- The problem
- Volvo Trucks North America (Volvo) is recalling certain 2004-2019 Volvo VHD trucks equipped with snow plow lamp preparation kits. The snow plow headlights can be turned on without other exterior lights, and high beam indicator will not work when the snow plow high beams are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
- The risk
- The driver may operate the vehicle with the snow plow headlights on but the marker and tail lamps off, reducing the vehicle's visibility and increasing the risk of a crash.
- The fix
- Volvo will notify owners, and dealers will update the software related to the plow lights, free of charge. The recall began December 19, 2018. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1804.
Vehicle safety record
2006 Volvo VHD Problems, complaints & recalls
No owner complaints about the 2006 Volvo VHD have been filed with NHTSA. It is covered by 6 recalls, the latest in October 2018 for the exterior lighting.
NHTSA data checked
BFewer problems than a typical VHD year, for its age
- Complaints
- 0
- Recalls
- 6
- Crashes
- 0
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
2006 Volvo VHD recalls 6
Recall repairs are free. Your dealer fixes them whether or not you bought the car there - check your VIN at nhtsa.gov/recalls to see if yours is done. What to do
- The problem
- Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. Therefore, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 210, "Seat Belt Assembly Anchorages."
- The risk
- In the event of a crash, an insufficient seat belt weld may prevent the seat belt from properly restraining the occupant. This increases the risk of injury to the seat occupant.
- The fix
- Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
- The problem
- Volvo trucks is recalling 127,764 my 2001-2008 vhd, vnl, vnm, and my 2005-2008 vt trucks. A seal may fail allowing water and contaminants to seep into the windshield wiper motor.
- The risk
- If this happens a short circuit may occur, which over time could possibly lead to a vehicle fire.
- The fix
- Volvo will replace the wiper motor free of charge. Since this recall involves a large number of vehicles, volvo will release the recall in stages as parts are received. Priority will be given to the vehicles located in the regions/states that have a corrosive environment. The recall began on september 30, 2009. Owners may contact volvo trucks at 1-800-528-6586.
- The problem
- On certain heavy duty trucks, the circuit protection (i.E. Automatic circuit breakers) used to protect the vehicle lighting system may not provide adequate protection.
- The risk
- If a short circuit occurs and is left untreated, components and wiring may be subject to overheating which could possibly result in a vehicle fire.
- The fix
- Dealers will replace the circuit breakers with fuses. The recall began on february 25, 2008. Owners may contact volvo trucks at 1-800-528-6586.
- The problem
- On certain trucks, the wheel spacer may become distorted from heat which potentially could lead to a loss of clamp that may result in loose wheel nuts.
- The risk
- If the wheel nuts loosen for any reason, damage to the wheel studs and wheel may occur, and may lead to a complete separation of the wheels from the truck which could result in a vehicle crash.
- The fix
- Dealers will replace the wheel spacers and the wheel equipment (wheels,studs, and hub) will be inspected for damage and replaced if necessary free of charge. The recall began on june 26, 2006. Owners may contact volvo trucks at 1-800-528-6586.
- The problem
- On certain trucks equipped with d12d engines, the exhaust gas recirculation (egr) cooler inlet pipes or the pipes that connect the egr valves to the cooler may crack or break.
- The risk
- If the pipes or the cooler inlet pipes fail and are left untreated, the air cleaner and inner fender may be subject to hot exhaust gases, which could lead to a fire.
- The fix
- Dealers will inspect and repair the egr cooler pipes as required and install a heat shield free of charge. An interim owner letter was mailed on february 17, 2006, to advise on precautions that the owner can take until parts become available. Owners are being notified starting march 3, 2006, that parts are now available. Owners may contact volvo trucks at 1-800-528-6586.
What owners say
Be the first VHD owner to share.
Problems or none - your experience is exactly what the next buyer is looking for. Write it now
No complaints about the 2006 Volvo VHD yet
No owner has filed a complaint about this vehicle with NHTSA. If yours has a problem, share it here and report it to NHTSA.
Volvo VHD: every year compared
All VHD years2006 Volvo VHD vs rivals
| Vehicle | Complaints | Recalls | Grade | |
|---|---|---|---|---|
| 2006 Volvo VHD | 0 | 6 | B | |
| 2006 Volvo S40 | 59 | 3 | D | Compare |
| 2006 Volvo XC90 | 53 | 3 | F | Compare |
| 2006 Volvo S60 | 31 | 4 | C | Compare |
| 2006 Volvo V70 | 24 | 4 | D | Compare |
| 2006 Volvo XC70 | 18 | 3 | D | Compare |
| 2006 Volvo V50 | 12 | 3 | D | Compare |
| 2006 Volvo S80 | 12 | 4 | B | Compare |
| 2006 Volvo C70 | 9 | 2 | C | Compare |
More sales usually means more complaints, so compare similar vehicles of the same year. The grade compares each vehicle with its own model's other years.
Questions about the 2006 Volvo VHD
Does the 2006 Volvo VHD have any recalls?
Yes - NHTSA lists 6 recalls for the 2006 Volvo VHD: exterior lighting (October 2018); seat belts (October 2012); motor (May 2009); fuses and circuit breakers (December 2007) and more. Recall repairs are free at any authorized dealer. Enter your VIN at nhtsa.gov/recalls to see whether yours has been fixed.
How many complaints has the 2006 Volvo VHD had?
None have been filed with NHTSA so far.
Is the 2006 Volvo VHD a reliable vehicle?
Its Safety Index is 61 out of 100 (grade B: fewer problems than a typical Volvo VHD year, for its age). The index weighs complaints, crashes, fires, injuries, deaths and recalls against how long the vehicle has been on the road, compared with the same model's other years. It is not a measure of every repair - read the complaints and owner experiences, and have any used vehicle inspected before you buy.
Which Volvo VHD years have the most complaints?
2003 (3), 2004 (3), 2005 (3). See every Volvo VHD year compared.
What should I do if my 2006 Volvo VHD has a problem?
If it is a safety problem, stop driving it if it is unsafe and contact your dealer. Report it to NHTSA at nhtsa.gov/report-a-safety-problem - enough reports start investigations and recalls - and share your experience here so other owners know what to look for.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data