The open-deck engine design features small coolant passages between the cylinders. Over time, thermal cycling warps the block deck or compromises the head gasket, allowing pressurized coolant to leak directly into the combustion chambers (often cylinders 2 and 3). The check engine light came on. A new engine was required at 62,000 miles on the vehicle. This is a known issue but Fors has chosen not to address it.
Engine & cooling
2019 Ford Escape Engine problems
Owners have filed 400 complaints about the 2019 Ford Escape's engine & cooling with NHTSA - 66% of all its complaints, most recently on November 10, 2026. They describe 3 crashes, 0 fires and 2 injuries. Stalling, loss of power, oil consumption, overheating, head gaskets, timing chains and engine failure.
- Complaints
- 400
- Recalls
- 0
- Crashes
- 3
- Fires
- 0
- Injuries
- 2
- Deaths
- 0
Engine complaints
• I have a P0304 code from coolant intrusion. •Coolant intrusion can cause sudden loss of engine power while driving, severe engine overheating, or engine fires.
Engine was sputtering. We took it to a Ford dealership in Kalispell MT and was plugged into their diagnostic tool. We were told it was an emissions issue but was safe to drive home to [[redacted]]. A few days later the engine failed while on the interstate 3 miles east of Billings MT. We barely got it off the interstate. A warning light read something to the affect "get off road and turn off engine". It was towed to a dealership where we were told before they had even unloaded it that it had a known problem...
Read the full complaint
called coolant intrusion and would need a new engine. We were told that if we had had the 1.5L eco boost engine that Ford would pay for a new engine, but since we had a 2.0L eco boost engine we would have to pay for it. The engine only had 32,000 miles on it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Was told by an automotive repair shop that my car's check engine light codes are P0302/P0316. Current intrusion into the cylinder directly through the head gasket. The technician looked into this issue and found that 2019 Ford Escapes assembled in [[redacted]] in 2019 have these issues. I was not aware of this manufacturing error, and no recall/repair notices were issued. I'm putting [redacted] as my date of incident, even though the manufacturing error was done upon creation. I'm also selecting WA where the incident occurred, but my vehicle was assembled in [[redacted]]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Misfire in cylinder 2. Diagnosed as coolant intrusion. Block and header replaced.
The vehicle suffered a major manufacturing defect known as internal cylinder coolant intrusion, which is common to Ford's 1.5L EcoBoost engines. The vehicle began experiencing rough cold starts and white exhaust smoke before being officially diagnosed by a certified dealership, Folsom Lake Ford, who confirmed internal coolant leaking into the 2nd engine cylinder. The dealership issued a repair quote of $13,000 for a complete engine replacement. Ford Motor Company Corporate headquarters was notified via certified...
Read the full complaint
mail but issued a formal courtesy denial letter refusing any financial or mechanical assistance because the vehicle is outside its standard warranty period. This defect creates a critical roadway safety hazard, as internal coolant leaks can lead to sudden engine overheating, catastrophic block failure, stall-outs in active traffic, or potential engine fires. The vehicle is currently un-driven and parked at my residence due to this safety risk. This newly purchased used car from a dealership was at the end of May 2026. Happened while driving home on the freeway from work, I noticed the engine was overheating. I had to quickly and very nervously move through traffic to get to the shoulder of the freeway in traffic hour. I was traveling up a steep grade and traffic was bunched and slowing, which compounded the problem. I was in the second lane from the left and had to get over, I think 3 lanes to get to the shoulder quickly. It was very scary with all the traffic. Everyone on the road near me was at risk including me. This is a known manufacture defect in this type of engine (1.5L). Happening in July 2026. Why has a recall not been done for this very dangerous known fault of Fords and for anyone to be on the road around these types of engine propelled cars is putting many at risk on the roads. How can this be overlooked???
We received an "engine failure- service now" error message on our vehicle and our mechanic told us it is a known issue with this year, make,model, engine and to take it to the dealership for repair. The dealer, and Ford Motor Company said though the recall is for 2017-2019 Ford Escape EcoBoost engines and for the EXACT same issue, our VIN is not on the current VIN list so it's not covered. Even though this issue is due to a faulty design, thus the recall, they will not cover it. They want $10,000 to fix an issue caused by their design which they have a recall out for. Ford needs to step up and cover this issue under the recall that does apply. Help please.
I have a 2019 Ford Escape. With the EcoBoost 1.5-liter engine. The engine has a well-documented engineering defect that causes coolant intrusion into the cylinders. And ultimately engine failure. Ford created a customer assistance program to deal with this. Its limits are seven years and 84,000 miles. My vehicle is 7 1/2 years old and 96,000 miles so I'm outside their numbers. The problem first presented itself in my vehicle nearly two years ago, but none of the mechanics I work with had any idea about this defect,...
