- The problem
- Daimler trucks is recalling 243,435 my 1995-2008 thomas built school buses manufactured between january 1994, and march 10, 2008. (Additional buses have been added to this recall campaign. Please see supplemental report no. 4) The emergency exit door handle begins corroding around the securing roll pin and square drive mechanism causing the protective finish to chip and flake. Continued corrosion and pitting weakens the handle. Handles weakened by corrosion may break while trying to open the door from the exterior.
- The risk
- In the event of an emergency, a person on the outside of the bus may break the door handle trying to open the emergency exit potentially delaying evacuation and increasing the risk of personal injury to the vehicle's occupants.
- The fix
- Daimler trucks will notify owners and will replace the handles with a more robust handle free of charge. Repairs will be performed by thomas built buses dealerships. The recall began on august 18, 2008, and notification for the revised population is expected to begin on or about april 29, 2009. Owners may contact thomas built at 336-889-4871.
Vehicle safety record
1998 Thomas ER Transit Problems, complaints & recalls
No owner complaints about the 1998 Thomas ER Transit have been filed with NHTSA. It is covered by 6 recalls, the latest in February 2008 for the hinge and attachments.
NHTSA data checked
CAbout as many problems as a typical ER Transit year, for its age
- Complaints
- 0
- Recalls
- 6
- Crashes
- 0
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
1998 Thomas ER Transit recalls 6
Recall repairs are free. Your dealer fixes them whether or not you bought the car there - check your VIN at nhtsa.gov/recalls to see if yours is done. What to do
- The problem
- Vehicle description: certain school buses and transit buses equipped with national seating's series 93b-sb driver seat. A bracket attaching the gas spring shock to the height adjuster of the seat can deform and break. This bracket is located at the top of the height adjuster.
- The risk
- If the bracket is not replaced after deforming, and is allowed to break, its breaking will result in a sudden drop of the driver's seat, increasing the risk of loss of control of the vehicle and a crash.
- The fix
- Dealers will replace the seat base and add reinforcement to the seat assembly
- The problem
- Vehicle description: school bus chassis and emergency vehicles built with bendix air abs with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted abs activation at low speeds caused by 1) chafed abs wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
- The risk
- This condition could cause the abs ecu to exhaust the air at the air brake modulators for one or more of the wheels. This could result in extended braking distances and a possible crash.
- The fix
- DEALERS WILL REPLACE THE ABS ECU.
- The problem
- Vehicle description: heavy duty trucks and school bus chassis built with bendix air abs with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted abs activation at low speeds caused by 1) chafed abs wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
- The risk
- This condition could cause the abs ecu to exhaust the air at the air brake modulators for one or more of the wheels. This could result in extended braking distances and a possible crash.
- The fix
- DEALERS WILL REPLACE THE ABS ECU.
- The problem
- Certain school buses with weldon technologies' 5050-1400 surface mount marker lights have an option to replace each of the twelve clearance/marker/identification lights with four-candlepower lights, twice the candlepower normally used. The higher current demand created by these lights can cause excessive heat through the headlight switch connection if a relay is not installed between the combination tail/marker light circuit and the headlight switch.
- The risk
- This can result in deformation of the plastic connectors that connect the headlight switch to its wiring harness.
- The fix
- Dealers will install a relay to reduce the current draw through the headlight switch. Owner notification began september 8, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 1-336-881-7219.
- The problem
- Vehicle description: school and transit buses equipped with national seating series 93b-sb driver seat. A bracket attaching to the height adjusting shock absorber on the driver's seat can deform and break.
- The risk
- This condition can result in a sudden drop of the driver's seat, increasing the risk of loss of control of the vehicle and a crash.
- The fix
- Dealers will add a reinforcement to the bracket, or if the bracket is deformed and/or broken, the entire seat base will be replaced.
What owners say
Be the first ER Transit owner to share.
Problems or none - your experience is exactly what the next buyer is looking for. Write it now
No complaints about the 1998 Thomas ER Transit yet
No owner has filed a complaint about this vehicle with NHTSA. If yours has a problem, share it here and report it to NHTSA.
Thomas ER Transit: every year compared
All ER Transit years1998 Thomas ER Transit vs rivals
| Vehicle | Complaints | Recalls | Grade | |
|---|---|---|---|---|
| 1998 Thomas ER Transit | 0 | 6 | C | |
| 1998 Thomas School Bus | 5 | 0 | A | Compare |
| 1998 Thomas MVP EF | 3 | 8 | D | Compare |
| 1998 Thomas Thomas | 1 | 0 | A | Compare |
| 1998 Thomas Bus | 1 | 0 | A | Compare |
| 1998 Thomas Saf-T-Liner | 1 | 0 | A | Compare |
More sales usually means more complaints, so compare similar vehicles of the same year. The grade compares each vehicle with its own model's other years.
Questions about the 1998 Thomas ER Transit
Does the 1998 Thomas ER Transit have any recalls?
Yes - NHTSA lists 6 recalls for the 1998 Thomas ER Transit: hinge and attachments (February 2008); seats (November 2000); antilock (August 2000); antilock (August 2000) and more. Recall repairs are free at any authorized dealer. Enter your VIN at nhtsa.gov/recalls to see whether yours has been fixed.
How many complaints has the 1998 Thomas ER Transit had?
None have been filed with NHTSA so far.
Is the 1998 Thomas ER Transit a reliable vehicle?
Its Safety Index is 43 out of 100 (grade C: about as many problems as a typical Thomas ER Transit year, for its age). The index weighs complaints, crashes, fires, injuries, deaths and recalls against how long the vehicle has been on the road, compared with the same model's other years. It is not a measure of every repair - read the complaints and owner experiences, and have any used vehicle inspected before you buy.
What should I do if my 1998 Thomas ER Transit has a problem?
If it is a safety problem, stop driving it if it is unsafe and contact your dealer. Report it to NHTSA at nhtsa.gov/report-a-safety-problem - enough reports start investigations and recalls - and share your experience here so other owners know what to look for.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data