2005 Toyota 4RUNNER Problems, complaints & recalls

Head gasket failure. 2005 toyota 4runner generation are notorious for head gasket failure. Due to the poor manufacturing of the gasket it has been deteriorating and has allowed coolant to leak into the cylinder causing misfires and possibly more damage internally. including permanent mechanical breakdown or a completely ruined engine block. High risk of Hydrolock, Damaged Engine Bearings and Sludge, Severe Overheating, Catalytic Converter Failure. Any of these effects cause by this head gasket failure will be...

I have a 2005 Toyota 4runner with frame rust that has caused everything under my 4runner to rust. Toyota knows these frames have problems with rust and corrosion and have done nothing, I am far from being the only one with this complaint or problem. It is up for inspection anytime. I have taken it to get work done at shops and been turned away because of the amount of rust on all bolts, lines, all metal under truck causing it to be a liability. I cant even get my skid plates off to fully address the issue. ...

Odometer Fraud. The contact purchased a 2005 Toyota 4Runner. It was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 217,000, and at the time of registration, it was discovered that the mileage was 342,912.

Premature/unsafe frame rot

The contact owns a 2005 Toyota 4Runner. The contact stated that while driving at an undisclosed speed, the vehicle briefly hesitated and was unable to accelerate, prompting the contact to discontinue driving the vehicle. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the catalytic converter. The contact was also made aware that the mechanic discovered excessive corrosion covering the entire subframe of the vehicle. The contact was advised not to drive the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 205,000.

- The undercarriage and frame have had premature rusting for years. The car is otherwise in excellent condition due to my care of it over the last 20 years. 5 years ago, a service person at my local Toyota dealership said, "I'm really disappointed in Toyota, I've never seen rust like this." I have now recently been told by a local service shop that it's time to get a new car. The lines are all corroded for the power steering, etc, and he was unable to even "touch them," and said that the rust issue is no longer...

When I first saw the pictures on the internet, I noticed that the front underside appeared to have rust issues. (Frontal shot) I contacted that sales person and he blew me off when I requested photos of the underbody. After several attempts, he finally sent a couple of pictures. The pictures obviously did not show the major rust issues as I have provided. The pictures were carefully fabricated not to show the major rust issues. It was apparent that the vehicle was taken off the internet while they hid the rusty...

ENTIRE body frame has excessive rust, holes, and cracks. It is available for inspection. Toyota dealership says it is safe to drive for now but it is failing. I feel any cracks, rust, holes, separation of frame components places all occupants and anyone near the vehicle at risk for when anything fails - this could be when the vehicle is on the expressway in motion (such as when the GM ignition switch failures happened), causing catastrophic loss of life, injuries, and damage to all. It's not a matter of "if" it...

Frame rot. The frame on the 4Runner is a known problem for excessive rot. My frame is shot. There is no reason a frame on a 2005 should be rotted. I was advised by my mechanic that my frame is dangerously close to snapping in half. This needs fixed by Toyota!

Under frame is rusted. The area between the doors in the passenger side is gone. only the top face of the member is present.

Frame has very severe rust and has started to come part in places. Soon vehicle will no longer be road worthy.

Rear hatch glass broke during defroster operation. Started to smell a burning smell and then moments later the entire rear hatch glass shattered. Known issue by Toyota. They issued a brief Warranty Enhancement Program (ZG7) in March 2017 thru April 2018 but are refusing to honor current issues.

Excessive frame rusting. There are holes in the frame from rusting. At this point in time there isn't anything I can do about the issues. Frame is unrepairable.

The contact owns a 2005 Toyota 4Runner. The contact stated that the subframe was rusted. The TPMS warning light was illuminated. The vehicle was taken to an independent mechanic, who repaired the TPMS, but the failure persisted. The vehicle was taken to the local dealer, where it was diagnosed that the frame was rusted and recommended that the vehicle no longer be driven. The mechanic referred the contact to the manufacturer. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 200,948.

Frame of the vehicle is showing rust corrosion. The frame are the same as the tacomas that were released the same year. The tacomas were granted frame replacement by Toyota but 4Runners weren't. Noticed a lot of other 4th generation 4Runners are having the same issues.

The rear window shattered while using the rear window defrost.

Frame has rusted through and the boot of the frame that holds the front driver side suspension is 3/4 of the way cracked. Independent Body shop rendered car unsafe to drive.

The contact owns a 2005 Toyota 4Runner. The contact stated while the vehicle was at the independent mechanic for servicing, and he was informed that the sub frame was severely corroded. The dealer was notified of the failure and referred the contact to the manufacturer. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 166,000.

The rear windshield shattered suddenly without any apparent reason. At first I thought something had smashed onto our car because there was a loud smashing sound as it a sheet of ice fell on the roof of the car, but it was not a snowy or icy day and there was no rock or branch by the car. It was rainy and cold and I had the wipers and defroster on so the only thing I could think of as the problem was the temperature of the glass and defroster caused the glass to shatter. I had all three of my children in the car (all under 6 years of age) in the backseat and I was lucky none of the shattered glass projected into the air on to them. The entire windshield was shattered.

The contact owns a 2005 Toyota 4Runner. The contact stated that while her brother-in-law was inspecting the vehicle battery, he activated the rear windshield defroster and the rear windshield exploded. There were no injuries sustained. The vehicle was taken to an auto glass repair mechanic, where it was diagnosed that the defroster motor and the rear windshield wiring had melted. The auto glass repair mechanic replaced the rear windshield and referred the contact to the dealer for the defroster motor replacement....

Frame on 2005 Toyota 4Runner has excessive rust due to Toyota's negligence on frame production. I can make it available if needed. My safety is 100% compromised, had my mechanic not have told me of the issue, I would have kept driving the vehicle and the suspension could have detached from the frame at any point. The problem has been confirmed by my independent service center South Lake Automotive. It has not been inspected by police, manufacturer or other. There was no warning prior to the failure. Had I not had it pointed out as an issue, I would never have known it was an issue.

The frame and complete undercarriage is completely prematurely rusted.

The frame on both sides of the vehicle in the front, where it connects under the radiator crossbar has rusted through.Not feeling to safe about this. also the transmission cooling lines are also looking thin. The dealership I have maint. done at informed me of this condition. Can send pictures if needed.

My frame has rotted through, causing the rear bump stops to fall off, putting excessive wear on both frame and suspension components. In parts of the frame, it has rotted all the way around and caused a loss in structural integrity. Worst of all, there is a hole near the rear most strap holding the gas tank to the chassis, which is a risk to not only me and my pregnant wife but others driving on the road around me if it where to fall off. Looking at the body, there is no rust or corrosion. The same goes for the engine bay, the rust is entirely located on the frame. Mechanically, the vehicle is in excellent shape. It has now got to the point it will no longer pass a NYS inspection.

I was driving my 4Runner and the rear glass exploded and shattered. This is a known issue with Toyota and documented in T-SB-0189-17 and warranty enhancement ZG7. There were no warning lamps, messages or other symptoms of the problem prior to the glass shattering. Toyota refuses to cover the repair costs and the estimate provided by the dealer is $1,200. Photos were taken in my garage when I got home immediately after the explosion occurred.