2015 Subaru Outback Engine problems

NHTSA issued a notice for a recall on the 2015 Subaru Outback for an exhaust pipe bellows crack which causes exhaust noise and odor which affects emission and engine performance. I had noticed our Subaru's exhaust smoke coming in through the air vents while idling and also a general loss of power for the vehicle. When I dug into the causes, I came across this recall and did the VIN look up on the NHTSA website and also the Subaru website for active recalls. The Subaru website states that the recall was...

The contact owns a 2015 Subaru Outback. The contact stated that while driving at an undisclosed speed, the exhaust manifold detached from the vehicle. Due to the failure, the vehicle was towed to the residence. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The dealer advised the contact that a recall repair was previously performed on the vehicle, which was related to an exhaust pipe cracking, and that additional repairs would be at the owner's expense. The manufacturer was notified of the failure. The approximate failure mileage was 244,000.

The contact owns a 2015 Subaru Outback. The contact stated that while driving at an undisclosed speed, and while at a stop light, there was an abnormal exhaust fumes odor inside the vehicle. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed with a cracked exhaust pipe. The vehicle was not repaired. The manufacturer was contacted and confirmed that the vehicle was previously repaired under Service Program Bulletin: WUJ-95 but no additional assistance was provided. The failure mileage was approximately 110,000.

The contact owns a 2015 Subaru Outback. The contact stated that while starting the vehicle, there was an abnormal exhaust odor entering the cabin of the vehicle through the vents. No warning lights were illuminated. The contact stated that the vehicle was consuming an excessive amount of fuel. Before the contact purchased the vehicle, the contact became aware that the vehicle had been repaired under recall for the catalytic converter. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the issue. The failure mileage was approximately 135,000.

I was within the town limits so I was driving slowly. When I approached the first stop light in town I saw that it was red. There were of three or four vehicles stopped at that light. At that point I was probably only going 5mph. I took my foot off of the gas pedal and put my foot on the brake to make a slow stop. Instead, the car accelerated rather quickly. I continued to brake but the car seemed to speed up. I was able to avoid hitting the truck in front of me by going around it. No vehicles were coming...

The cam carrier has a leak that is causing oil to slowly leak out of the car. The current issue is causing me to have to regularly add oil to the car. My safety is at risk as the car engine could fail while driving which would be me and others at risk. My understanding is that the leaking oil could also cause other parts to fail such as the O2 sensor. The recommended repair from the local Subaru dealer is to reseal the cam carrier at an estimated cost of $4,744. I attempted to contact Subaru after reading that many...

The car had a recall on it for the catalytic converter and front pipe and bellows being cracked. It was replaced under a service bulletin put out by Subaru at 104,000 miles in 2020. I just went to get the vehicle inspected in 5/2023 and the exact same part is failing once again. It will not pass inspection. This causes exhaust to leak back into the car (including carbon monoxide) given the converter/bellows are parts that come off the engine right under the driver/passenger's front seat. I have called corporate...

#1. I replaced the battery in June of 2022 after all the dash warning lights came on. My eyesight safety feature was rendered in operative. After the battery was replaced, all the warning lights eventually went out. In July of 2023 the same scenario happened again. I returned to Advance Auto retailer and the store manager checked the battery. She replaced the battery with a new one of greater cold cranking amps. she was most knowledgeable and extraordinarily gracious. I asked her to check the alternator for...

The contact owns a 2015 Subaru Outback. The contact stated that while driving 67 MPH with the cruise control activated, the vehicle suddenly decelerated to approximately 25-30 MPH while depressing the brake pedal. The contact stated that the vehicle stalled. After pulling over to the side of the roadway, the contact was able to restart the vehicle and drove to the residence. The vehicle was taken to the dealer however, the cause of the failure could not be determined. The contact's wife stated that the failure had...

Oil consumption issues. The oil is burning more then it should. Oil light would come after 2 to 3 more after an oil change. The dealership has been notified and is working on ordering new parts for the engine. Replacing the small block of the engine. Had less the 100k miles when this problem accured. Electrical issues. The battery is being drained after the car is turned off. Car would not start in the morning and need to be jumped. Additionally, battery eventually dies and needs to be replaced. Dealership has been notified.

Intermittant engine acceleration or engine surge while braking at very low speeds.

