- The problem
- Certain replacement k&n fuel performance kits, p/nos. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, And 57-1530. Also, a small percentage of these kits were sold under the mopar performance parts brand name (p/nos. P5007069 and p5007070). All kits were manufactured from april 20, 1999, through september 23, 2004. These assemblies were manufactured as replacement equipment for certain dodge pickup trucks and suvs. A small piece of material from the tube wall could be sucked into the engine throttle body, which could cause the throttle to become jammed in the open position.
- The risk
- A jammed open throttle could cause unintended acceleration of the vehicle, possibly resulting in a crash or increased stoping distances when braking.
- The fix
- K&n will provide owners with a free repair kit along with repair instructions. The recall began on april 20, 2006.
Engine & cooling
2003 Dodge Dakota Engine problems
Owners have filed 35 complaints about the 2003 Dodge Dakota's engine & cooling with NHTSA - 12% of all its complaints, most recently on December 9, 2017. Stalling, loss of power, oil consumption, overheating, head gaskets, timing chains and engine failure.
- Complaints
- 35
- Recalls
- 1
- Crashes
- 0
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
Engine recalls for the 2003 Dodge Dakota
Engine complaints
Over a period of time I gradually noticed exhaust gas coming into the cab. I had no idea why I was getting a headache and becoming exhausted. I took the truck into a dealer and he found exhaust manifold bolts broken allowing exhaust gas to escape through the gaskets.
2003 Dodge dakota. Consumer writes in regards to dealership unable to diagnose and repair engine stalling problems. *Smd after having a computer update performed, the vehicle continued to stall. *Jb
Tl* the contact owns a 2003 dodge dakota. The contact stated that the windshield wipers failed and the exterior lighting sporadically malfunctioned. Also, the side cap to the main radiator spewed antifreeze approximately five feet in the air. The contact shut off the vehicle. The vehicle was not diagnosed or repaired. The manufacturer and dealer were made aware of the failure. In addition, while driving at a low speed, a loud popping sound emitted from the vehicle. After inspecting the vehicle, the contact noticed...
Read the full complaint
that the ball joint fractured. The contact was made aware that the vin was not included in nhtsa campaign number: 04v596000 (suspension). The vehicle was towed to the contact's residence where he performed the repair. The failure mileage was 220,000.
I have owned a 2003 dodge dakota v6 for the past 3 years and never had a problem until I took it to the dealership in union city ga yesterday for a routine oil change. After waiting 2 hours, they told me they were having a problem getting oil in the engine because there was sludge in the engine which was causing the oil to go in slowly. They recommended adding an oil additive. An hour later they returned my car to me. I started driving out of the lot my car was running rough. Two blocks later the oil light came...
Read the full complaint
on, engine started a little ticking and ran rougher. I turned around, driving about 5 mph, barely made it back to the dealership. They said there was 6 qt of oil in the engine. They would have to start over. Half hour later, they came out and said now they had no oil pressure at all and they would had to remove the oil pan and maybe have to replace the oil plump and other parts. I may need a new engine or have it rebuilt. They would call me today and let me know. Mind you, I have never had a problem until they did the oil change this time. Now that I check the computer, I find hundreds of people have a problem with sludge and loss of oil pressure in the dodge dakota for no reason. This is very dangerous. All of a sudden there is no oil pressure while you are driving. *Tr
Tl* the contact owns a 2003 dodge dakota. The contact stated that the vehicle stalled intermittently, without warning. The vehicle was taken to a local mechanic several times for the failure. The mechanic was unable to diagnose the failure. The local mechanic replaced the spark plugs and the o2 sensors, but the failure was not corrected. The vehicle continued to stall intermittently. The manufacturer was made aware of the failure. The failure mileage was 90,000 and the current mileage was 135,000. The vin information was not available.
Original owner of a 2003 dodge dakota quad cab 4.7L v-8. It experienced sudden loss of oil pressure and catastrophic engine failure. Vehicle had only 60,745 miles on odometer, it should have been covered by chrysler's 7yr/70,000 mile powertrain warranty but chrysler refused to cover as with all the other similar complaints. How many of these engines have to fail before the government protects the consumer? This oil pump failure is a well known problem with chrysler, but they refuse to cover any warranty claims...
