- The problem
- Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
- The risk
- An engine compartment fire increases the risk of injury.
- The fix
- Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S54.
Engine & cooling
2021 Ford Escape Engine problems
Owners have filed 49 complaints about the 2021 Ford Escape's engine & cooling with NHTSA - 14% of all its complaints, most recently on November 2, 2026. They describe 1 crash, 5 fires and 0 injuries. Stalling, loss of power, oil consumption, overheating, head gaskets, timing chains and engine failure.
- Complaints
- 49
- Recalls
- 4
- Crashes
- 1
- Fires
- 5
- Injuries
- 0
- Deaths
- 0
Engine recalls for the 2021 Ford Escape
- The problem
- Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
- The risk
- An engine compartment fire increases the risk of injury.
- The fix
- Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will replace the engine long-block in 2023 Escape and Corsair vehicles. For the other vehicles, dealers will update the powertrain control module software. If a connecting rod bearing failure is detected, dealers will replace the engine long-block. All inspections and repairs will be performed free of charge. Owner notification letters were mailed on June 14, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S27. This recall expands and replaces recall number 22V-484. Vehicles previously repaired under 22V-484 will need to have the new remedy completed.
- The problem
- Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
- The risk
- An engine compartment fire increases the risk of injury.
- The fix
- Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will modify the under engine shield and active grille shutter, free of charge. Owner notification letters were mailed August 19, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S47.
- The problem
- Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2022 Bronco Sport vehicles equipped with 1.5L engines. The engine oil separator housing may crack and develop an oil leak.
- The risk
- An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
- The fix
- Dealers will inspect the oil separator for damage or oil leaks, and replace the oil separator and seals, as necessary, free of charge. Owner notification letters were mailed April 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S21.
Engine complaints
Car is experiencing internal engine component deterioration under Recall 23S27. Auffenberg Ford in O'Fallon, IL cleared the critical P1061 safety code on October 6 using my code reader, saying they didn't have time to hook it up to their system and sent me home with an appointment to bring it back in, without fixing the vehicle. Ford Corporate is now utilizing that unauthorized deletion to deny my engine replacement under Customer Satisfaction Program 23N06, forcing me to drive a vehicle with a documented catastrophic engine failure and fire risk until it either throws the code again or catches fire, possibly killing one of my children, or throws a rod.
The contact owns a 2021 Ford Escape. The contact stated that while driving at an undisclosed speed, an unknown warning light illuminated. The contact stated that the failure was intermittent at first but later became persistent. The vehicle was taken to O'Reily's where it was diagnosed with fuel control module failure, turbocharger failure, and powertrain failure. The contact was notified of three open recalls associated with the VIN. The contact stated that while driving at an undisclosed speed, the accelerator...
Read the full complaint
pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle lost motive power and the engine seized. The vehicle was towed to the dealer. The contact was informed that the parts were unavailable to repair the vehicle. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The failure mileage was 100,000.
Description of Defect & Safety Risk: Complete structural failure and collapse of the entire 3-part powertrain mounting system (right engine mount, left automatic transmission mount and rear lower engine torque strut mount). The severe defect was discovered at a mere 27,000 original miles by a certified independent technician fount the broken motor mounts during inspection, and I confirmed experiencing excessive, violent vibrations inside the vehicle cabin radiating heavily through the chassis. Total failure of...
Read the full complaint
these primary structural supports creates an immediate under-hood hazard. Severe engine shifting or total powertrain displacement while in motion can pinch fuel lines, sever electrical wiring harnesses, or snap CV axles. This poses an imminent risk of sudden highway propulsion loss or loss of vehicle steering control. Consumer notes that Ford TSB 20-2215 identifies an identical 3-part powertrain mount failure on this exact vehicle platform.
Engine will periodically and randomly stall and quit while driving. Mostly in city but it quit while driving on highway I-10 at 65 mph in one incident.
Coolant intrusion caused full engine to need to be replaced. Started with white smoke and engine overheating.
My escape would not change gears and the escape would not reverse it was also pulling back and accelerating in speed to the point I could not control it in traffic. My safety and the safety of my mother were greatly affected as the escape was malfunctioning in traffic and I could not control the gears. The alert on the escape came up and it stated: The powertrain control system has detected one of the transmission clutches did not apply within the expected time as expected. Some transmission gears may not being...