Entering a residential garage to park; experienced sudden acceleration while braking. Vehicle went through drywall/wall about 2 feet. Placed vehicle in park to stop vehicle. No airbags went off. Driving vehicle to repair shop later; experienced same rapid unexpected acceleration with different driver. No issue with floor mats. OEM mats. Service center cannot provide any insight or reproduction of event.

The contact owned a 2015 Subaru Outback. The contact stated that while driving at 60 MPH, he was alerted by another driver that the vehicle was smoking and flames were coming from under the vehicle. The contact stated that warning lights flashed off and on. The contact stated that he pulled over, exited the vehicle, and saw flames coming from underneath the vehicle before it was engulfed in flames and exploded. The contact stated that he sustained minor burns on his hands from the steering wheel however, medical...

On three separate occasions, most recently on 01/06/22 , my Subaru Outback began to accelerate without touching the gas pedal. My wife and myself were both fortunate to have a foot covering the brake pedal when this occurred . We fortunately avoided the potential collision hazard. The UNEXPECTED ACCELERATION is alarming and continues to occur !

Engine consistently burns oil. Adding pints between factory recommended oil change interval when low oil light comes on. On average, one pint is burned every 1500 miles.

Repeated dead batteries. Replaced OEM battery in year 2, new battery also comes up dead regularly. There is clearly a parasitic battery drain happening. Burning oil, this car burns more oil than any car I have ever owned. Subaru claims it is within specification, but their specification is 1 quart between changes, this is a ridiculous claim in 2021. Heat shield and exhaust noise. Always a new noise or exhaust leak. Lights are not adequate for country driving, it is dangerous.

While driving at highway speed and traveling over about 6 hours, the car simply shut off. We were traveling on the highway in the passing lane. Without warning the car began to slow down rapidly, no dash lights on, but the engine was off. We managed to cross two lanes of traffic without power assist and once on the shoulder and slowing down, the engine lights all came on. Once fully stopped, we turned the car off, waited a few seconds and restarted. We were then able to complete our trip without difficulty. This...

On 8/25/21, during servicing, I was informed by the Subaru dealer who has always serviced my car that the driver's side head gasket was starting to go bad. The car had 54,108 miles on it and was 6 years and 5 months old. It had always been driven under normal conditions, on public roads, and 100% of the servicing had been performed by the Subaru dealer who sold me the car, which I bought new. In addition, I had never used the car for towing. Under the circumstances, it seemed indefensible that the head gasket should be going bad. It's a very expensive repair. The engine in question is the 3.6-liter 6-cylinder.

Car stalled, could not take out of gear; could not restart, could not set emergency brake, couldn't turn key to restart. Finally a light came on that said hatch was open. Could not operate hatch from inside car. Jumped out hatch was closed. Opened and reclosed. Car started rolling. Ran to jump in and apply manual brake. I'm 85 years old. Very dangerous situation. Consumer stated AAA batteries failed several times. Vehicle was taken to a dealer for electrical failure.

My battery has had to be replaced twice because it drains even though the car is used regularly and nothing is left on. I have had to be jumped six or seven times since I purchased the car and towed once to the dealership.

Within 80k miles the car has started showing high engine oil consumption. Engine oil is to be changed every 6000 miles but at 4000 miles low engine oil light will show up and checking on oil level, it shows at the low level of dipdtick.Upon diagnosis, it was figured that it has stage 2 head gasket replacement by subaru dealership

The muffler makes a rattling or growling noise when idling or coasting. The noise disappears when accelerating.

I have this issue with my muffler. Tsb 09-66-16 rear muffler shell rigidity enhancement this bulletin announces a change in the production procedure for the rear muffler assembly. Spot-weld locations securing the outer shell portion have been changed to improve overall rigidity. A gap may develop at the spot welded seam as a result of repeated thermal shock (heating / cooling) which occurs during normal use. The gap does not create an exhaust leak. In some cases, a rattling sound from the muffler may develop.

Vehicle will not start/crank. Battery is brand new, all electronics function and light up, yet when ignition is turned the engine doesn't turn over. Vehicle is in the shop for the third time in 3 weeks. A new wiring harness was installed but failed to resolve the issue. Vehicle has been showing codes for the cam & crank sensors, including code p0340, yet all sensors have tested as operational. I'll post an update as soon as I hear from dealer.

Service technician reported a noise and leak from catalytic system. Hint of exhaust present in driver compartment at low speed and stops.