Volkswagen Group of America, Inc. (Audi) is recalling certain 2022 Audi A6 Sedan, A4 Sedan, Q5, and Q5 Sportback vehicles. The semiconductor inside the engine control unit may short-circuit and cause an engine stall.
Engine & cooling
Audi A6 Engine problems by year
223 complaints filed with NHTSA about the Audi A6's engine & cooling. Stalling, loss of power, oil consumption, overheating, head gaskets, timing chains and engine failure.
Engine complaints by model year
Engine recalls
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2017 Audi A5 Cabriolet, A5 Sedan and Audi Q5 vehicles, 2012-2015 Audi A6 vehicles and 2013-2016 Audi A4 Sedan and A4 allroad vehicles. These vehicles, equipped with 2.0l Turbo FSI...
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2017 Audi A5, A5 Cabriolet and Q5 vehicles, 2013-2016 Audi Allroad and Audi A4 vehicles and 2012-2015 Audi A6 vehicles. These vehicles, equipped with 2.0l Turbo FSI engines, have an...
Vehicle description: passenger vehicles. If the engine backfires during a cold-start, an air screen which is loosely seated in the air flow meter can become damaged.
Latest A6 engine complaints
While operating the vehicle under normal driving conditions, the vehicle suffered an immediate, un-commanded loss of engine power and throttle response. The vehicle displayed a critical dashboard restriction stating: "Maximum engine speed 2500 RPM", forcing an emergency limp-home mode that instantly created a roadway collision hazard. Simultaneously, the vehicle's primary safety and convenience systems dropped completely offline, displaying synchronized, consecutive malfunction alerts for the Central Locking...
Read the full complaint
System, Audi Pre Sense (Distance Monitoring), Cross Traffic Assist, and Lane Change/Blind Spot Warning systems. A subsequent professional diagnostic scan confirmed that the vehicle's Engine Control Unit (ECU) has hard-logged active manufacturer fault codes P310A (Low Fuel Pressure Regulation - Fuel Pressure Fluctuates) and P310B (Low Pressure Fuel Regulation - Fuel Pressure Outside Specification). These synchronized electrical and drivetrain failures occur intermittently, yet have specifically occurred multiple times following exposure to moisture, including rainfall, winter slush, and standard car washes. The identical electrical system dropouts were officially reported to two authorized Audi dealership service centers during its active warranty window, but the underlying system failures remain uncorrected, leaving a recurring safety hazard unaddressed.
The factory-installed mechanical water pump module suffered a severe internal seal and housing failure. This allowed pressurized engine coolant to migrate directly into the engine's vacuum control system and vacuum lines, damaging crucial emissions and vacuum tubing. This defect poses a severe safety risk as coolant entering the vacuum grid can cause sudden loss of engine power, erratic braking assist, and localized engine overheating while operating the vehicle at highway speeds.
On [redacted] my 2014 Audi A6 failed to accelerate on a parkway. An EPC light appeared. I restarted. It reappeared and car was slow and shaky. I took right to nearest Audi dealership. The next day, they sent this video, admitting a common problem, and suggesting full engine replacement. [[redacted]] I have contacted Audi of America, Audi of Huntington and Audi of Manhattan. All refusing to help with our faulty engine. Further investigation shows so many cases on Audizone, North Anerican Audi Owners groups. Why was this not a recall? Could have been very dangerous highway accident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
My 2019 Audi A6 was diagnosed with catastrophic internal engine failure on May 9, 2026 at Audi of Newton, Newton, NJ, at 93,645 miles. The vehicle required a full engine rebuild performed by REV Auto NJ at a cost of $12,000. The failure involved metal debris found in the engine oil, consistent with the documented EA839 3.0L V6 TFSI rocker arm needle bearing failure or piston skirt failure affecting this engine family. The EA839 engine used in this vehicle has a documented history of design defects: (1) Rocker arm...
Read the full complaint
needle bearings in early production engines were undersized and prone to disintegration, releasing metal debris into the oil supply and destroying camshaft lobes, balance shafts, and pistons. Audi silently revised the rocker arm part number three times (06M109417H -> 06M109417L -> 0P2109417), with the final revision featuring bearings twice the size of the originals - evidence of a known design defect. No recall was issued. (2) Audi of America issued a Piston Skirt Limited Warranty Extension in 2025 to 8 years/80,000 miles for EA839 piston failures. Independent engineering analysis by 034Motorsport, backed by laboratory testing, confirms that the EA839 piston design creates failure paths even under stock, unmodified conditions. Audi of America has not issued a safety recall for this engine failure pattern despite multiple documented failures across the A6, A7, A8, S4, S5, SQ5, Q7, and Q8 platforms sharing this engine. The failure mode - metal debris circulating through the lubrication system - poses a risk of sudden, complete engine loss while driving at highway speeds, creating an unreasonable safety risk to vehicle occupants and other motorists. I am requesting that NHTSA investigate the EA839 3.0T engine for a potential safety-related defect and consider whether a recall is warranted across the affected model population. I have incurred $12,000 in repair costs for a defect that evidence strongly suggests is a design flaw, not a maintenance issue.
I recently brought my 2019 A6 to Nyack Audi for an unrelated repair, after performing their complimentary inspection the service advisor told me my water pump was leaking coolant into the vacuum hose system; and the pump, PCV valve, sensors, solenoids and vacuum hose system need to be replaced, costing $6,186. My A6 was out of warranty at that point, so Audi would not pay for the $6,186 in repairs. Engine coolant purportedly leaks into the vacuum system and other electrical components, causing contamination of...
