PACCAR Incorporated (PACCAR) is recalling certain 2021-2025 Peterbilt and Kenworth vehicles, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Please see the recall report for a complete list of models. Electrical noise and low signal to...
2004-2025 · 22 model years
Peterbilt 389 Problems by year
Owners have filed 20 complaints about the Peterbilt 389 across 22 model years, and it has 48 recalls. The 2024 has the most complaints once its age is allowed for (2). The most reported problem area is the wheels & tires, followed by the electrical system.
- Complaints
- 20
- Recalls
- 48
- Crashes
- 1
- Fires
- 0
- Injuries
- 0
- Deaths
- 1
389 complaints by model year
Highlighted: the year with the most complaints for its age. Older vehicles have had more time to collect complaints - the Safety Index grade allows for that.
Most common 389 problems
Peterbilt 389 recalls 48
PACCAR Incorporated (PACCAR) is recalling certain 2024 Peterbilt 367, 389, 548, Kenworth T480, T800, 2024-2025 Peterbilt 520, 567 and Kenworth T880 vehicles with PACCAR 20k steer axles. The steering arm and/or tie rod bracket fasteners may fail, resulting in...
PACCAR Incorporated (PACCAR) is recalling certain 2021-2024 Peterbilt 365, 367, 389, 535, 536, 537, 548, 567, 579, and 2021-2025 Kenworth T180, T280, T380, T480, T680, T880 and W990 trucks. The right-hand gear shifter stalk connectors may have been...
PACCAR Incorporated (PACCAR) is recalling certain 2024-2025 Kenworth T280, T380, T480, T680, T880, L770, W990, and 2024-2025 Peterbilt 389, 520, 535, 536, 537, 548, 567, 579, 589 trucks. The steering gear assemblies may have been assembled incorrectly with...
PACCAR Incorporated (PACCAR) is recalling certain 2024 Peterbilt 367, 389, 520, 567, and Kenworth T800, T880, W900, and W990 trucks. The bearing journals may not be fully seated in the steering knuckle assemblies, preventing the proper installation of the...
PACCAR Incorporated (PACCAR) is recalling certain 2023 Peterbilt 348, 367, 389, 548, 567, and Kenworth T370, T480, T800, T800B, T880, W900B, and W990 vehicles. The tie rod clamps may have been improperly heat-treated, causing them to fail and allowing the...
PACCAR Incorporated (PACCAR) is recalling certain 2022-2023 Kenworth T680, T880, W990, and Peterbilt 365, 367, 389, 567, and 579 vehicles. The digital display may freeze and not display critical safety information. As such, these vehicles fail to comply...
PACCAR Incorporated (PACCAR) is recalling certain 2023 Peterbilt 220, 389, 520, 536, 537, 348, 367, 567, 548, 579, and 2023 Kenworth T680, K270, T440, T880, W990, K370, T280, T380, T480, T800, and W900 vehicles. The engine control module (ECM) may experience...
PACCAR Incorporated (PACCAR) is recalling certain 2022-2023 Kenworth T170, T270, T280, T370, T380, T440, T470, T480, T680, T800, T880, W900, W990, C500, and 2022-2023 Peterbilt 325, 330, 337, 348, 365, 367, 389, 520, 536, 537, 548, 567, and 579 vehicles. The...
PACCAR Incorporated (PACCAR) is recalling certain 2018-2020 Kenworth T270, T370, T440, T470, T660, T680, T880, T800, W900, W990; and 2018-2020 Peterbilt 330, 337, 348, 365, 367, 389, 520, 567, and 579 vehicles. The Dana D-Series axle steer arm fasteners that...
PACCAR Incorporated (PACCAR) is recalling certain 2019-2022 Kenworth T880, W990, Peterbilt 567, 579, 389, and 2022 Peterbilt 536, 537 wrecker and auto hauler vehicles. The work brake (winch brake) may unintentionally disengage the service brakes during...
