2018 Ford Escape Engine problems

gasket/ block crack issue. There were many, many vehicles affected by this problem. Ford had offered an engine replacement for cars with this problem, but only if the vehicle was still under the original factory warranty. Ours is not still under warranty and I'm curious as to what my options are to force Ford to admit/assist in my problem.

significantly reduced when the transmission is shifted into Park. The vehicle displayed diagnostic trouble code P0302, indicating a cylinder 2 misfire. I also noticed that acceleration was not as responsive as expected, requiring additional time to gain speed. Upon inspecting the engine compartment, I observed that the coolant level appeared low. These symptoms raise safety concerns because the vehicle may experience reduced engine performance or potentially lose power while driving, particularly during acceleration or when merging into traffic. I stopped operating the vehicle because of concerns about further mechanical damage and driving safety. According to the vehicle's service history, the engine short block was replaced on August 3, 2021, at approximately 28,170 miles. The service history also indicates subsequent cooling-system maintenance. I am concerned that the current misfire and apparent coolant loss may be related to an internal engine or cooling-system defect, including possible coolant intrusion, although the underlying cause has not yet been confirmed. The vehicle has not yet undergone a complete diagnostic inspection by a Ford dealership or independent repair facility for this incident. An experienced mechanic familiar with these engines expressed concern about possible internal engine failure based on the symptoms described, but no physical testing has confirmed that assessment. The vehicle remains parked and is available for inspection

coolant continues to disappear. No repairs have resolved the issue. Based on known problems with EcoBoost engines, an internal coolant leak or cylinder head defect is suspected, but the exact cause is UNKNOWN. This creates a safety risk because sudden overheating can occur while driving, which may lead to engine failure, loss of power, or stalling in traffic. The issue is ongoing and the vehicle is available for inspection upon request.

has done nothing. Regarding the engine failure, a coolant leak was reported by two mechanics but the source of the leak couldn't be identified. It was only discovered it was internal when my vehicle just stopped while pulling forward in a drive through. Luckily it wasn't on the highway but if it had been it could've caused an accident, at 70 mph, that likely would've resulted in minor injuries for not only me but other drivers. Ford has been made aware of this issue by owners of 2013-2019 Ford Escape Ecoboost vehicles but still hasn't issued a recall. Ford refuses to do anything about this and has instructed its customer support team to tell consumers they "can't" (won't) do anything outside of warranty. This issue often occurs outside of warranty. Ford still hasn't issued a recall despite numerous lawsuits for this exact problem. All customers can do is file a complaint. There are thousands of these vehicles on the road and if Ford continues to do nothing this could eventually lead to fatalities due to vehicle collisions. Someone needs to do something if Ford won't. Engine failure 10/20/26; electrical fire September 2026; lighting failure 2023-2026. The fact someone was fine selling this vehicle, despite consumer reports, is appalling.

Ford for basic minor service on April 29 and was told to check diagnostics I had to pay $298. I took it elsewhere and they told me it was a code that came up for the smog system. I didn't have any other issues at that time. In July a different light came on that was flashing so I took it to an independent mechanic and he found the misfire code of P0304 in cylinder #4. He proceeded to replace spark plugs and injector #4. Not until September did the sputtering start but no engine light came on. I took it back to my mechanic and he spent 2 weeks trying different things to figure out what was going on. He was unable to so I had to take it to the Ford service center and they verified the coolant intrusion problem. My car is only 8 years old and there was never a recall or service notice to advise me of this problem.

her life due to the sudden failure and exposure to passing traffic. She reached the shoulder without a collision. The vehicle required an emergency tow through her insurance company, and she received transportation home. The vehicle had undergone a safety inspection in August before this incident. A Ford dealership confirmed an internal engine leak allowing coolant into a cylinder's combustion chamber. A borescope inspection found liquid on top of the piston, and a cooling-system pressure test confirmed coolant entering the combustion chamber. The spark plugs were severely carbon-fouled, causing a misfire. Replacing them temporarily improved the symptoms, but the misfire quickly returned. The dealership determined that the engine requires a rebuild or replacement. The diagnosis appears to correspond to Ford Customer Satisfaction Program 21N12, dated June 9, 2022. We were not notified of this issue before the incident and found no corresponding safety recall for this vehicle in NHTSA's records. This sudden failure caused loss of propulsion and impaired control at highway speed, forcing an emergency maneuver onto a narrow shoulder after dark. The check engine light provided no advance warning. We request that NHTSA investigate this defect and determine whether a safety recall is warranted to prevent similar incidents and injuries.

years old, but that should not degate action from Ford on this. They have never notified Ford customers, and yet this is a safety hazard (can cause enginer to seize and start a fire). I was quoted $15,000 cost to replace the enginer from the dealer. I cannot afford this, but am afraid to drive my car!

