- The problem
- Chrysler (FCA US LLC) is recalling certain model year 2011-2015 Dodge Journey vehicles manufactured July 19, 2010, to May 26, 2015 and equipped with 2.4L engines. In the affected vehicles, the engine cover may detach from the engine and contact the exhaust manifold.
- The risk
- If the displaced engine cover contacts the exhaust manifold, there would be an increased risk of a vehicle fire.
- The fix
- Chrysler will notify owners, and dealers will install an improved mounting system for the engine cover, free of charge. The recall began on October 15, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R32.
Engine & cooling
2012 Dodge Journey Engine problems
Owners have filed 105 complaints about the 2012 Dodge Journey's engine & cooling with NHTSA - 28% of all its complaints, most recently on July 1, 2026. They describe 1 crash, 8 fires and 3 injuries. Stalling, loss of power, oil consumption, overheating, head gaskets, timing chains and engine failure.
- Complaints
- 105
- Recalls
- 2
- Crashes
- 1
- Fires
- 8
- Injuries
- 3
- Deaths
- 0
Engine recalls for the 2012 Dodge Journey
- The problem
- Chrysler is recalling certain model year 2012 chrysler vehicles, including 200 and town and country models, dodge vehicles, including charger, durango, grand caravan and journey models and jeep grand cherokee vehicles manufactured from august 31, 2011, through september 13, 2011, that are equipped with 3.6L engines. These engines may experience connecting rod bearing failure due to debris inside the engine block.
- The risk
- Connecting rod failure may lead to engine seizure which may increase the risk of a crash.
- The fix
- Chrysler will notify owners and replace the engine free of charge. The safety recall is expected to begin on or about november 18, 2011. Owners may contact chrysler at 1-800-853-1403.
Engine complaints
The contact owns a 2012 Dodge Journey. The contact stated that while driving at an undisclosed speed, there was white smoke coming from the vehicle, with the check engine warning light illuminated. The contact stated that the vehicle failed to accelerate above 20 MPH while driving. The vehicle was taken to the local dealer and was diagnosed with catalytic converter failure. The contact was informed that the catalytic converter needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 175,589.
No compression head gasket prob not running hot or water being used but cylinder test shows no compression and combustion leak detector test shows leak
The contact owned a 2012 Dodge Journey. The contact stated that upon her daughter starting the vehicle, an abnormal popping noise was emitted from the vehicle without warning. The vehicle caught fire as the contact's daughter exited the vehicle. The fire department was called to the scene of the incident, where they extinguished the fire. No injuries were reported, and a police report was not filed. A corner of the contact's home caught fire, melting the home's siding. Two other vehicles also caught fire, which...
Read the full complaint
melted the front ends of those vehicles. The vehicle was towed to an independent tow yard, where the vehicle was destroyed. Neither the dealer nor the manufacturer had yet been notified of the failure. Upon investigation, the contact discovered that there was a recall on the vehicle for NHTSA Campaign Number: 15V431000(Engine and Engine Cooling). The failure mileage was unknown.
Well I don't know I bought my car from extreme Auto I don't know if he is paying the police off or what to exchange cars or vin numbers but my vehicle has a few of the recalls that are still rolling on the ABS light is coming on the engine Department a few other things that I could not get fixed and they said that it wasn't part of the recall that airbag shelf which is works with the blinkers also because when I had an inspected they had informed me of that previously and there wanting us to get into accident and...
Read the full complaint
say that I was driving crazy and basically get away with it and that's what the police does undercover cops use it vehicle similar to mine and I seen it at Johnson County Police Department and I think they lied I had an inspection done and Merriam Auto and it's on file and I would need to go pick that one up that was the first one that I had got done and it should still be in the system and and they paid her off because she no longer works there anymore they refuse to fix it and I paid extreme money for the prior inspections to this one and I also have a contract that I paid $475 to get an oil panel and engine oil cover gaskets put on it purchase the parts off of Amazon in the oil panel he purchased it I don't know why this b**** you want to f*** with me my kids are gone and that was a second opinion they also pulled my vehicle over and ran my VIN number and that is on my kids and my life and my soul the detective said I don't have alternative email
Component/System That Failed or Malfunctioned & Availability for Inspection I have experienced multiple safety-critical failures in my 2012 Dodge Journey, including transmission failure, catalytic converter defects, engine repairs, electrical malfunctions, and brake system issues. Pattern of Recalls Across Dodge Journey Models & Lack of Recall for My Vehicle There have been numerous recalls across multiple model years (2009-2020) for the exact same failures my vehicle is experiencing, including: Transmission...