Read the full complaint
And I only became aware of it about two months ago. 1. The entire engine is in the process of failing 2. When it does fin ally fail I may well be driving it (it's my only transportation), which could jeopardize the safety of myself and others on the road. 3. The issue was confirmed by Ford service technicians 4. It has been inspected by the Ford Service Department 5. I started getting random engine warning messages intermittently 2 years ago, but they all pointerd to other issues, even though they were porbably caused by this design flaw. 4.
The coolant system leaked into engine cylinder two. This caused engine block destruction and I was quoted $13,000 to repair the engine. I called Ford and they stated that because the vehicle was at 120,000 miles there was nothing they could do.
At only 43,379 miles - well within the useful life expected of this vehicle - my 2019 Ford Escape developed two significant mechanical failures. (1) Fuel injector: the vehicle emits visible black smoke from the exhaust when accelerating at highway speeds; the dealership diagnosed this as a failed fuel injector requiring replacement (est. $1,200). Visible exhaust smoke during highway acceleration is a visibility hazard to following traffic. (2) Coolant intrusion into the engine: the dealership's service department...
Read the full complaint
diagnosed coolant intrusion requiring replacement of major short block components (est. $8,300), and told me this failure is in its early stages and the engine is likely to fail completely within 6 to 12 months if not repaired. The lead service technician stated this is a common, known issue with this engine, which is being discontinued. Complete engine failure could occur without warning, including while driving on a highway, creating a risk of a stalling-related crash. Rather than repairing the vehicle, the dealership's own service advisor recommended I sell or trade the vehicle to a third party such as CarMax while it still retains value and purchase a different vehicle - effectively passing a vehicle with a known, unresolved engine defect on to the next owner. Coolant intrusion and short block failures in this engine family have been widely reported by other Ford Escape owners. I am requesting NHTSA review this complaint alongside others for the same engine/model-year combination to determine whether a pattern exists warranting an investigation or recall.
The contact owns a 2019 Ford Escape. The contact stated that while driving 35 MPH, the message "Stop Vehicle" was displayed. The vehicle was taken to the dealer, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The failure mileage was approximately 60,000.
My vehicle has to have a new motor. It only has 127,154 miles on it. I have sent Ford a letter to respond with in 30 days and they have not done that. Please advise the next steps.
My 2019 Ford Escape Se was smoking during start up. Dealer says it needs a whole new engine due to coolant intrusion. I have been seeing there are many issues with this.
I am reporting a potential safety defect involving the 1.5L EcoBoost engine in my 2019 Ford Escape, which has approximately 39,000 miles. Beginning in August 2026, the vehicle developed repeated check-engine lights, misfires, and severe shaking while driving. Ignition coils and a spark plug were replaced, but the problems continued. The vehicle then began displaying overheating warnings and repeatedly losing coolant. On one occasion, the coolant reservoir was found completely empty. Coolant was added, but the...
Read the full complaint
overheating continued. On September 3, 2026, the thermostat assembly and temperature sensor were replaced. On September 5, after about 15 minutes of driving, the vehicle began smoking and overheating. After it cooled, the coolant reservoir was again empty. Coolant was added, but the vehicle continued to overheat. I scheduled a Ford dealer diagnostic appointment for September 23 because I believed something was seriously wrong, but the vehicle was not diagnosed because the check-engine light was not illuminated at that time. The engine later suffered a major failure. An independent repair shop performed compression testing and reported extremely low readings of approximately 20-40 PSI on the cylinders tested, indicating severe internal engine damage. Ford has previously documented coolant intrusion on certain 2017-2019 Escape 1.5L EcoBoost engines, with symptoms including coolant loss, smoke, rough running/misfires, and possible engine damage. Ford confirmed that Customer Satisfaction Program 19B37 was completed on my vehicle in 2020, but says my VIN was not included in 21N12. Coolant intrusion has not yet been conclusively diagnosed, but the failure pattern is concerning and occurred at only about 39,000 miles. I am asking NHTSA to review this complaint for a possible safety-related defect trend.
The check engine light has repeatedly came on and been brought to the mechanics numerous times throughout the year. It was determined that the cause of issue is due to engine coolant leaking into the engine.
I am reporting a dangerous manufacturing defect regarding internal engine coolant intrusion on my 2019 Ford Escape SEL at less than 70,000 miles. Upon starting the vehicle after it sat parked overnight, a massive cloud of heavy white smoke erupted from the exhaust system and both sides of the vehicle, clearing after 1-2 minutes. The vehicle also exhibits a severe structural shudder and a mechanical groaning noise when shifting gears due to engine misfires caused by this leak. A physical inspection confirmed that...
