. *Tr

When the car sits for a day or more it won't crank and needs to be jumped off. The battery and altenator are good and so are the fuses. I have changed ignition relay and no difference. Had car running and would not this morning after sitting for 18 hrs. Batt is totally dead. *Tr

June 12-my car received complimentary maintenance. At which point, the car would not start. The body control was replaced. After moving over 1800 miles, the car would not start. June 16-had it serviced again and to my knowledge, the car had been damaged during servicing at dealership ( dropped off foot jack and damaged radiator and ac condenser). June 17-after commuting 80 miles and the passing of 9 hours, the car would not start again. Then after 3 hours, it started ( as I was in an unfamiliar location). June...