- The problem
- Motor Coach Industries (MCI) is recalling certain 2011-2012 MCI D4000, D4005, D4500 and D4505 coaches equipped with Cummins ISX 12 liter engines. The vehicles may have an incorrectly installed exhaust bellow pipe, resulting in a bend in the pipe which can cause its premature failure.
- The risk
- If the pipe fails and a diesel regeneration cycle occurs, the hot exhaust gases will increase the risk of a fire.
- The fix
- MCI will notify owners and dealers will inspect and replace any deformed or failed bellow pipes if necessary, free of charge. The recall began on June 15, 2017. Owners may contact Motor Industries at 1-800-241-2947. MCI's number for this recall is SB 397B.
Vehicle safety record
2011 Mci D4000 Problems, complaints & recalls
No owner complaints about the 2011 Mci D4000 have been filed with NHTSA. It is covered by 9 recalls, the latest in May 2017 for the exhaust system.
NHTSA data checked
DMore problems than a typical D4000 year, for its age
- Complaints
- 0
- Recalls
- 9
- Crashes
- 0
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
2011 Mci D4000 recalls 9
Recall repairs are free. Your dealer fixes them whether or not you bought the car there - check your VIN at nhtsa.gov/recalls to see if yours is done. What to do
- The problem
- Motor Coach Industries (MCI) is recalling certain model year 2011-2013 and 2015 J4500 coaches manufactured November 18, 2011, to July 10, 2015, 2011-2012 and 2014-2015 D4000 coaches manufactured manufactured September 24, 2010, to September 5, 2015, 2011-2013 and 2015-2016 D4005 coaches manufactured January 17, 2011, to November 23, 2015, 2012-2014 and 2016 D4000ISTV coaches manufactured July 18, 2012, to December 2, 2015, 2010-2016 D4500 coaches manufactured April 15, 2010, to December 18, 2015 and 2011-2016 D4505 coaches manufactured December 15, 2010, to December 4, 2015. The affected buses are equipped with certain Recaro Ergo-M Commercial Bus Driver Seats that have J-Brackets that may be missing welds which could allow the seat belt anchorage assembly to separate from the J-Bracket.
- The risk
- If the seatbelt anchorage assembly separates from the J-Bracket, the bus driver may not be properly restrained in the event of a crash increasing their risk of injury.
- The fix
- MCI will notify owners and dealers will inspect the seats and determined if welds are missing. Any J-Bracket that is missing welds will be removed and replaced, free of charge. The recall began on February 15, 2016. Owners may contact MCI at 1-800-241-2947. MCI's number for this recall is SB 431.
- The problem
- Motor Coach Industries (MCI) is recalling certain model year 2011-2012 D4000 motorcoaches manufactured November 12, 2011, to July 11, 2012, and 2014-2015 D4500 motorcoaches manufactured July 4, 2014, to April 30, 2015. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces.
- The risk
- If the engine oil comes into contact with a hot surface, it can increase the risk of a vehicle fire.
- The fix
- MCI will notify owners, and Cummins service centers will administer the repairs which include securing the ends of the 90-degree elbow and reprogramming the electronic control module (ECM) with software that can adjust the engine output under misfire conditions to limit crankcase pressures. These repairs will be performed free of charge. The recall began on June 18, 2015. Owners may contact MCI customer service at 1-800-241-2947 or Cummins Inc. at 1-800-343-7357. MCI's number for this recall is SB 423.
- The problem
- Motor Coach Industries, Inc (MCI) is recalling certain model year 2009-2011 D4000 and D4500 and 2010 D4505 motor coaches equipped with LED lights interior lights powered by either a Vansco or IO multiplex system. Due to the excessive power draw of the LED lights, heat may build up at the fuse block and connector, causing the components to melt.
- The risk
- If this occurs, the surrounding material may be damaged and will burn, increasing the risk of a fire.
- The fix
- MCI will notify owners, and dealers will replace the fuse holders, free of charge. The recall began in July 2014. Owners may contact MCI customer service at 1-847-285-2090. MCI's number for this recall is 388B. Note: This recall supersedes recall 12V-250. Motorcoaches that were remedied under the previous campaign need to be remedied under this campaign as well.
- The problem
- Motor Coach Industries, Inc. (MCI) is recalling certain model year 2011-2012 D4000 motorcoaches manufactured March 2011 through July 2012 and equipped with certain Cummins Westport model ISL G. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor.