Read the full complaint
for this problem. The engine is a defective design, these engines are failing at a very high rate. Speak with any engine remanufacturer and they will tell you about the design flaws of this engine and how many rebuilds they are selling to fix blown engines of consumers that have chrysler vehicles with this 4.7L engine. *Tr
Tl*the contact owns a 2003 dodge dakota quad cab. The contact stated that the radiator in the vehicle failed. He went to thompson chrysler and dodge and had the vehicle repaired; however, he was not satisfied with the repairs. The radiator still leaks fluid and the contact would just like his vehicle repaired properly. The vin was not included in the recall. The nhtsa campaign id number and vin were unknown. The current mileage was 88,000 and failure mileage was 82,000.
Tl*the contact owns a 2003 dodge dakota quad cab. Whenever the brake pedal was applied, the brakes would pulsate, overheat, and lock up. The stopping distance would also increase. The dealer stated that wet conditions and high speed braking caused the rotors to warp. In addition, the vehicle idles high and roughly when approaching a stop sign or traffic light. When accelerating from a stop or merging into traffic, the vehicle would idle roughly. There was no throttle response for approximately 10 to 20...
Read the full complaint
seconds, but then the vehicle would surge forward. The vehicle has been taken to a dealer approximately five times for these issues, but the failures still persist. All the sensors were replaced, but the failure is becoming worse. The dealer replaced the front rotors three times and the contact replaced them four times. The current mileage was 132,655 and failure mileage was 5,000. Updated 11/06/08. *Lj the rotors and brakes were replaced several times. The consumer was told the vehicle had a faulty master cylinder that was not letting the rear brakes ever work. The air conditioner was built to drain into the front passenger floor. The computer in the vehicle would not accept updates. The intermediate shaft was replaced. The wiper motor was replaced. Updated 11/06/08. *Jb
Replace exhaust manifold gaskets, screws and studs on right and left sides of engine. *Tr
Dt*: the contact stated while driving 60 mph on the highway, there was a loss of all oil pressure without warning. The vehicle was inspected by a dealer, who determined the oil pump failed, and the engine needed to be replaced. The manufacturer was not alerted.
Oil gauge dropped to 0 while driving. Stopped to check the oil and it was fine. Drove about 3 miles and the truck died. Every thing locked up and unable to start again. Towed it to the mechanics and he said that we had sludge. We changed the oil as recommended. The warranty said that they will not cover buying a new engine because it was our fault. I have the receipts to prove that we did the oil changes. They had poor customer service. What's the sense of getting the extended warranty if it won't help. Our truck has 50,000 miles. *Jb
Oil pressure dropped within seconds, within 8 minutes engine died, couldn't start up again. Oil level was fine, did the oil changes prior to this when it was recommended. Chrysler stated that the warranty did not cover this. Oil sludge. Others have gone through the same thing. *Jb
On june 5, 2006 the engine light came on in our 2003 dodge dakota (approx. 25,500 Miles). We took it to the dodge dealership and they replaced a hose for the fuel line at a cost of approx. $250. On june 7, 2006 the engine light again came on and dodge said an o2 sensor needed to be replaced (at a cost to us of approx. $300). With in the next 3 weeks our dodge was in the shop 2 more times (for a total of 4 items in a month) due to the engine light coming on. The last time they told us the o2 sensor that was replaced...
Read the full complaint
was faulty and was the problem. This concerns me as the car was 5 weeks over the 3 year warranty so nothing was covered and the service we received at dodge was the worst I have ever received. *Nm
Email fm mr. Robin suggs (nc) re an oil consumption problem with her 2003 dodge dakota pick up truck.*Mr the dealer told the consumer the vehicle consumes about 2 quarts of oil every 3,000 miles. The manufacturer stated it was normal. The emergency brake handle needed to be repaired, however, the consumer was told it was a cosmetic defect and was not covered under warranty. *Jb
A loud clanking noise was heard coming from the front the clutch popped out. Consumer had the vehicle towed to the dealer, and mechanic determined that the 02 sensor blew a hole inside of the clutch and needed replacement. *Ak......*Ak
Two weeks after purchasing the vehicle and upon making a right turn there was a loss of power. Vehicle continued to run, but the vehicle would not move. This has happened four times. Also, check engine light illuminateed, and evaporation leaked. Took vehicle to the dealer, but problem recurred. *Ak
While driving down the road my engine lost oil pressure and I had it towed from the spot. Now I need to have dodge dealer look at it.*Ak
I have a light knocking in my engine. The first time I took it to the dealer, they stated there was something wrong with the engine, but unable to indentify the problem. I took it back again. They had it for 3 days, and said there was nothing wrong with it. They say all dodge engines make that noise. Unknown to them, I have 2 and my other does not make the same noise. It has occasionally stalled both backing up and going forward. There is a pulling to the right even after having it aligned and balanced. It...