Read the full complaint
failures and defects Engine problems requiring major repairs Catalytic converter and exhaust failures Brake system failures and premature caliper wear Electrical malfunctions affecting windows, wiring, and power systems Despite this clear pattern of defects in Dodge Journey models, my specific vehicle has not been recalled for these issues. Dodge/Stellantis needs to explain why these defects are not being covered under existing recalls when the same problems have been recognized in other model years. How My Safety & Others' Safety Was Put at Risk 1. Transmission Failure & Unsafe Driving Conditions My transmission failed completely, causing high RPM revving, and loss of acceleration. My vehicle essentially stalled out on the highway. Now, the transmission requires a full rebuild costing over $5,238.64. Dodge has issued recalls for transmission defects in other Journey model years, but mine is excluded despite experiencing identical failures. 2. Engine Repairs & Performance Failures My vehicle has required major engine repairs, including: Camshaft and rocker arm replacements Ignition coil replacements Thermostat and cooling system repairs Dodge has issued engine-related recalls for other Journey models, including crankshaft/camshaft sensor failures, engine stalling, and overheating risks. My vehicle suffers from the same defects but has not been recalled. These engine issues pose a major safety hazard by increasing the risk of engine stalling, loss of power, and
Engine problems
We've owned this vehiclenot even 4 years. It had an engine recall that it was part of. It says it was repaired, however it never recieved a new engine. Now I just spent $9,000+ to replace the entire engine because of the exact issue of the recall: metal fragments in the engine. Why did I pay for this recall problem? Did dodge replace the engine during the recall? Paperwork says no, but shows it was "repaired". If it was replaced, why did I replace it again for the exact same issue? Dodge has financially...
Read the full complaint
ruined our family. Besides this $9k we've spent $6k on engine work before the new engine, $4,500 on transmission work (with more to come as we're currently experiencing transmission issues) and $6k + on all kinds of issues that has never occurred on any vehicles I have owned in the last 30 years. And we've spent all this in under 4 years. This is unacceptable! For an american auto maker to produce and sell vehicles like this. This is why we people buy foreign. This dodge IS NOT a well built, trustworthy and dependable car. You won't believe how many times we've had to miss school and work because the car was broken down or being repaired. Our Honda civic was 20 years old, ran better and was 100% dependable. I never had to replace the engine, do ANY transmission work or have had half the problems with my civic than I have had and currently have with this "american" car that is only 11 years old. As a 1 income family with 2 kids in college and one still in high school, this is completely devastating to us. Trying to save money and get ahead and ALL OF IT has been spent fixing this vehicle. Dodge has completely devastated our family. How can an American auto maker be allowed to get away with producing vehicles like this? Why should I have to go bankrupt owning a dodge? Why won't they accept responsibility for their defective product? I've spent $25,000 fixing this dodge in 4 years. I can't afford to fix it or buy a new car. We're ruined
Airbag light is on. P06DD Engine oil pressure control circuit performance /stuck off
The car shifts super hard into second gear. The inside smells like the car is over heating,driving down the interstate the car losses power,you can push your foot to the floor and nothing,the car will not excelerate at all.It's extremely dangerous. You have to pull over turn the car off and then on again to get it to go. This happens about every 20 minutes or so,the heat only works in the driver vent and the smell gives you a headache and makes you sick to your stomach. The vehicle is not safe at all. The catalytic converter gives gas off into the cabin.
On vehicles with the 3.6l Pentastar engine, the oil pump fails before 150,000 miles causing DTC P06DD to trip which instantly puts the vehicle into "Limp Mode". This immediately cuts down the power to the engine which slows everything down potentially causing you to be hit by other traffic. It also causes a hefty repair bill. This is a very common issue known to the repair shops and dealers. My family has a 2012 Dodge Journey with this engine. A local and well known mechanic shop performed extensive diagnostics...
Read the full complaint
and confirmed this issue. The repair took hours to complete. The repair shop did replace other parts that could potentially cause this problem, however, it did not resolve the issue. There were/are no warning signs; simply the engine light comes on and the vehicle goes straight into limp mode with immediate decline in power.
Oil filter housing broken internally
The crankshaft position sensor as well as a oil leak from the motor and has intermittent start delays these failures I found on this sight that affects my vehicle make & model year my engine 3.6 when I accelerate the overdrive doesn't engage and i took it to Nyle Maxwell in San Antonio where it's at now I also have the diagnosis that matches what is posted here on this site & 3 open recalls that suggest other years may be affected.
Engine shut off and wouldn't start up again
The contact owns a 2012 Dodge Journey. The contact stated that while driving at an undisclosed speed, the ABS warning light and the traction control warning lights were illuminated. The vehicle was taken to the dealer, where the driver's side wheel sensor, the passenger's side wheel sensor, and the crank position sensor were replaced; however, the failure recurred. The contact related the failure to NHTSA Campaign Number: 15V675000 (Electronic Stability Control, Service Brakes, Hydraulic). The vehicle was taken to...