Read the full complaint
available resulting in delayed or harsh shifts into another gear. Additional alerts that may provide additional information may accompany this alert. I took it to dealership and they told me it would need a transmission over haul. Once repairs were completed I brought it back home and had to take the escape back to the dealership because it started to pull back again and for the second time the dealership told me the escape would need a second transmission overhaul
Complaint to the National Highway Traffic Safety Administration (NHTSA) I am filing this complaint regarding an unresolved safety recall on my vehicle. This recall has remained open for more than one year, yet no remedy has been made available. Despite the manufacturer acknowledging the safety defect, I continue to operate a vehicle that presents significant safety concerns because the defect has not been corrected. The recall has caused my vehicle to experience severe drivability issues, including engine...
Read the full complaint
failure, excessive rough idling, and violent shaking while the vehicle is operating. These conditions create an increased risk of the vehicle stalling unexpectedly, reducing my ability to safely operate the vehicle and placing myself, my passengers, and other motorists at risk. Additionally, because of the unresolved recall condition, my vehicle is unable to pass the required state safety inspection. This has left me with a vehicle that I cannot fully utilize or register while I continue waiting for the manufacturer to provide a repair. It is unreasonable for consumers to wait more than a year for a safety recall remedy while continuing to experience hazardous operating conditions. I respectfully request that the NHTSA investigate the manufacturer's failure to provide a timely remedy, determine whether it is complying with its obligations under federal motor vehicle safety laws, and take appropriate action to ensure affected owners receive a prompt repair or other appropriate relief. I have retained documentation regarding the recall, the symptoms affecting my vehicle, and the impact this unresolved defect has had on my ability to safely operate and maintain the vehicle. I am prepared to provide this information upon request.
My car was at only 55,000 miles, there was a weird shuddering and my RPMs were very jumpy. It almost felt like my car was going to stall out. I took it in to the ford dealership and I had to get my Torque Converter replaced. I had no dash lights on or any other problems. I got it replaced, but my car still feels shaky while at low speeds. Apparently it's a very common problem in this car.
On [redacted] I was driving my 2021 Ford Escape for 10 minutes before I stopped at Sheetz gas station on [[redacted]]. I ran into the building to withdraw cash from the ATM leaving my fiance and dog in the car while it sat idle. Upon exiting the building about 30 seconds to a minute later, I witnessed smoke coming up from the hood of my car. My fiance and Dog quickly evacuated the car as we saw flames emerging. I ran inside to get assistance from the workers and they brought out fire extinguishers. The attempt to...
Read the full complaint
extinguish the flames was unsuccessful and the front of the car quickly went up. Police and fire department were called and they showed up about 10 minutes later to handle the situation. Reports from the officer, fire department and the Sheetz assistant were taken. I do not have access to those. My car insurance is covering the cost of the vehicle and a 7 day car rental. They are not covering the loss of both mine and my fiance's cell phones. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Windows and engines
Canister purge valve getting stuck open and causing a hard start
The contact owns a 2021 Ford Escape. The contact stated that while driving at an undisclosed speed, the engine coolant overheated warning light illuminated. The vehicle stalled after the warning light illuminated and became inoperable. The dealer was notified of the failure; however, the vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 39,700.
My vehicle has had a fuel injector recall since 07/2025. My car has gradually started to idle and drop rpms. It starts when the vehicle was only in park and now it is happening when I am in drive and foot is on the brake. I am not sure what to do because of the open recall with no repair options in sight almost a year later.
Everytime I drive the car and I don't get no warming and I bring the car to the dealer and tell them what going on and dealer do and don't tell me what going on.. i should be able to get another car free because they want me to keep pay thing out my pocket which I don't have Also want to let you know that [[redacted]] and I will like to explain more on phone [[redacted]] Also the ford dealership want me to trade in my car for 2,000 which my car is value7,000 because what three thing broken and they want 5600...
Read the full complaint
it not right because I just have Tht car right after my mother pass away and it only 2 years now INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2021 Ford Escape. The contact received notification of an undisclosed recall. The contact stated that while driving on several occasions at various speeds, the vehicle hesitated and jerked while depressing the accelerator pedal, with the check engine warning light illuminated. The vehicle was taken to a dealer, where it was diagnosed that there was an active recall and the powertrain control module needed a software update. The vehicle was repaired, but the failure reoccurred approximately 5 months later. The manufacturer was not notified of the failure. The failure mileage was approximately 98,000.
