- The problem
- Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. Therefore, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 210, "Seat Belt Assembly Anchorages."
- The risk
- In the event of a crash, an insufficient seat belt weld may prevent the seat belt from properly restraining the occupant. This increases the risk of injury to the seat occupant.
- The fix
- Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
Vehicle safety record
2002 Volvo VN Problems, complaints & recalls
No owner complaints about the 2002 Volvo VN have been filed with NHTSA. It is covered by 5 recalls, the latest in October 2012 for the seat belts.
NHTSA data checked
CAbout as many problems as a typical VN year, for its age
- Complaints
- 0
- Recalls
- 5
- Crashes
- 0
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
2002 Volvo VN recalls 5
Recall repairs are free. Your dealer fixes them whether or not you bought the car there - check your VIN at nhtsa.gov/recalls to see if yours is done. What to do
- The problem
- On certain trucks equipped with valeo wiper systems, the wiper motor may be susceptive to salt intrusion that could possibly lead to a condition where the connector overheats to a point where the connector could ignite.
- The risk
- If this occurs, excessive heat and smoke could result in an under hood fire.
- The fix
- Dealers will inspect and replace the connector plate on the windshield wiper motor. Phase 2 of the recall began on november 1, 2004. Owners should contact volvo trucks at 1-800-528-6586.
- The problem
- On certain trucks, a malfunction in the solenoid valve may allow air to be released to fifth wheel latch when the park brake is engaged.
- The risk
- This condition could cause the fifth wheel latch to release inadvertently when the park brake is engaged, creating the potential for loss of the trailer. A crash could occur without prior warning.
- The fix
- Dealers will add an additional solenoid valve in series with the existing pneumatic circuit for the fifth wheel air release. The recall began on august 9, 2004. Owners should contact volvo at 1-800-528-6586.
- The problem
- On certain heavy-duty class 8 trucks, the assembled engine pre-heater jumper wiring harness was incorrectly assembled.
- The risk
- The engine pre-heater could overheat resulting in damage to the pre-heater and other engine heat sensitive components near the pre-heater and the ability to re-start the engine could be compromised, increasing the risk of a crash.
- The fix
- Dealers will repair the affected circuits in the jumper wiring harness connector. Owner notification is expected to begin during march 2004. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo trucks at 1-800-528-6586.
- The problem
- On certain heavy duty class 8 trucks with volvo b-ride rear suspension, the forward and/or rear drive axle upper axle seat could break allowing the affected axle to shift out of alignment.
- The risk
- This condition could result in loss of axle stability, increasing the risk of a crash.
- The fix
- Dealers will replace the upper axle seat on both rear drive axles. Owner notification began january 14, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo trucks at 1-800-528-6586.
What owners say
Be the first VN owner to share.
Problems or none - your experience is exactly what the next buyer is looking for. Write it now
No complaints about the 2002 Volvo VN yet
No owner has filed a complaint about this vehicle with NHTSA. If yours has a problem, share it here and report it to NHTSA.
Volvo VN: every year compared
All VN years2002 Volvo VN vs rivals
| Vehicle | Complaints | Recalls | Grade | |
|---|---|---|---|---|
| 2002 Volvo VN | 0 | 5 | C | |
| 2002 Volvo S60 | 189 | 9 | F | Compare |
| 2002 Volvo V70 | 106 | 6 | F | Compare |
| 2002 Volvo S80 | 45 | 5 | D | Compare |
| 2002 Volvo S40 | 30 | 1 | C | Compare |
| 2002 Volvo V70XC | 30 | 1 | C | Compare |
| 2002 Volvo C70 | 9 | 1 | B | Compare |
| 2002 Volvo V40 | 7 | 1 | B | Compare |
| 2002 Volvo S70 | 3 | 0 | A | Compare |
More sales usually means more complaints, so compare similar vehicles of the same year. The grade compares each vehicle with its own model's other years.
Questions about the 2002 Volvo VN
Does the 2002 Volvo VN have any recalls?
Yes - NHTSA lists 5 recalls for the 2002 Volvo VN: seat belts (October 2012); motor (September 2004); fifth wheel assembly (July 2004); engine and engine cooling (February 2004) and more. Recall repairs are free at any authorized dealer. Enter your VIN at nhtsa.gov/recalls to see whether yours has been fixed.
How many complaints has the 2002 Volvo VN had?
None have been filed with NHTSA so far.
Is the 2002 Volvo VN a reliable vehicle?
Its Safety Index is 42 out of 100 (grade C: about as many problems as a typical Volvo VN year, for its age). The index weighs complaints, crashes, fires, injuries, deaths and recalls against how long the vehicle has been on the road, compared with the same model's other years. It is not a measure of every repair - read the complaints and owner experiences, and have any used vehicle inspected before you buy.
Which Volvo VN years have the most complaints?
2003 (3), 2007 (3), 2005 (2). See every Volvo VN year compared.
What should I do if my 2002 Volvo VN has a problem?
If it is a safety problem, stop driving it if it is unsafe and contact your dealer. Report it to NHTSA at nhtsa.gov/report-a-safety-problem - enough reports start investigations and recalls - and share your experience here so other owners know what to look for.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data