Read the full complaint
the vacuum system. Leaking coolant will cause an overheated engine and possible FAILURE of the (EA839)engine and even the turbocharger . Today I did some online research line research and discovered a class action lawsuit involving their 1.8 & 2.0 engine water pumps which failed prematurely for the same reason. A major class-action settlement (Zhao v. Volkswagen Group of America) was approved covering certain 2014-2021 Audi vehicles equipped with 1.8L and 2.0L engines. And now, there is a class action involving the 2.9 & 3.0 V6 engines; "the lawsuit alleges the water pumps are defective in Audi's 2.9-liter and 3.0-liter EA839 V-6s; these engines were available in nearly every Audi model on sale from the 2018 to 2024 model years. The lawsuit - Larr, et al., v. Volkswagen Group of America, Inc., et al. -has been filed in the U.S. District Court for the District of New Jersey". Apparently, Audi has know about this issue since at least 2018 and done nothing to try and resolve it. Please put the pressure of the federal government on Audi to settle the lawsuit, DO THE RIGHT THING and cover the cost of repairs. Also find a solution to prevent this from happening to other Audi owners. I can't afford $6,186 for a repair, nor go purchase a different vehicle.....Rock & a hard place. Please help. Thank you .
The contact owns a 2021 Audi A6. The contact stated while driving at an undisclosed speed, the vehicle overheated. The engine overheating and the low coolant warning light illuminated. In addition, the engine seized. The vehicle was taken to the dealer where it was diagnosed with a coolant leak and a failed coolant pump vacuum. The contact was informed that the coolant pump vacuum assembly needed to be replaced. The vehicle was not repaired. In addition, the contact was informed that the failure was a known failure...
Read the full complaint
of the vehicle. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline and report the failure. The failure mileage was approximately 80,000.
Thermostat housing and oil cooler bracket leaking coolant with only 56k miles on the car
Every single EA839 Audi Engine has piston skirt and cylinder scoring.
Complete shut down of all electrical associated components while driving on highway Loss of power steering loss of braking loss of ability to accelerate transmission failure loss of lane detection, loss of car detection. Diagnosed as , faulty alternator recall repaired and continuation of same electrical failures despite six additional repairs Multiple failures of all electrical components on highway road and side roads
My 2019 Audi A6 sedan displays warnings for the Start/Stop system malfunction indicated in Audi's document: "Emissions Service Action Code: 27BQ" [[redacted]] I'm still waiting to hear if this has been elevated to Recall status. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
It was recently began to leak fuel from the top of the engine close to the windshield. Then the whole cabin specially in the front where the steering wheel began to have bad vibration during reversed, and idle, also when the ac is on. Then theres the airbag for the passenger, the light is on, it used to say '"off" then when the seat is used it will shut off. Now it just stays on. Last is the ac compressor seems to be rattling like a bolt is loose. All the recalls have been happening with my audi and still my vin is not included.
The water pump on my 2016 Audi A6 has failed multiple times prematurely. The first water pump failed at 36,965 miles in May 2019. That repair was covered under an extended warranty I purchased. The second water pump failed around 83,000 miles in September 2025, and Audi is now quoting me $2,350 out of pocket to replace it. I am now facing a third water pump replacement, which is far earlier than expected for this type of component. These repeated failures create a significant safety concern, as sudden coolant loss...
Read the full complaint
can cause the engine to overheat, potentially leading to engine failure or loss of power while driving. Each problem has been diagnosed and confirmed by an authorized Audi service center. The vehicle was inspected by Audi technicians, and repairs were recommended both times. The repeated failure of this critical component strongly suggests a systemic defect with the water pump design on this model. Despite a recent Audi water pump settlement, my vehicle was excluded, even though it has now experienced two failures and is requiring a third replacement.
My water pump failed at 49,000 miles. I have been advised by Audi that it is not covered by the extended warranty for some similar cars.
This vehicle had a claim for water pump replacement and the 3.0 model has a recall for the turbo charger. This vehicle is experiencing the same issues and went from 70 mph to 0 and stalled on the freeway. Thankfully the semi and other vehicles were able to avoid me or my family would be reaching out instead of me. Currently the vehicle is parked in my garage because it is unsafe to drive. Can you please advise Audi to take responsibility and offer the same recalls on the 2.0 vehicles for the water pump and turbo charger because they have the same internal parts as the 3.0 vehicles that failed and these parts were covered.
I purchased a 2014 Audi A6 2.0T Quattro premium plus on November 15, 2024 with 99,141 miles. I got the 14 day dealership extended warranty, which covered powertrain systems. After 3 days of driving exactly 103 miles the oil light came on my dashboard telling me that the oil was low. I immediately brought it back to the dealership and their mechanic look at it, he said there was nothing wrong and changed the oil so it should be good now. I drove it another 3 days 136 miles this time, and the oil light came on once...
Read the full complaint
again. Brought it back a 2nd time to the dealership's mechanic. After about a week, we heard back and they told us he still couldn't find anything wrong, but agreed that for some reason, the engine is consuming oil more than it should be. At this point we go to an actual Audi dealership where they tell us that the pistons and turbo were the problem so they would have to rip apart the engine and seal everything back up. At the time we purchased the vehicle on top of the 14 day dealership warranty we also purchased an extended warranty by a company called integrity warranty LLC. Our warranty company decided that they were not going to cover the cost of the parts and labor in order to fix my Audi, because they said it was a pre-existing issue prior to us purchasing the vehicle which we had not heard of before, or even seen on the Carfax report. On February 25 I was driving at night 25 mph and I came to a red light stopped my car and began smelling a very strange smell. Saw a lot of smoke coming from the exhaust in the back, the dashboard lights began flickering, the steering wheel start to shake, and then the car just shut down. Now I am without a vehicle, the dealership will not help us, the warranty company will not help us, and I now have to purchase a new car while still making payments on the Audi that doesn't work.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked daily. Complaints are owners' own reports and are not verified. How we use the data