- The problem
- Workhorse is recalling 5,606 my 2006-2008 w42 commercial chassis and w18 recreational vehicle chassis. The castle nut that retains the steering drag link to the pitman arm may have been improperly torqued during assembly. The improper torque may have damaged the castle nut and compromised the integrity of the connection.
- The risk
- If the drag link were to separate from the pitman arm, the driver would not have directional control of the vehicle possibly causing a crash.
- The fix
- Dealers will replace and properly tighten the castle nut that retains the steering drag link to the pitman arm. The recall began on september 19, 2008. Owners may contact workhorse at 1-877-946-7731 or at http://www.Navistar.Com.
Vehicle safety record
2007 Workhorse W18 Problems, complaints & recalls
Owners have filed 2 complaints about the 2007 Workhorse W18 with NHTSA, most often about the steering (2) and the electrical system (1). It is covered by 1 recall, the latest in August 2008 for the shaft pitman. For comparison, the 2006 has 1 and the 2008 has 0.
NHTSA data checked
CAbout as many problems as a typical W18 year, for its age
#360 most complained-about 2007 vehicle
- Complaints
- 2
- Recalls
- 1
- Crashes
- 0
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
Most common 2007 Workhorse W18 problems
Share of all 2 complaints. One complaint can name more than one area. Tap an area for its complaints and recalls.
2007 Workhorse W18 recalls 1
Recall repairs are free. Your dealer fixes them whether or not you bought the car there - check your VIN at nhtsa.gov/recalls to see if yours is done. What to do
What owners say
Be the first W18 owner to share.
Problems or none - your experience is exactly what the next buyer is looking for. Write it now
2 complaints about the 2007 Workhorse W18
Newest first, as filed with NHTSA by owners.
Tl* the contact owns a 2007 workhorse w18. The contact stated that the vehicle veered left and right while driving approximately 50 mph. The failure occurred without warning. The vehicle was not taken to an independent mechanic or dealer to be diagnosed or repaired. The manufacturer was notified of the failure. The contact referenced nhtsa campaign number: 08v442000 (steering). The manufacturer informed the contact that they had no obligation to complete the recall repair because it was expired. The failure mileage was 8,500.
While vehicle is being driven, entire dash cluster zeros and alarms go off. All instruments then come back on except alarm stays on . Can only silence alarm by unlatching seat belt and re-latching it. This is dangerous ; action must be done while vehicle is rolling generally at speed limit. Cannot have hands on steering wheel and disconnect seat belt and reconnect it. Reported problem to manufacturer months ago they say they are working on it. Also on same vehicle, constant steering is required. Steering is loose...
Read the full complaint
while rolling down road. Manufacturer recommended certain tire pressures and alignment check when vehicle is loaded. I have done this and problem is the same. I have checked forums by other owners and many are experiencing the same problems. I think a recall is in order. *Tr
Workhorse W18: every year compared
All W18 years2007 Workhorse W18 vs rivals
| Vehicle | Complaints | Recalls | Grade | |
|---|---|---|---|---|
| 2007 Workhorse W18 | 2 | 1 | C | |
| 2007 Workhorse W22 | 5 | 1 | A | Compare |
More sales usually means more complaints, so compare similar vehicles of the same year. The grade compares each vehicle with its own model's other years.
Questions about the 2007 Workhorse W18
Does the 2007 Workhorse W18 have any recalls?
Yes - NHTSA lists 1 recall for the 2007 Workhorse W18: shaft pitman (August 2008). Recall repairs are free at any authorized dealer. Enter your VIN at nhtsa.gov/recalls to see whether yours has been fixed.
What are the most common problems with the 2007 Workhorse W18?
By the complaints owners filed with NHTSA, the most common problem areas are the steering (2), electrical system (1).
How many complaints has the 2007 Workhorse W18 had?
2 complaints have been filed with NHTSA, the first on November 28, 2008 and the latest on April 26, 2016. Of these, 0 describe a crash and 0 a fire, and together they report 0 injuries and 0 deaths.
Is the 2007 Workhorse W18 a reliable vehicle?
Its Safety Index is 42 out of 100 (grade C: about as many problems as a typical Workhorse W18 year, for its age). The index weighs complaints, crashes, fires, injuries, deaths and recalls against how long the vehicle has been on the road, compared with the same model's other years. It is not a measure of every repair - read the complaints and owner experiences, and have any used vehicle inspected before you buy.
Which Workhorse W18 years have the most complaints?
2007 (2), 2006 (1). See every Workhorse W18 year compared.
What should I do if my 2007 Workhorse W18 has a problem?
If it is a safety problem, stop driving it if it is unsafe and contact your dealer. Report it to NHTSA at nhtsa.gov/report-a-safety-problem - enough reports start investigations and recalls - and share your experience here so other owners know what to look for.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data