Read the full complaint
the engine cooling system is losing fluid (which was just topped off again last night), which is leaking directly into the combustion cylinders overnight. This is a well-documented factory design flaw involving the engine block casting on Ford EcoBoost engines (referenced in Ford Customer Satisfaction Program 21N12 and multiple Technical Service Bulletins). Ford Corporate and local dealerships have refused to assist with repairs because my specific VIN was excluded from their limited voluntary campaign parameters. This defect presents an immediate, severe safety risk to myself and others, as internal coolant leaks cause sudden cylinder misfires, severe engine shuddering, engine stalling without warning in traffic, and the sudden eruption of heavy white exhaust smoke blinds drivers driving behind my car...not to mention catastrophic engine failure. Ford should be forced to issue a mandatory safety recall for all affected model years regardless of VIN exclusion lists.
The contact owns a 2019 Ford Escape. The contact stated that while depressing the accelerator, the vehicle hesitated and was idling rough. During initial start-up there was a backfire coming from the engine with white smoke coming from the exhaust pipe. The maintenance warning light was illuminated. The vehicle was taken to a certified mechanic and DTC: P0302 was retrieved. The cylinder was replaced. The contact stated that approximately 2 weeks later, the failure reoccurred. The vehicle was taken to the dealer and DTC: P0302 (Cylinder #2 misfire); was retrieved. The manufacturer was informed of the issue, and a case was opened. The failure mileage was 53,967.
The contact owns a 2019 Ford Escape. The contact stated that at cold starts, the vehicle vibrated significantly with heavy white smoke coming from the exhaust. The check engine light was intermittently illuminated, accompanied by a noticeable coolant odor. A diagnostic test by the dealer confirmed that there was coolant leaking between cylinders #1 and #2, leading to total engine failure. The vehicle remained with the dealer unrepaired. The dealer submitted a goodwill request to the manufacturer for the repair. The failure mileage was approximately 43,800.
Vehicle has coolant intrusion into cylinders verified by Ford dealer
The contact owns a 2019 Ford Escape. The contact stated that while driving 20 MPH, the vehicle was shaking and vibrating abnormally. The check engine warning light remained illuminated with the message "Engine Overheating - Pull Over Immediately" displayed. The vehicle was taken to a local dealer, where it was diagnosed with engine failure due to coolant intrusion. The manufacturer was notified of the failure. The failure mileage was 85,818.
We purchased a 2019 Ford Escape 1.5L new from the dealer. We've put only 25,000 miles on it, but are now facing a well known issue (coolant intrusion) that they failed to inform us about. This is despite our vehicle meeting literally every requirement to be included in their Customer Service Program, they told us it is not tied to our VIN and are out of luck. Our car is now worthless. If we had been notified we would have taken the necessary precautions. Again, this is a known issue, with a current Class Action lawsuit in place, that Ford failed to notify us of. We are now out tens of thousands of dollars in replacing a car we have barely driven.
The vehicle had a transmission shutter and shakes the car. It also had a hard shift at 38mph. It happens daily, was not a one time Incentent
Slow coolant leak that is a known issue with engine. This caused the water pump to go bad and engine to risk overheating. Has been looked at by 3 independent mechanics all confirmed this is a known issue causing major concerns. No warning! Just suddenly lost all coolant! No engine needs replaced!
I recently bought a 2019 Ford Escape from Superior Mazda in Bentonville, Arkansas for my daughter going off to college. Soon after purchasing the vehicle a giant puff of smoke started coming out the exhaust when starting. We took it to a Ford dealership and they said the coolant is leaking into the engine block and apparently this is a known issue with 2017-2019 ford escapes. Superior Mazda said it's not their problem. The cost to fix is $12,700. We've only had this car for 38 days. Ford has issued 2...
Read the full complaint
statements about this defect in these cars: Ford issued TSB 19-2375 for 2017-2019 Escapes with the 1.5L EcoBoost. It specifically says coolant can intrude into the cylinders and calls for short-block and head-gasket replacement when the condition is confirmed. There is also Ford Customer Satisfaction Program 21N12, titled "Short Block Replacement After Coolant Intrusion." Why is this not a recall? I have since read/heard that this is an issue all over. I spoke to a mechanic in my town and they stated they currently have a 2017 escape that they are working on with this exact problem. An investigation needs to made into Ford regarding 2017-2019 Ford Escapes. Since this is a known defect and Ford is well aware of this engine flaw in this model car they need to do the right thing and issue a recall. My daughter could have been stranded on the highway heading to college.
The transmission had to be replaced in 2024 and now the engine needs to be replaced in 2026. Ford customer service will not help with any of the repairs.
Ford Escape engine complaints by year
Escape engine problems, every yearSource: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data