Electrical system

Zero SR Electrical problems by year

3 complaints filed with NHTSA about the Zero SR's electrical system. Dead batteries, warning lights, wiring, alternators, infotainment and electronic module failures.

Electrical complaints by model year

12014 2015 2018

Year	Electrical complaints	Crashes
2018	1	0
2015	1	1
2014	1	1

Latest SR electrical complaints

2014 Zero SR Electrical system Lights Engine & coolingCrash

I could have died. For 7 months my 2014 zero sr has been waiting on zero service. I was originally told a new battery was needed. Motorcycle would not accelerate past 50-55mph and range had fallen from 70-90 miles to less then 20 miles. Zero made excuses for months why they couldn't properly service. I spoke with an aaron several times, also zack. Zero then replaced the controller claiming it was defective and there were no problems with the battery. I finally received the sr back and in heavy traffic, the...

Read the full complaint

motorcycle dropped from a full charge to 18% in only 16 miles and then completely shut off without any warning while going about 40 mph. It would not go faster then 40mph. I managed to move between 2 cars to the shoulder, but I smashed my leg on the railing in the process. Sr turned back on a few seconds later and I made it a mile to the exit before it turned off again as I was crossing the road.

2018 Zero SR Electrical system

I own a zero s 2018, when I often experience problems and the motorcycle does not start. Zero does not give support even though I have a 5-year warranty, no training, no information. There is no dealer in israel, I also sent them a few emails on the subject. I did not get an answer other than advertisements about the new motorcycle they're investing in. I would like your help to find a solution for my problem and dozens if not hundreds of israeli zero-type motorcycle owners.

2015 Zero SR Electrical system LightsCrash

I am a new owner of this motorcycle and it falls out the light and as I noticed uncontrolled the signal light, brake booster, abs .. . It is very dangerous to drive with this bike and you could get a penalty in our country . The motorcycle was only used for short distances. I have the opinion that not every customer can be an expert and constantly check the newly purchased (6000km total mileage) motorcycle for manufacturer error or even worse maybe an accident. The manufacturer refuses any warranty processing by...

Read the full complaint

the reasons that it has not been built during this period even though the same fault has occurred. Apparently there is the problem with several dc / dc controllers and the internet is full of very discusse about that. Unfortunately, I can no longer check that 2014 (from this year is the regulator) models have the same problem since the information about zero motorcycles disappeared at your hompage. I think it is definitely not the problem of the customer to pay the product errors. I have still one time the accumulator had already a capacity failure and a power drop of the engine to zero during one ride !!

Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked daily. Complaints are owners' own reports and are not verified. How we use the data