Read the full complaint
does not shift properly and won't stay in cruise control while climbing a hill. Also my oil hose was loose causing a rattling under the hood. The light showing you the gear your in did not work properly. Over all the worse vehicle I have ever owned with a hefty tag.
Various problems with 2003 dodge dakota. *Mr there were backfires at times, the pedal would barely move at stop signs, when backing out, the vehicle would stay in second gear for a long period of time and the consumer would have to let off of the gas pedal then shift into high gear, sometimes the vehicle wouldn't shift into overdrive, then as soon as it started to misfire, the vehicle would drop to overdrive, the cruise control was inoperative, there was a whine and or howl in the rear differential around 50...
Read the full complaint
mph, the engine light would never come on, sometimes the shift lever would be placed in park and the vehicle would start, at times when shifting to reverse or drive, the vehicle would not move and the would have to be jerked around on the shift lever, the heater controls were inoperative, and there were noises when the lights on the radio were turned on. The valve on the transmission was change and helped the vehicle, but sometimes when the vehicle was shifted up or down in gear it would be a problem. *Sc *jb
Vehicle stalled when driven at 50 mph or greater. *Ak the consumer stated the problem occurred at least 4 times. *Jb
At certain times the engine omits a high pitch whistle when driving. The noise comes and goes periodically and at different speeds. *Jb
When the truck is started and put into drive it hesitates then shifts really hard. Also when the truck is started and allowed to warm up for around three minutes it dies when it is put in reverse. When it does this none of the lights on the instrument panel come on. The truck just dies. I have had the truck into the dealership four times now. The first time I took it in, the dealership told me that they couldn't get the problem to replicate and told me to bring it back when it got worse. I am now on my forth...
Read the full complaint
attempt to get the problem fixed and they are continuing to tell me that they can't get the problem to replicate. So I went to the dealership and replicated the problem for them. That was on 10-27-03. It is now 11-06-03 and they called me today to tell me that they still can't get the truck to replicate. But they have hooked up a "co-pilot" which will read the trucks computer and hopefully catch the problem. I am having a really hard time believing that they can't replicate the problem. I have had the truck for three months now and the [[redacted]] thing has died every single time I have put it in reverse. I am positive that I am being bent over. I know that I will never buy another chrysler again. Information redacted pursuant to the freedom of information act (foia), 5 u.S.C. 552(B)(6). *Tr
Transmission will not shift from 2nd to 3rd gear when climbing grades. Also truck will stall out with no warning or check engine lights.
As truck pulls out (1-5min.)It slows down and backfires real loud. Doesnt stall out, but no power. When you step on the gas nothing happens it still is crawling around 5mi.This will happen about 1-3mminutes then it automatically picks up by itself and resumes speed. Happening every 2wks then every wk. Sometimes a day apart.Had co-pilot on twice but results were o. Nothing shows on the dashboard when it happend, but the backfiring is getting louder. Called consumer around 5 times but I am right where I started.
Peeling paint from front grille assembly. Also at 10600 miles the transmission shifts hard. Both upshifts and downshifts cause a noise and a slight hesitation, followed by a very harsh shift. And the engine seems to engage the electric heat/exchanger fan assembly causing a tremendous amount of cab noise. No temperature change has been detected with the dash gauges when the electric radiator has engaged. Very noisy. There will be a follow up letter after the truck is taken to the dealer. Oct. 5Th, 2003. 2:30 Pm mst
Dodge Dakota engine complaints by year
Dakota engine problems, every yearSource: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data