P0300 Random misfire detected Cylinder 3 On October 5, 2026, I took it to my mechanic and he began checking everything. He found oil on and inside the computer. He also found that there was antifreeze residue on the Cylinder and Spark Plugs. He did some research to find out what could cause this to happen. He found the following: 1,134-1,711 engine complaints depending on dataset. Failures typically occur between 50,000 and 100,000 miles. Main Engine Problems 1. Coolant Intrusion (1.5L EcoBoost - Most Common & Severe) Coolant leaks past the block/head sealing surface into cylinders. Not a head gasket failure - requires short-block or long-block replacement. Symptoms: Misfire codes (P0300-P0304) White exhaust smoke Unexplained coolant loss Rough idle, stalling, overheating. 2. Cracked Engine Block Often the end result of prolonged coolant intrusion. Leads to catastrophic engine failure requiring full replacement. On Friday, October 9, 2026, I drove my car to work, approximately 2.5 miles, after the Escape sitting for 3.5 hours, I started it. I immediately received the HIGH ENGINE TEMPERATURE STOP SAFELY, and the engine shut off. On the 3rd try, the Escape stayed running. I could only drive 11 mph. On my final turn onto a busy street, the Escape began sputtering and would not accelerate at all. I was stuck in the middle of the street, putting myself at risk of being hit. I finally made it to a parking lot but had to be pushed home by my son.

driving, creating a hazardous situation - especially at highway speeds or in heavy traffic. This poses a significant risk to my safety and the safety of others on the road. Requested Action: I am requesting NHTSA review this issue as a potential recurring safety defect affecting the 2018 Ford Escape. Many owners have reported similar coolant intrusion problems, and a recall or investigation may be warranted to prevent engine failure-related accidents. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

situations. The vehicle leaks hot fluids into the combustions system putting everyone at risk for under hood fires. Has the Problem been confirmed: Yes, my vehicle is currently at the Pennyrile Ford Dealership, they performed a cooling system pressure test and borescope inspection, and confirmed internal coolant intrusion requiring a total engine replacement. They have even confirmed and acknowledged that this is an on going issue! Dealer inspection: Yes Warning Lamps/Messages: Check engine soon light, raised engine levels, rapidly depleting coolant within days of refill, rough idling, cold start rumblings, sweet chemical smell and thick white smoke coming from tailpipe. Ford has already admitted this is an ongoing issue with these systems, I currently have a 2.0 engine but the recall is for the 1.0/1.5.

to scrape a curb - damaging the right tire rim - and collide with a utility pole. Fortunately, no injuries occurred. I managed to bring the vehicle to a stop on a side street. Once stopped, the vehicle exhibited a total "no crank, no start" condition and completely refused to turn over or restart. The vehicle had to be towed to a repair facility. Upon professional diagnostic inspection, the technician discovered extensive engine oil intrusion within the main engine wiring harness. Engine oil had dynamically wicked through the harness directly into the Powertrain Control Module (PCM), completely compromising and shorting out the primary computer. This electronic failure is what triggered the sudden, catastrophic engine shutdown mid-traffic. This vehicle has a chronic history of severe electrical, powertrain, and "no-start" defects at only 56,000 miles, despite being meticulously maintained with routine synthetic oil changes as required. This is the second time I have experienced a life-threatening loss of engine power while actively driving, and I am fortunate to have narrowly avoided a major, high-speed collision on both occasions. In July 2025, the throttle body failed and initiated a dangerous Limp Mode mid-traffic, forcing a tow for replacement. In July 2026, a starter failure resulted in another total "no crank, no start" condition during the holiday weekend, requiring an emergency mobile mechanic. Following this my car has sat for a month.

warranty on the vehicle. The dealer informed the contact that the engine needed to be replaced. A mobile mechanic diagnosed the vehicle and confirmed that the head gasket was cracked. The approximate failure mileage was 94,000.