2025 Kia EV6 Problems, complaints & recalls

On [redacted], I brought my Kia EV6 to an authorized Kia dealership in [[redacted]], for outstanding safety recalls and a tire that was consistently losing air pressure. My vehicle remained at the dealership for 51 days and was not returned until [redacted]. Approximately three weeks into the repair, the dealership informed me that the airbag system was too complex for its technicians to complete without additional technical assistance. Despite the extended repair period, my vehicle was returned with several...

The contact owns a 2025 KIA EV6. The contact stated that while entering the parked vehicle, he observed that the front driver-side wheel well melted from the inside out. Two dealers were notified of the failure in person. The manufacturer was notified of the failure by phone. The failure mileage was approximately 6,000.

As of Oct2026 2nd occurrence of need by Dealer Service Dept. to replace ICCU in 2025 EV6 Wind; Car delivered new in July 2025 with current mileage of 13,614

I own a 2025 Kia EV6 Wind RWD. At approximately 14,655 miles, the vehicle experienced a confirmed Integrated Charging Control Unit (ICCU) failure that resulted in loss of 12-volt charging and reduced motive power. On August 1, 2026, while reversing the vehicle, I heard a loud pop from underneath the rear seating area. Immediately afterward, the red 12-volt battery warning light illuminated and the vehicle displayed a "Check Electrical Vehicle System" message. Because I was concerned that the vehicle was no longer...

The door closed sensor fails intermittently. This causes the car to sound an alarm while driving, prevents locking of the doors, and results in automated sudden braking at low speeds, such as in heavy stop & go traffic, causing a significant crash hazard. When it engages in the emergency braking routine, it shifts out of gear, so you can't prevent a rear collision by simply accelerating, you must rapidly shift the car into gear, first.

Hi, I had to transport a few lumber pieces that did not fit into the trunk of my Kia EV6, so I had to leave the hatch open (I pulled it down as far as possible and secured it via a rope against the latch). When I started driving the car started beeping frantically, but allowed me to drive. When I crossed an intersection traffic came to a temporary halt, and when I came to a stop my Kia all of a sudden shut off and would not allow me to put it back into gear again. When traffic around me continued I was unable to...

Driving on three lane highway at 60 mph the car abruptly lost power. Was able to get off the highway. Called Kia roadside assistance. Tow truck picked up car and delivered it to Kia dealership. Service dept diagnosed and is replacing the ICCU.

While charging at a L3 station, charging was interrupted with a pop (which turned out to be ablown fuse). Two warning lights appeared on the dashboard (battery and vehicle with exclamation points) as well as message to "Check electrical vehicle system". Kia Connect told me to exit the vehicle and that it would need to be towed to the dealer. Dealer Service Office confirmed it was not safe to be in the vehicle nor to drive it. Car had only 2311 miles at the time! From the dealer invoice the KDS was inoperative at...

While driving car began to decelerate and the dash lit up with a number of ABS/Brake system failure symbols. I was on the highway traveling at abt 70 mph when the issue happened. Got car to coast off hwy onto an upward sloping exit. Stopped at a light. Turned off and back on and was able to gain minor speed got approx three blocks to a gas station. Pulled off and tried restarts. The screen stated there was an update pending, but it could not complete it because the Electronic Brake System failed. I tried...

While maneuvering my Kia EV6 into my garage, the vehicle accelerated unexpectedly and struck the garage wall. I believe the acceleration may have been unintentional or due to a malfunction. I request review of any vehicle event data

2025 KIA EV6 ICCU (part#36401 1XFD5) failed at 2,658 miles. Failure occurred when power was applied after reversing out of a parking space, switching to drive and applying power. No safety issues as vehicle remained controllable. Vehicle went into "limp" mode. Build date of vehicle is 6/20/2025. KIA Dealer has replaced failed ICCU with updated unit (part#36400 1XFD6). No indication of failure occured prior to the failure (an audible "POP" heard from the rear cabin when the unit failed).

As I was driving, there was a loud pop that came from the rear of the car. The vehicle immediately flashed a warning to "check electrical systems". I pulled over as quickly as possible but was faced with reduced acceleration. I ended up stuck in a parking lot awaiting a tow truck for over an hour with my dog and my wife in the car headed to a surgery appointment. The dealership has not confirmed anything but from research it seems to be a known issue that Kia has not addressed.

ICCU failure at 900 miles

Loud pop and Check Electrical System Message - limited ability to drive due to ICCU no longer charging 12V battery. Car no longer able to drive.

While driving Friday 4/17/26, I heard a pop and the car displayed a message to "Check electric vehicle system." The car seemed to still drive so I drive it home. That evening the car would not charge. I called Jim Shorkey Kia on 4/18/26, where I bought the car, to schedule the car to be looked at. They told me to bring it in on Monday and they will try to squeeze me in so they can diagnose the issue. Later that morning, I took that car out and made it about a block away before the car displayed a new message to...

Steering rack need to replace after drive almost 1900 miles. It has knocking nosie when turn the wheel, the car had been in the shop for three weeks.

KIA has created a safety hazard by removing the ability for the driver to select LIGHT or DARK mode for the two 7" data and infotainment screens in their 2025 and forward EV6 electric cars. Like many, I have to drive in very fast busy commuter traffic on highway I-66. (exaserbated by driving into the sun in the AM) The DARK mode screens have insufficient contrast even with the screen lighting turned all the way up. It takes the drivers eyes away from the road longer than is safe, particularly in high speed freeway commuter traffic. This is seriously exacerbated if the driver uses sunglasses because of the sun. This is obviously not an issue confined to highway I-66, or me.

I start vehicle and try to put transmission to drive its not working after I try to put vehicle to reverse transmission its not working

ICCU and fuse failure when it was being moved out from the garage. Got a "Check electrical system" notification when I turned it on following a level 2 charge the night before. It was with the dealer for exactly one month before I was able to pick it back up.

ICCU replaced after 5 months of purchasing new and less that 7,000 miles.

While driving on a sunny day on a 35mph road, my dashboard reported "Check Electrical Vehicle System". A red battery symbol appeared and my cruise control disengaged with a message "requirements not met". When I got home I read my 12 volt battery monitor that reported the battery was 11.99v and only had a 60% state of charge. Just prior to this short drive from home, my battery was 12.77v and had a 100% state of charge. I put in my ODB reader and it provided two error codes: P1A9096 and P1A961C. The first error...

ICCU failure.

ICCU failure. Car lost power while driving. I heard a "pop" sound and then the car displayed a warning light moments before losing power. Car was towed to the dealership where they diagnosed and replaced the ICCU and a fuse. This is a known problem since the 2022 model year and seems to be a very common failure that the manufacturer is unable definitively repair. Thankfully I was on a local street and not on a highspeed highway when this occurred.

The ICCU unit failed and the car first slowed and then stopped. I was able to pull off the road at an intersection. A tow truck had to jump charge the battery to allow the car to be shifted into neutral in order to pull it onto the tow truck.

The battery had an electrical system failure warning after 5900 miles and has been in the shop for over a month.