- The problem
- On certain transit buses, the fuel lift pump could fail in a manner which results in engine fuel starvation, which could result in a stall condition. Potential lift pump failure modes include: brush wear out, bushing failure, rotor tab insert failure, or any other failure mode that would cause the fuel pumping element to stop spinning.
- The risk
- If the fuel lift pump pumping element stops spinning and the fuel pumping vanes stop in a location which blocks fuel flow through the lift pump, the engine will be starved of fuel. Fuel starvation could cause low engine power, engine misfire, or engine stall. Prior to the engine stalling, the operator could experience low engine power, engine misfire, and/or dash-mounted fault lamp illumination.
- The fix
- Cummins is conducting the owner notification and remedy for this campaign. Owners may contact cummins at 1-800-343-7357 or orion bus at 905-403-7807.
Vehicle safety record
2001 Orion II Problems, complaints & recalls
No owner complaints about the 2001 Orion II have been filed with NHTSA. It is covered by 3 recalls, the latest in March 2005 for the fuel system, diesel.
NHTSA data checked
FFar more problems than a typical II year, for its age
- Complaints
- 0
- Recalls
- 3
- Crashes
- 0
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
2001 Orion II recalls 3
Recall repairs are free. Your dealer fixes them whether or not you bought the car there - check your VIN at nhtsa.gov/recalls to see if yours is done. What to do
- The problem
- Certain orion buses equipped with sure-lok wheelchair tie-down securement assemblies. The sprocket teeth of the retractor assembly may be out of alignment causing the load pawl not to fully seat in the sprocket teeth.
- The risk
- In the event of a vehicle crash, the wheelchair may not be adequately secured possibly resulting in injuries.
- The fix
- Sure-lok will conduct the owner notification and remedy for this campaign. Dealers will inspect and replace the wheelchair securement retractors as necessary. Owners should contact sure-lok at 1-866-787-3565 or Orion at 905-403-1111.
- The problem
- Certain transit buses fail to comply with the requirements of federal motor vehicle safety standard no. 217, "Bus emergency exits and window retention and release." The handle pull force exceeds the 89n force to release the emergency window. Additional force is required to release the window.
- The risk
- In the event of a crash, an occupant may have difficulty opening the emergency exit window, increasing the risk of personal injury or death.
- The fix
- Dealers will repair these windows. Owner notification began june 1, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact orion at 1-800-492-2116.
What owners say
Be the first II owner to share.
Problems or none - your experience is exactly what the next buyer is looking for. Write it now
No complaints about the 2001 Orion II yet
No owner has filed a complaint about this vehicle with NHTSA. If yours has a problem, share it here and report it to NHTSA.
Orion II: every year compared
All II yearsQuestions about the 2001 Orion II
Does the 2001 Orion II have any recalls?
Yes - NHTSA lists 3 recalls for the 2001 Orion II: fuel system, diesel (March 2005); equipment adaptive / mobility (October 2004); glass, side / rear (March 2003). Recall repairs are free at any authorized dealer. Enter your VIN at nhtsa.gov/recalls to see whether yours has been fixed.
How many complaints has the 2001 Orion II had?
None have been filed with NHTSA so far.
Is the 2001 Orion II a reliable vehicle?
Its Safety Index is 16 out of 100 (grade F: far more problems than a typical Orion II year, for its age). The index weighs complaints, crashes, fires, injuries, deaths and recalls against how long the vehicle has been on the road, compared with the same model's other years. It is not a measure of every repair - read the complaints and owner experiences, and have any used vehicle inspected before you buy.
What should I do if my 2001 Orion II has a problem?
If it is a safety problem, stop driving it if it is unsafe and contact your dealer. Report it to NHTSA at nhtsa.gov/report-a-safety-problem - enough reports start investigations and recalls - and share your experience here so other owners know what to look for.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data