I believe my car to be unsafe to drive because of the possibility that it could overheat, crack and release fluids on top of the engine causing a fire. They have yet to have a remedy for this and that is deeply concerning. I fear they often have recalls because FORD is not the best car to own. There's so many problems all the time. It's concerning and I feel like my car is unsafe to drive often.
The recall on the fuel issue was released in July 2025. This is now March 2026. Eight months should be enough time to get the parts needed for this repair. What can you do to see about getting this process accelerated? Thank you.
The entire dashboard/infotainment interface will lose power suddenly. The car will struggle to start, and have an emissions or evap code, and there's a smell from the engine sometimes, that leaks into the cabin, which the cabin has bad thermoregulation, and cold air seeps in QUICK. Also I've driven on the highway and have had all the steering and power stop all at once! The headlights also keep getting popped or burnt out.
There are swveral issues with this model, the worst being the constant jerking/ bucking while driving. The second being the forward collision warning alerting when no vehicles are near you, it just randomly alerts.The third most annoying issue is the dashboard from time to time goes out as if no electricty is flowing throught it, ive also experinced the volume not adjusting properly at times.
It has a recall 25s76 that ford says has no solution. I called ford, and they said it did have one, and that I should take it in. Supposedly, what they did was a software update on 05/01/2025, but nothing worked. The gasoline smell inside the car persists, with a risk of fire.
The contact owns a 2021 Ford Escape. The contact stated that while driving approximately 60 to 70 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The check engine warning light and the charging system service light were illuminated. The message "Vehicle Turning Off to Save Power" was displayed. In addition, there was an abnormal knocking sound coming from the engine while the vehicle was slowing down. The contact stated that the parking brake push button failed to function...
Read the full complaint
as intended. The contact was unable to coast to the side of the road. The vehicle was towed to Auto Zone, where the battery was checked, and the battery passed the test. The tow truck driver had difficulty attempting to tow the vehicle. The vehicle failed to restart, and the auto brake turned on independently. After a while, the vehicle was towed to the contact's mother's residence. The vehicle was later towed to the dealer. The vehicle remained at the dealer pending the results of the diagnostic test. The manufacturer was made aware of the issue; however, no assistance was offered. The vehicle was included in NHTSA Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE). The contact was the second owner of the vehicle and had not received the recall notification. The failure mileage was approximately 79,000.
This vehicle! It eats so much gas. Something is wrong. It makes a weird noise and puts itself into modes of sports, ice/snow, eco, slippery all by itself while I am driving. My RPMs will change and car makes a different sound and it is in a different driving mode without being put in it by me. It puts itself in auto mode and shuts off at red lights and starts back up when I put on the gas and this is not a hybrid.
2021 Ford Escape. In January 2025 the turbo system failed and was replaced by a Ford dealer for about $5,903.85. Around five months later the transmission required repairs for a valve body issue, totaling roughly $3,000 in August. Two months after that repair, Firestone advised that the entire transmission now needs replacement. Each time the problem appeared, the vehicle showed violent slippage while upshifting and downshifting. When coming to a stop, the car would shake violently, slip forward several inches...
Read the full complaint
while my foot was still on the brake, and sometimes hesitate or lose power. Recently the vehicle will stop responding to acceleration, then suddenly surge forward without warning. These repeated transmission failures have created serious safety risks and appear consistent with ongoing problems involving the Ford 8F35 transmission used in the 2021 Escape.
NHTSA Recall 25V467 was issued in July 2025. It has been over 3 months of constant fear for under-hood fire from possible fuel injector crack. My family's safety has been at risk long enough, this needs a permanent fix please!
My engine has been misfiring since I purchased my vehicle from a Ford Dealership in Mooresville, NC. At least, I think it is misfiring. My vehicle did not pass an emissions test and I had it inspected at a Ford Dealership in Statesville, NC. They told me I have a transmission fluid leak. I went to a transmission specialist, and we stood under my car while he showed me that the transmission is not leaking in any way. This when I learned of the fuel injection recall. He wants to help in discerning what the problem...
Read the full complaint
actually is, but I need to address the recall issue first. I have to do something, as I need my car for my Uber side job, but I'm being told that I have no option. Please, help. I'll provide any additional information that you may need. Thank you.
Ford Escape engine complaints by year
Escape engine problems, every yearSource: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data