- The risk
- The improper operation of the sensor could induce elevated exhaust temperatures or flames from the exhaust pipe, increasing the risk of a vehicle fire or burn injury to a person near the exhaust pipe.
- The fix
- MCI will notify owners, and authorized Cummins service facilities will upload a new ECM calibration, free of charge. The recallbegan on April 16, 2014. Customers may contact MCI at 1-847-285-2090 or Cummins Inc. at 1-800-343-7357. MCI's number associated with this campaign is 405.
- The problem
- Motor Coach Industries (MCI) is recalling certain model year 2000-2012 D, E, G and J series coaches manufactured January 2000 through June 2011 and equipped with Sure Power battery equalizers containing a particular epoxy sealing, aka 'potting', compound. The specific potting compound used in the subject products for insulation was found to be capable of conducting electricity after being exposed to heat.
- The risk
- Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.
- The fix
- MCI will notify owners, and Sure Power will replace the equalizers, free of charge. Owners may contact MCI at 1-847-285-2000. This campaign is MCI service bulletin 401.
- The problem
- Motor coach industries, inc (mci) is recalling certain model year 2009-2011 d4000, d4500 and 2010 d4505 motor coaches equipped with led lights interior lights and powered by either a vansco or io multiplex system. Due to excessive power draw of the led lights, heat may build up at the fuse block and connector, causing components to melt.
- The risk
- If this occurs, surrounding material may be damaged and will burn, increasing the risk of a fire.
- The fix
- Mci will notify owners, and dealers will install re-designed wiring, free of charge. The recall began on july 17, 2012. Owners may contact mci at 1-866-624-2622.
- The problem
- Motor coach industries (mci) is recalling certain model year 2003, and 2007-2012 e and j models along with model year 2007-2012 d4000, d4005, d4500, d4505, d4000istv motor coaches equipped with meritor wabco electronic stability control (esc) modules, manufactured from october 2002, through october 2011. Under certain road and driving conditions, vehicle body roll and road inclination characteristics may adversely affect the slip angle calculation of the electronic stability control (esc) system. This might cause the esc to perceive an over steering situation and therefore apply the outer wheel brake on the front axle until the vehicle is perceived to be stable.
- The risk
- If the driver is slow to react during this esc intervention, the vehicle may deviate from the intended line of travel, increasing the risk of a crash.
- The fix
- Mci will notify owners and replace the control module free of charge. The safety recall began on january 4, 2012. Owners may contact mci customer service at 1-800-241-2947.
- The problem
- Mci is recalling certain model year 2010-2011 d4500, d4505, and d4000 motor coaches. The affected pulley covers may lack certain welds required to keep the covers attached to the coach structure.
- The risk
- The cover will eventually fail as a result of fatigue, and the cover may become detached from the coach and fall and strike a person or object, resulting in personal injury or property damage.
- The fix
- Mci will inspect and replace as necessary the idler pulley covers free of charge. The safety recall began on february 10, 2011. Owners may contact mci customer service at 1-800-241-2947.
What owners say
Be the first D4000 owner to share.
Problems or none - your experience is exactly what the next buyer is looking for. Write it now
No complaints about the 2011 Mci D4000 yet
No owner has filed a complaint about this vehicle with NHTSA. If yours has a problem, share it here and report it to NHTSA.
Mci D4000: every year compared
All D4000 yearsQuestions about the 2011 Mci D4000
Does the 2011 Mci D4000 have any recalls?
Yes - NHTSA lists 9 recalls for the 2011 Mci D4000: exhaust system (May 2017); seats (January 2016); engine (May 2015); fuses and circuit breakers (June 2014) and more. Recall repairs are free at any authorized dealer. Enter your VIN at nhtsa.gov/recalls to see whether yours has been fixed.
How many complaints has the 2011 Mci D4000 had?
None have been filed with NHTSA so far.
Is the 2011 Mci D4000 a reliable vehicle?
Its Safety Index is 26 out of 100 (grade D: more problems than a typical Mci D4000 year, for its age). The index weighs complaints, crashes, fires, injuries, deaths and recalls against how long the vehicle has been on the road, compared with the same model's other years. It is not a measure of every repair - read the complaints and owner experiences, and have any used vehicle inspected before you buy.
What should I do if my 2011 Mci D4000 has a problem?
If it is a safety problem, stop driving it if it is unsafe and contact your dealer. Report it to NHTSA at nhtsa.gov/report-a-safety-problem - enough reports start investigations and recalls - and share your experience here so other owners know what to look for.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data