Read the full complaint
a second dealer, Darcars Orange Park Chrysler Dodge Jeep Ram (7233 Blanding Blvd, Jacksonville, FL 32244) for recall repair; however, the VIN was not included. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 80,000.
The clvehicke will stall at slow motion and on highway dash lights will flicker and eventually shut off ... only thing that helps is to wiggle the wiring harness until dash comes back on
What component or system failed or malfunctioned, and is it available for inspection upon request? The check engine light came on a few days ago and now the battery light came on. The right headlight has condensation in it and the heat slowly has gone out across the front panel. The touch screen sometimes works but sometimes malfunctions. I have to get my car changed from Michigan to Virginia and it will require an inspection How was your safety or the safety of others put at risk? The car slows down or...
Read the full complaint
electrical goes wired while I'm the car and I have 2 children under the age of 2. So if it catches fire due to an electrical problem or the engine fails while driving because of the check engine light or battery light it could cause a serious problem Has the problem been reproduced or confirmed by a dealer or independent service center? No Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No they just started a few days ago the check engine light came on and now the battery light came on. It's been a great car but I'm not sure what's happening now because it's nothing I did.
The contact owns a 2012 Dodge Journey. The contact stated while driving approximately 25 MPH, the vehicle started to jerk. In addition, when the brake pedal was depressed it traveled to the floorboard. There was also a failure with the electric stability control failure; in addition to the headlights, visibility was dim. There were no warning lights illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 76, 200
The contact owns a 2012 Dodge Journey. The contact stated while driving 40 MPH, the vehicle inadvertently decelerated to 20 MPH. The contact stated that several unknown warning lights were illuminated. The vehicle was taken to the dealer where it was purchased to be diagnosed. The contact was informed that the head gasket and throttle body had failed. The contact stated that the vehicle was repaired however, the failure recurred while driving. The vehicle was taken back to the dealer and it was determined that the...
Read the full complaint
throttle body had failed and needed to be replaced. The dealer towed the vehicle to an unknown authorized Dodge dealer who repaired the vehicle however, the failure persisted. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 126,000.
As I am drive my car will slow down almost as if it's gonna shut off then began to rev up and feel as if it's jumps back into gear. I been looking through issues with this car and I see the transmission solenoid has been a problem. Seems as if this is the issue with my vehicle.
Vehicle stalls intermittently, when coming to a stop at a light or Stop Sign.This has occurred on multiple occasions and could result in serious injury or Death. The latest date was yesterday May 31,2021.
Vehicle turns off while driving without warning, even at full speed. This happens while I am drving anywhere including the highway
Engine light multiple times- emissions control - found online but did not receive a recall: in affected cars, fca will replace the catalytic converter and update software for the powertrain control module — that is, your car’s primary drivetrain computer. Fca will recycle the old catalytic converter to remove the precious metals common in such devices, a usual practice. “Obviously the catalytic converter, that’s the biggest part of this,” chernoby said. The replacement converter has a...
Read the full complaint
“different mixture of precious metals … to be less susceptible to sulfur in the fuel,” he added. Due to the number of replacement catalytic converters needed, the automaker is recalling cars in waves. Model-year 2011 cars: first quarter of 2019 model-year 2012 cars chrysler's number for this recall is t47 chrysler's number for this recall is s08 chrysler's number for this recall is r61 chrysler's number for this recall is r32
My car is throwing off a check engine light an it indicates it's my catalytic converter, my engine has an knocking sound also, and when I apply pressure on my brakes there's a delay of stopping. While I'm driving city/highway.
Nhtsa id number:11258769 engine light multiple times- emissions control - found online but did not receive a recall: in affected cars, fca will replace the catalytic converter and update software for the powertrain control module — that is, your car’s primary drivetrain computer. Fca will recycle the old catalytic converter to remove the precious metals common in such devices, a usual practice. “Obviously the catalytic converter, that’s the biggest part of this,” chernoby said. The...
Read the full complaint
replacement converter has a “different mixture of precious metals … to be less susceptible to sulfur in the fuel,” he added. Due to the number of replacement catalytic converters needed, the automaker is recalling cars in waves. Model-year 2011 cars: first quarter of 2019 model-year 2012 cars: second quarter of 2019 model-year 2013-14 cars: third quarter of 2019 model-year 2015-16 cars: fourth quarter of 2019
Over heating and running hotter than usual. Unusual smell from engine when accelerating quickly. Popping when making sharp turns. Air conditioner turning on and off or up and down randonly
Dodge Journey engine complaints by year
Journey engine problems, every yearSource: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data