- The problem
- Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. Therefore, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 210, "Seat Belt Assembly Anchorages."
- The risk
- In the event of a crash, an insufficient seat belt weld may prevent the seat belt from properly restraining the occupant. This increases the risk of injury to the seat occupant.
- The fix
- Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
Vehicle safety record
2004 Volvo VN Problems, complaints & recalls
Owners have filed 1 complaint about the 2004 Volvo VN with NHTSA, most often about the electrical system (1). It is covered by 4 recalls, the latest in October 2012 for the seat belts. For comparison, the 2003 has 3 and the 2005 has 2.
NHTSA data checked
CAbout as many problems as a typical VN year, for its age
#455 most complained-about 2004 vehicle
- Complaints
- 1
- Recalls
- 4
- Crashes
- 0
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
Most common 2004 Volvo VN problems
Share of all 1 complaints. One complaint can name more than one area. Tap an area for its complaints and recalls.
2004 Volvo VN recalls 4
Recall repairs are free. Your dealer fixes them whether or not you bought the car there - check your VIN at nhtsa.gov/recalls to see if yours is done. What to do
- The problem
- On certain trucks equipped with valeo wiper systems, the wiper motor may be susceptive to salt intrusion that could possibly lead to a condition where the connector overheats to a point where the connector could ignite.
- The risk
- If this occurs, excessive heat and smoke could result in an under hood fire.
- The fix
- Dealers will inspect and replace the connector plate on the windshield wiper motor. Phase 2 of the recall began on november 1, 2004. Owners should contact volvo trucks at 1-800-528-6586.
- The problem
- On certain trucks, the bolts that retain the universal joint to the yoke at the transmission may not be tightened correctly.
- The risk
- This can result in the drive shaft coming loose from the transmission, increasing the risk of a crash.
- The fix
- Dealers will remove and install removing new bolts, inspect for cross-threaded bolts, and replace the yoke if necessary. The recall began october 1, 2004. Owners should contact volvo trucks at 1-800-528-6586.
- The problem
- On certain trucks, a malfunction in the solenoid valve may allow air to be released to fifth wheel latch when the park brake is engaged.
- The risk
- This condition could cause the fifth wheel latch to release inadvertently when the park brake is engaged, creating the potential for loss of the trailer. A crash could occur without prior warning.
- The fix
- Dealers will add an additional solenoid valve in series with the existing pneumatic circuit for the fifth wheel air release. The recall began on august 9, 2004. Owners should contact volvo at 1-800-528-6586.
What owners say
Be the first VN owner to share.
Problems or none - your experience is exactly what the next buyer is looking for. Write it now
1 complaints about the 2004 Volvo VN
Newest first, as filed with NHTSA by owners.
Dt:history of electrical problems since purchase of semi-truck. When driving at any speeds or even shifting into gear the truck stops without warning. When this occurs the engine dies and loses all electrical power. Several times, the engine stalled for a second and then quit. Consumer had to replace blowen out 30 amp and 15 amp fuses. There is a load of 75-80,000 pounds, and vehicle stops in the middle of the highway in traffic. Has been to dealer numerous times, said warranty expired aafter one year. Dealer tried to fix some electrical wiring harness but of no avail. Truck drained batteries, and is currently on a battery charger. *Ak
Volvo VN: every year compared
All VN years2004 Volvo VN vs rivals
| Vehicle | Complaints | Recalls | Grade | |
|---|---|---|---|---|
| 2004 Volvo VN | 1 | 4 | C | |
| 2004 Volvo S60 | 198 | 6 | F | Compare |
| 2004 Volvo V70 | 89 | 6 | F | Compare |
| 2004 Volvo S40 | 50 | 6 | D | Compare |
| 2004 Volvo S80 | 50 | 5 | D | Compare |
| 2004 Volvo C70 | 16 | 0 | C | Compare |
| 2004 Volvo VNL | 5 | 6 | C | Compare |
| 2004 Volvo 780 | 5 | 0 | C | Compare |
| 2004 Volvo V40 | 4 | 3 | C | Compare |
More sales usually means more complaints, so compare similar vehicles of the same year. The grade compares each vehicle with its own model's other years.
Questions about the 2004 Volvo VN
Does the 2004 Volvo VN have any recalls?
Yes - NHTSA lists 4 recalls for the 2004 Volvo VN: seat belts (October 2012); motor (September 2004); driveshaft (August 2004); fifth wheel assembly (July 2004). Recall repairs are free at any authorized dealer. Enter your VIN at nhtsa.gov/recalls to see whether yours has been fixed.
What are the most common problems with the 2004 Volvo VN?
By the complaints owners filed with NHTSA, the most common problem areas are the electrical system (1).
How many complaints has the 2004 Volvo VN had?
1 complaints have been filed with NHTSA, the first on August 9, 2005 and the latest on August 9, 2005. Of these, 0 describe a crash and 0 a fire, and together they report 0 injuries and 0 deaths.
Is the 2004 Volvo VN a reliable vehicle?
Its Safety Index is 47 out of 100 (grade C: about as many problems as a typical Volvo VN year, for its age). The index weighs complaints, crashes, fires, injuries, deaths and recalls against how long the vehicle has been on the road, compared with the same model's other years. It is not a measure of every repair - read the complaints and owner experiences, and have any used vehicle inspected before you buy.
Which Volvo VN years have the most complaints?
2003 (3), 2007 (3), 2005 (2). See every Volvo VN year compared.
What should I do if my 2004 Volvo VN has a problem?
If it is a safety problem, stop driving it if it is unsafe and contact your dealer. Report it to NHTSA at nhtsa.gov/report-a-safety-problem - enough reports start investigations and recalls - and share your experience here so other owners know what to look for.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data