PACCAR, Inc. (PACCAR) is recalling certain 2021-2022 Peterbilt 367, 389, 567, and 579 vehicles. The cross member mounted Hill Start Assist valve assembly may have insufficient clearance to the rear axle, causing damage to the rear brake hose and loss of the...
Latest 389 complaints
ABS tone rings are prone to premature corrosion and rust jacking causing the ABS system to fail along with the traction control. This corrosion causes the rings to warp prematurely. Not only is this an expensive and time-consuming fix, but it is also an extreme safety hazard. This condition has been noted on several trucks in the Fleet along with other local companies in the area.
OEM pressed-on cast iron/stamped rings fail prematurely due to regional rust jacking, disabling the vehicle's ABS. Explicitly mention that the current design creates a systemic safety risk in cold-weather states and that a recall mandating corrosion-resistant materials (like stainless steel) is required. This cost thousands of dollars to repair and only lasts 2-3 years. Almost everyone I know with these trucks have experienced this problem. Peterbilt is highly aware of the situation, but they refuse rectify it because it only affects cold weather states.
Odometer Fraud. The contact purchased a 2021 Peterbilt 389. The contact stated that while attempting to restart the vehicle after running out of diesel, it was discovered that there was a mileage discrepancy. The contact stated that while restarting the vehicle, the fuel filters needed to be refilled with diesel. The contact stated that whenever a trailer was serviced, the date and mileage were written on the filters. The contact stated that the mileage was significantly higher as written on the filter than what...
Read the full complaint
was written on the sales contract and shown on the odometer. The vehicle was a dealer sale. At the time of purchase, the mileage was 411,000, and while refilling the fuel filters, the mileage was 671,000.
The contact owns a 2022 Peterbilt 389 equipped with Goodyear Tires, Tire Line: Marathon LHS, Tire Size: 11R22.5, DOT Number: 1MY3TTYBW0324. The tires had been replaced prior to the failure. While driving, the driver's side front tires had a blowout. The local dealer was contacted, where it was diagnosed that the tread had separated. The vehicle was repaired. The manufacturer was contacted and declined the claim. The manufacturer stated that the tires were either underinflated or overinflated. The tires were sent...
Read the full complaint
for X-ray. The contact stated that the vehicle carried propane fuel, and the air pressure was set at 110. The tire failure mileage was 37,000. The vehicle failure mileage was approximately 439 087.
The contact owns a 2024 Peterbilt 389. The contact stated while driving at various speeds, the vehicle experienced an inaccurate reading of the adaptive cruise control, causing the cruise control to disengage. Additionally, the contact stated after driving for an hour, the ABS, traction control, and electronic stability control warning lights were illuminated. The contact received notification of NHTSA Campaign Number: 24V915000 (Service Brakes, Hydraulic, Electrical System), which the contact related to the...
Read the full complaint
failure. The vehicle was taken to the dealer for the recall repair. The dealer informed the contact that the recall repair had been performed. The contact stated upon test-driving the vehicle, the failure persisted. The dealer was informed that the recall repair had not corrected the failure. The vehicle was not yet repaired; however, the dealer charged a labor fee. The contact declined to pay the fee and the vehicle remained with the dealer. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the failure. The failure mileage was approximately 180,000.
Digital dash/display and the whole cluster freezes while driving. The recall 22v-779 update was done on the truck 4 weeks ago and it still have the same issue.
Questions about the Peterbilt 389
Which Peterbilt 389 years have the most problems?
Which Peterbilt 389 years have the fewest complaints?
What are the most common Peterbilt 389 problems?
Across every model year, owners report problems with the wheels & tires (7), electrical system (5), body, doors & structure (3) most often.
How many recalls does the Peterbilt 389 have?
NHTSA lists 48 recalls across all Peterbilt 389 model years. Each year's page lists the recalls for that year; check your own vehicle by VIN at nhtsa.gov/recalls to see whether the repair has been done.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked daily. Complaints are owners' own reports and are not verified. How we use the data